processing induced changes in phenolic concentration and antioxidant capacity of corn ... · 2018....
TRANSCRIPT
PROCESSING INDUCED CHANGES IN PHENOLIC CONCENTRATION AND
ANTIOXIDANT CAPACITY OF CORN FOR PRODUCTION OF CORN FLAKES
BY
ZHOU ZHONG
THESIS
Submitted in partial fulfillment of the requirements
for the degree of Master of Science in Food Science and Human Nutrition
with a concentration in Food Science
in the Graduate College of the
University of Illinois at Urbana-Champaign, 2015
Urbana, Illinois
Master’s Committee:
Professor Nicki Engeseth, Chair
Associate Professor Martin Bohn
Associate Professor Kent Rausch
ii
ABSTRACT
Epidemiological studies have suggested that regular consumption of breakfast cereals would
help in reducing the risk of obesity and cardiovascular disease. However, average nutritional
quality of ready-to-eat breakfast cereals have been declining since late the 1980s. This study was
designed to examine how phenolics and antioxidant capacity change during processing of corn
into flakes, and to evaluate the effects of processing condition, corn genotype, and growing year
on phenolics, with the ultimate goal of improving the nutritional quality of corn flakes. Three
commercial corn hybrids grown in three different years with three replicates per year were dry-
milled, cooked, baked, and toasted into corn flakes to determine the impact on phenolic content
and antioxidant capacity. Genotype and processing effects were significant for phenolics, while
the yearly effect was not. Cooking and toasting were the two critical processing points to induce
phenolic changes. Total phenolic content significantly decreased during cooking, and
significantly increased again during toasting. Significant losses of antioxidant capacity were
observed during dry-milling and pressure cooking. Baking and toasting did not further alter the
antioxidant capacity of corn. Significant linear correlations were observed between antioxidant
capacity and phenolics in corn, while a higher correlation was observed for bound phenolics
rather than soluble phenolics. Total phenolic content of corn was enhanced with higher cooking
pressure, but decreased with extended pressure cooking time. Increased baking time and
temperature both induced significant increases in phenolics. Extended toasting time could also
liberate more bound phenolic compounds to increase total phenolic content, but higher toasting
temperature did not facilitate in faster liberation. Our findings will provide a guide to optimize
processing conditions and select proper corn hybrids for higher phenolic content and antioxidant
capacity in corn flakes.
iii
ACKNOWLEDGEMENTS
This thesis could not be down without all the help and guidance provided by my advisor, Dr.
Nicki Engeseth. She is so kind and always willing to provide generous help whenever I meet
problems in my research project or in my life. She lets me know what a good scientific
researcher is and helps me to develop skills to become a scientific researcher. I really appreciate
all her patient modifications and valuable suggestions for this thesis. It is my great fortune and
pleasure to work with her.
I also would like to thank my committee members, Dr. Martin Bohn and Dr. Kent Rausch for
their suggestions and guidance. Dr. Martin Bohn generously provided the corn samples needed
in this project, and I appreciate this. Dr. Kent Rausch is so nice that he always responds quickly
when I need him.
I want to thank Gurshagan, Nicole, and Carrie, who work with me in the Kellogg’s project.
Thanks Gurshagan for sharing the processing method to produce corn flakes, thanks Nicole for
providing me all the equipment and ingredients needed in flaking, and thanks Carrie for
packaging the corn samples and sending them to me. It is impossible for me to finish my
research without their effort and help.
Many thanks also to my labmates Jeff, Ziyi, and Eliana. Jeff was always willing to help when
I was in trouble. If I had some confusion in my research and looked for his help, he always tried
to answer it for me patiently. Ziyi assisted me in the ORAC assays for antioxidant capacity of
corn and I appreciate that.
I am so fortunate to meet a group of best friends in Champaign. I feel like we are a big family.
My two-year life in Champaign cannot be so colorful without them. Special thanks are due to
Haiqing, who always stands behind me and provides support and assistance when I am in need.
iv
Finally, I would like to thank my parents for supporting me to study abroad. They are always
my strong backing when I come across any difficulties, giving me warm words and encouraging
me to pursue what I want. Their love and faith in me are my motivation to keep walking forward.
v
TABLE OF CONTENTS
INTRODUCTION………………………………………………………………………………...1
CHAPTER 1: LITERATURE REVIEW………………………………………………………….3
1.1. Corn – As a Major Component of Human Diet………………………..……………….3
1.2. Lipid Oxidation and Natural Antioxidants.…................................................................10
CHAPTER 2: PHENOLIC CONTENT OF CORN AS AFFECTED BY GENOTYPE,
GROWTH YEAR, AND CORN FLAKE PROCESSING STAGES………………………....…28
2.1. Introduction…................................................................................................................28
2.2. Materials and Methods………………………………………………………..…….…29
2.3. Results…………………………………………………………....................................32
2.4. Discussion.......................................................................................................................35
2.5. Tables.............................................................................................................................42
2.6. Figures…........................................................................................................................48
CHAPTER 3: ANTIOXIDANT CAPACITY OF CORN AS AFFECTED BY GROWTH YEAR
AND CORN FLAKE PROCESSING STAGES.…………………………………………...........54
3.1. Introduction……………………………………..………………………......................54
3.2. Materials and Methods…………………………………………..…….........................55
3.3. Results…...………………..…..………………..……...................................................57
3.4. Discussion.……...……………………………….…......................................................59
3.5. Tables..…………………………………………...………..…………...........................64
3.6. Figures………………………………………………………..………..........................65
CHAPTER 4: EFFECT OF PROCESSING CONDITIONS ON THE PHENOLIC CONTENT
OF CORN FOR PRODUCTION OF CORN FLAKES.…………………………........................66
4.1. Introduction.…...………..…………………………………………………..................66
4.2. Materials and Methods.…….…………………………………………….....................67
4.3. Results…………..……………………………………………………..........................68
4.4. Discussion……..………………………………………………………........................74
vi
4.5. Tables…………….……………...………………..…………………...........................81
4.6. Figures………………………………..………………………………..........................83
CHAPTER 5: CONCLUSIONS AND FUTURE STUDIES.........................................................86
5.1. Conclusions………..……..……...……………………………………….....................86
5.2. Recommendations for Future Studies………………………..…………………..……88
BIBLIOGRAPHY.…………………………….…………………………………........................90
APPENDIX A. ANALYSIS OF VARIANCE FOR MOISTURE CONTENT, PHENOLICS,
AND ANTIOXIDANT CAPACITY OF CORN HYBRIDS GROWN IN THREE YEARS AT
FIVE PROCESSING STAGES……….……………………………………..............................118
1
INTRODUCTION
Corn (Zea Mays) is one of the most widely cultivated crops all over the world, whose global
production is higher than rice and wheat (Chaudhary et al., 2014). Epidemiological studies
suggest that regular consumption of breakfast, especially cereals, would help in reducing the
risks of obesity and cardiovascular disease (Geliebter et al., 2015). Corn flakes are a major kind
of ready-to-eat breakfast cereals with various nutrients, which are popular worldwide. However,
the average nutritional quality of ready-to-eat breakfast cereals has declined in the market since
the late 1980s. A database which monitored the nutritional profiles of over 150 top cereal brands
indicated a 16% decrease in nutritional quality of cereals produced in 2011, compared to 1988
(Wang et al., 2015). Hence, it is necessary to improve the nutritional value of ready-to-eat corn
flakes to meet the nutritional needs of consumers.
Apart from providing macro- and micro-nutrients in daily diets, corn also acts as an abundant
source of bioactive compounds, most of which possess antioxidant activity to enhance human
health. Major antioxidants in corn include carotenoids (Kurilich & Juvik, 1999; Kopsell et al.,
2009), phytosterols (Piironen et al., 2000; Yoshida & Niki, 2003), tocopherols (Kurilich & Juvik,
1999), ascorbic acid (Dewanto et.al., 2002), anthocyanins (Li et al., 2008; Pedreschi & Cisneros-
Zevallos, 2007), and other phenolic compounds (Pedreschi & Cisneros-Zevallos, 2007; Ramos-
Escudero et al., 2012). Phenolics were cited as the major contributors to antioxidant capacity in
corn (Velioglu et al., 1998; Adom & Liu, 2002; Hu & Xu, 2011). According to Adom & Liu
(2002), phenolic content of corn was higher than in rice, wheat, and oats. Phenolics provide a
wide variety of potential health-enhancing functions, such as antimutagenic activity (Cardador-
Martínez, 2002; Pedreschi & Cisneros-Zevallos, 2006), anticarcinogenic property (Owen et al.,
2000), anti-inflammatory effects (Jiang & Dusting, 2003), microbial inhibition (Nohynek et al.,
2
2006), and prevention of coronary heart disease (Morton et al., 2000). Therefore, enhancing
phenolic contents and antioxidant activities is important in improving the overall nutritional
quality of corn flakes.
Few studies have focused on the phenolic compounds and antioxidant activity of corn flakes,
while several studies have been conducted on the nutritional values of oat, rye, wheat, and
parsley flakes (Ewaidah & Alkahtani, 1992; Luthria, 2008; Sumczynski et al., 2015). Previous
studies examined the effect of processing on phenolics and antioxidant capacity in corn
(Dewanto et al., 2002; Parra et al., 2007; Lopez-Martinez, 2012; Harakotr et al., 2014). Dewanto
et al. (2002) indicated that cooking significantly elevated the free phenolic content and
antioxidant capacity in sweet corn. However, phenolics and antioxidant capacity in corn were
significantly reduced during processing for production of masa, tortillas, and tortilla chips (Parra
et al., 2007). More information is needed on the effect of the corn-flaking process on phenolics
and antioxidant capacity of corn.
Hence, the objectives of this study were to examine how phenolics and antioxidant capacity
change during the corn-flaking procedure and to evaluate the effects of processing conditions on
phenolics, with the goal of improving the nutritional quality of corn flakes. Three commercially
available corn hybrids grown in three years were used to investigate how genotype and growing
year influence phenolics and antioxidant capacity in corn during processing. The hypotheses of
this research are that processing will impact on phenolic concentration and antioxidant capacity
of corn, and corn flakes with higher phenolic content can be obtained with optimized processing
conditions. Since phenolic compounds may be disrupted under thermal treatment, we would
expect lowered antioxidant capacity of corn after flaking. Higher pressure and temperature with
extended treatment time may help to liberate more phenolics in corn.
3
CHAPTER 1: LITERATURE REVIEW
1.1. Corn – As a Major Component of the Human Diet
Corn (Zea Mays) is one of the most widely cultivated crops, providing foods for majority of
the population worldwide; corn provides multiple nutrients, as well as a variety of bioactive
phytochemicals that are beneficial to health. There are multiple varieties of corn. Among them,
white and yellow kernel corn are the most common species, while other pigmented corn such as
multicolored, black, red, purple, and blue corn are only produced in small amounts for some
specific foods or for decoration (Abdel-Aal et al., 2006; Žilić et al., 2012). Corn composition,
concentration of potentially-bioactive components, and other properties are greatly affected by
corn varieties and growing conditions (Lopez-Martinez, 2009; Luo & Wang, 2012).
1.1.1. Structure and Components of Corn Kernel
The corn kernel is comprised of the tip cap, pericarp, germ, and endosperm, with a
composition percentage of 0.8-1.0%, 5-6%, 10-11%, and 82-83%, respectively (Singh et al.,
2014). Endosperm is the largest fraction of corn kernel, which is mainly comprised of starch
(70%), protein (8-10%), and a small amount of fat (Lawton & Wilson, 1987; Prasanna et al.,
2001; Chaudhary et al., 2014). The carbohydrate content of germ (33-36 %) is relatively lower
than the other parts, but it contains high levels of protein (19%), oil (33-36 %), and ash (10%). A
high content of carbohydrate is present in pericarp (93-94%), while the contents of the other
components (3-4% protein, 0.7-0.9% oil, and 0.7-1.1% ash) are relatively low (Hopkins et al.,
1903).
4
1.1.2. Processing of Corn into Flake Products
Corn is processed into a variety of products in the food industry, among which, ready-to-eat
cereal products like corn flakes are popular. Whole kernels are first dry milled to seperate the
corn fractions of pericarp, germ and endosperm (Rausch et al., 2009). Flaking grits are then
obtained from the endosperm fraction, and are further cooked, delumped, dried and tempered,
flaked, and toasted into flakes (Fast & Caldwell, 2000).
U.S. No. 1 or No. 2 yellow dent corn is the common source for producing flaking grits
(Caldwell and Fast, 1990). To prevent the interference of fibers during processing and guarantee
consistent properties in final flake products, the pericarp fraction is removed during dry milling
(Culbertson, 2004). Germ is the part with highest oil content. Removal of germ fraction could
help prevent the final products from oxidative rancidity (Culbertson, 2004).
Formulation of corn flakes typically involves adding the ingredients of salt, sugar, and malt
syrup with water to flaking grits (Caldwell et al., 1990; Culbertson, 2004). The main objective of
adding salt in the formulation is flavor improvement. Sugar is added to increase sweetness. Malt
syrup, with its abundance of reducing sugars, proteins, and free amino acids, is of great
importance for color and flavor development induced by non-enzymatic browning (Kujawski,
1990, as cited in Culbertson, 2004). During cooking, typical reactions of starch gelatinization,
Maillard browning, Strecker degradation, and lipid oxidation will occur (Culbertson, 2004). Soft
and translucent grits with golden brown color will be obtained after complete cooking (Caldwell
& Fast, 1990; Culbertson, 2004). During tempering, retrogradation starts for the gelatinized
starch in cooked grits, resulting in increased firmness and resistance to digestion. Maillard
reaction, as well as caramelization of sugars such as sucrose will occur during toasting to further
5
generate the desired color and flavor of the final flake product. Compounds able to inhibit lipid
oxidation are also generated during toasting (Culbertson, 2004).
Limited studies exist on the phenolic compounds in corn flakes; however, significant
nutritional information is provided about oat, rye, wheat, and parsley flakes (Ewaidah &
Alkahtani, 1992; Luthria, 2008; Sumczynski et al., 2015). Hence, more research was needed that
focused on the changes of phenolics and antioxidant capacity during the corn-flaking procedure.
1.1.3. Bioactive Compounds in Corn and Their Health Benefits
Apart from providing macro- and micro-nutrients in daily diets, corn also acts as an abundant
source of bioactive compounds, including carotenoids (Kopsell et al., 2009), phytosterols
(Ostlund et al., 2002), resistant starch (Luo & Wang, 2012), and a range of phenolic compounds
(Pedreschi & Cisneros-Zevallos, 2007; Ramos-Escudero et al., 2012). These phytochemicals,
due to their specific properties, have diverse health-promoting effects in humans.
1.1.3.1. Carotenoids
Carotenoids are a family of organic pigments, including red, orange, and yellow colors (Luo
& Wang, 2012) that are located in chloroplasts and chromoplasts of plants (Žilić et al., 2012).
The yellow-orange color of corn endosperm is contributed by carotenoids, which can be split
into two classes, carotenes and xanthophylls (Panfili et al., 2004; Parra et al., 2007). Lutein,
zeaxanthin, and β-cryptoxanthin are classified as xanthophylls (Figure 1.1) and have been
identified with, α- and β-carotene (Figure 1.2) as dominant carotenoids in corn (Hu & Xu, 2011;
Panfili et al., 2004; Žilić et al., 2012). Carotenoid concentration and composition differ
significantly amongst different varieties of corn. According to a study conducted on four types of
6
waxy corn with different colors, the total carotenoid content in yellow normal corn was the
highest, followed by yellow waxy corn, black corn, and white corn, ranging from 1.24 to 39.61
μg/g dry weight (Hu & Xu, 2011). Another study of 44 sweet and dent corn lines also reported
significant variability among corn types from 0.15-33.11 μg/g dry weight (Kurilich & Juvik,
1999).
α-Carotene
β-Carotene
Figure 1.1: Structures of Major Carotenes in Corn
Carotenoids are antioxidants that play a crucial role in radical-initiated processes (Palozza &
Krinsky, 1992). Additionally, α- carotene, β-carotene, β-cryptoxanthin and other carotenoids
with at least one integrated nonoxygenated β-ionone ring also possess provitamin A activity
(Panfili et al., 2004), which means they are able to be metabolized in the gastrointestinal (GI)
tract to form vitamin A (Luo & Wang, 2012). Several epidemiological studies have linked rich
serum/adipose tissue carotenoid levels with reduced disease risk, including coronary heart
disease (Kritchevsky, 1999), lung cancer (Michaud et al., 2000), cataract development (Knekt et
al., 1992), and age-related macular degeneration (Carpentier et al., 2009), indicating that daily
consumption of carotenoids is beneficial for human health. Since human bodies are not able to
biosynthesize carotenoids (Luo & Wang, 2012), ingesting carotenoids from carotenoid-rich
7
foods such as fruits, vegetables, and whole grains is necessary. Among grains, corn has a higher
carotenoid concentration than wheat, oats and rice (Panfili et al., 2004).
Lutein
Zeaxanthin
β-Cryptoxanthin
Figure 1.2: Structures of Major Xanthophylls in Corn
1.1.3.2. Phytosterols
Phytosterols are mainly found in seeds of crops and cereals as secondary metabolites
(Bartłomiej et al., 2011). Corn oil contains more abundant phytosterols compared to the other
commonly used commercial oils (Weirauch et al., 1978). Phytosterols can be classified into three
major classes: 4-desmethylsterols, 4,4-dimethylsterols, and 4-monomethylsterols (Grunwald,
1975). Common phytosterols in corn oil such as sitosterol, stigmasterol, and campesterol (Figure
1.3) are all from the class of 4-desmethylsterols (Luo & Wang, 2012). Phytosterols in cereal
8
grains may also be conjugated with fatty acids, phenolic acids, carbohydrates, and acylated
carbohydrates (Lagarda et al., 2006; Bartłomiej et al., 2011).
β-Sitosterol Stigmasterol
Campesterol Cholesterol
Figure 1.3: Structures of Major Phytosterols in Corn Oil, Compared to Cholesterol
Ostlund et al. (2002) demonstrated the cholesterol lowering activity of dietary phytosterols in
corn oil upon consumption of physiological concentrations. Epidemiological studies also
indicated a 10% lowering effect on the low density lipoprotein (LDL) cholesterol level in human
blood serum by ingesting 1-3 g phytosterols every day (Katan et al., 2003; Lagarda et al., 2006).
The similarity of phytosterol and cholesterol structures contributes to the cholesterol-lowering
effect of phytosterols (Figure 1.3) (Luo & Wang, 2012). Phytosterols function in the intestine,
being able to inhibit cholesterol absorption and reduce LDL-cholesterol (Ling & Jones, 1995),
thus may help prevent atherosclerotic disease (Moghadasian & Frohlich, 1999; Ostlund et al.,
2002).
9
1.1.3.3. Phenolics
Phenolics are a class of compounds possessing one or more hydroxyl groups (-OH) bound
directly to one or more aromatic rings (Liu, 2004). Plant phenolic compounds are generally
classified as phenolic acids, flavonoids, tannins, and the less common categories, stilbenes and
lignans (Dai & Mumper, 2010). In corn kernels, phenolic acids and flavonoids are the most
predominant forms of phenolics (Žilić et al., 2012). According to Sen et al. (1994), free phenolic
acids and flavonoids were concentrated in pericarp, aleurone layer, and germ fractions of corn.
Žilić et al. (2012) also indicated that the total phenolic content in corn is significantly correlated
to its pericarp portion per kernel weight (R2=0.87).
Total phenolic contents of corn vary from genotype to genotype (Žilić et al., 2012). Corn
with dark colors such as red, blue and purple contain higher phenolics than light colored corn
types (Hu & Xu, 2011; Žilić et al., 2012). Growth stage is also an influencing factor on phenolic
content. During maturation, a significant decrease in total phenolic content is observed in corn
(Xu et al., 2010). Phenolic contents in corn, whether free, soluble-conjugated or insoluble bound
form, are higher than those in rice, wheat, and oats (Adom & Liu, 2002).
Phenolic compounds display a wide variety of potential health-enhancing functions, mainly
related to antimutagenic activity (Cardador-Martínez, 2002; Pedreschi & Cisneros-Zevallos,
2006), anticarcinogenicity (Owen et al., 2000), anti-inflammatory effects (Jiang & Dusting,
2003), microbial inhibition (Nohynek et al., 2006), and prevention coronary heart diseases
(Morton et al., 2000). However, it is also noted that under certain conditions, phenolic
compounds can act as pro-oxidants rather than antioxidants (Duthie et al., 2000; Morton et al.,
2000). This is achieved by chelating metals and altering their catalytic activity, thus free radical
formation is enhanced and oxidation damage is induced (Decker, 1997).
10
1.2. Lipid Oxidation and Natural Antioxidants
1.2.1. Mechanisms of Lipid Oxidation
Oxidation of polyunsaturated fatty acids in cell membranes occurs through free radical chain
reactions, by both enzymatic and auto-oxidative peroxidation (Torel et al., 1986). Chain
reactions and lipid peroxidation may become uncontrolled with an over-abundance of free
radicals, which may lead to health problems such as atherosclerosis and cancer (Cook &
Samman, 1996). The rate of lipid autoxidation depends on factors such as fatty acid composition,
degree of unsaturation, and the partial pressure of oxygen (Belitz et al., 2009). Three stages are
involved in the mechanisms of free-radical induced lipid peroxidation: initiation, propagation,
and termination (Torel et al., 1986; King et al., 1993).
Initiation: RH → R∙
Propagation: R∙ + O2 → ROO∙
ROO∙ + RH → ROOH + R∙
Termination: ROO∙ + ROO∙ → ROOR + O2
R∙ + R∙ → RR
ROO∙ + R∙ → ROOR
R∙ + H∙ → RH
In initiation, a hydrogen atom is abstracted from unsaturated fatty acids, and lipid free
radicals are formed (Cook & Samman, 1996; Frankel, 2012). The rate of initiation may be
affected by factors such as temperature, light, and metals (King et al., 1993). Lipid peroxidation
is initiated by free radicals and singlet oxygen that are generated in biological systems. Hence,
free radical scavengers or singlet oxygen quenchers may help to prevent the initiation of lipid
peroxidation (Torel et al., 1986). Initiation is followed by propagation, in which lipid radicals
11
reacts with oxygen to form peroxy radicals (ROO∙). The lipid peroxy radical is able to abstract a
hydrogen atom from a fatty acid to generate a monohydroperoxide (ROOH) and a new free lipid
radical (R∙) to propagate the chain of reaction (King et al., 1993; Cook & Samman, 1996; Belitz
et al., 2009). This hydrogen abstraction is the lowest step, which controls the rate of radical
generation (Belitz et al., 2009). Thus, it becomes selective to abstract the most weakly-bound
hydrogen in an unsaturated fatty acid (Frankel, 2012). However, with accumulation of
hydroperoxides, the reaction would accelerate and hydroperxide molecules break down into free
radicals via metals, heat, and ultraviolet light (Schaich et al., 2013). Peroxy radical scavengers
are able to break the chain reaction in propagation to inhibit lipid oxidation (Torel et al., 1986).
When the rate of radical quenching becomes faster than chain expansion, lipid free radicals tend
to generate stable non-radical products, which is the termination stage (Schaich et al., 2013).
Lipid oxidation occurring in foods will result in off-odors and flavor fade. It will also induce
membrane degradation and lipid structural changes, which may cause turgor loss and texture
degradation of foods (Schaich et al., 2013). Apart from its detrimental effects on foods, lipid
peroxidation is also related to human diseases such as cancer and atherogenesis (Frei et al., 1988).
Antioxidants can be used to limit the degree of lipid oxidation, which will be further discussed in
the following section.
1.2.2. Mechanisms of Antioxidant Activity
Free radicals are atoms, molecules or ions with one or more unpaired electrons, with the
potential to damage proteins, lipids, carbohydrates, and nucleotides (Slater, 1984; Halliwell,
1987). Such damage caused by oxidizing species are related to negative health problems such as
heart diseases (Halliwell, 1987; Tsutsui, 2011), fibrosis (Cheresh et al., 2013), reperfusion injury
12
(Zweier & Talukder, 2006), cancer and aging (Ames, 1989). Lipid peroxidation-induced damage
can be controlled by antioxidants, which interfere with free radicals. Antioxidants can be
classified into three major groups by different mechanisms of action (Schaich et al., 2013).
The most prominent group of antioxidants acts as radical scavengers. A hydrogen atom
transfer reaction can be induced by these antioxidants to scavenge free radicals as follows
(Leopoldini et al., 2004).
Hydrogen atom transfer: ROO∙ + AH → ROOH + A∙
ROO∙ + AH2 → ROOH + AH∙
AH∙ + R∙ → A + RH
The radical A∙, which is generated by this kind of chain-breaking antioxidant, is stable and
will not further propagate the radical chains (Halliwell, 1995; Schaich et al., 2013). Antioxidants
such as ascorbic acid, quinones, and some phenols can also change the reactive radicals into
unreactive ions through single electron transfer (Schaich et al., 2013), thus to quench the free
radicals.
Single electron transfer: ROO∙ + ArOH + e- → ROO
- + ArOH∙
+
ROO∙ + A - e- → ROO
+ + A
-
The second type of antioxidants acts to prevent production of free radicals rather than
scavenge them. These antioxidants function as metal chelators and complexers, being able to
block all the metal orbitals (Schaich et al., 2013). Production of free radicals is then inhibited,
with their metal catalysts chelating to the antioxidants (Duthie et al., 2000; Morton et al., 2000).
Antioxidants, particularly carotenoids are also capable of scavenging singlet oxygen to inhibit
radical production (Stahl & Sies, 2005).
13
The third type of antioxidant is related to environmental factors that can limit lipid oxidation.
If controlled properly, factors such as temperature, pH, moisture content, light, and
environmental gases can slow the rate of lipid oxidation, thus reducing the radical load (Schaich
et al., 2013).
1.2.3. Potential Antioxidants in Corn
Multiple beneficial functions are attributed to bioactive phytochemicals in corn, among
which antioxidant activity is one of the most important properties. Potential antioxidants in corn
include carotenoids (Kurilich & Juvik, 1999; Kopsell et al., 2009), phytosterols (Piironen et al.,
2000; Yoshida & Niki, 2003), tocopherols (Kurilich & Juvik, 1999), ascorbic acid (Dewanto et
al., 2002), anthocyanins (Li et al., 2008; Pedreschi & Cisneros-Zevallos, 2007), and other
phenolic compounds (Pedreschi & Cisneros-Zevallos, 2007; Ramos-Escudero et al., 2012). Corn
contains a large variety of phenolics, which are the major and most effective contributors of
antioxidant activity in corn (Velioglu et al., 1998; Hu & Xu, 2011). Hence, due to their
significant role in corn bioactivity, phenolic compounds in corn and their antioxidant capacity
will be mainly discussed in the following sections.
1.2.3.1. Phenolic Compounds in Corn
A variety of phenolic compounds have been identified in corn, among which, phenolic acids
and flavonoids are the two forms that are most common (Žilić et al., 2012).
Phenolic acids are aromatic acid compounds, which can be classified into two categories:
hydroxybenzoic acids and hydroxycinnamic acids (Figure 1.4) (Liu, 2004). Based on different
substitutions on the aromatic ring, different types of phenolic acids are obtained (Table 1.1 &
14
1.2). A majority of the phenolic acids in corn are in bound forms. According to Žilić et al. (2012),
76-91% of total ferulic and p-coumaric acids in corn are insoluble-bound. The free phenolic
acids are primarily found in the outer layer of pericarp, while the bound ones are mainly
esterified to cell wall components (Dykes & Rooney, 2007). In general, phenolic acids that have
been identified in different maize types and preparations include tannic, gallic, o-coumaric,
caffeic, vanillic, ferulic, cinnamic, protocatechuic, p-coumaric, salicylic, and chlorogenic acids
(Hu & Xu, 2011; Ramos-Escudero et al., 2012; Pandey, 2013). The composition of phenolic acid
varies among different corn varieties.
Benzoic acid Cinnamic acid
Figure 1.4: Basic Structures of Phenolic Acids (From Liu, 2004)
Phenolic acids can function as strong antioxidants, scavenging free radicals and other ROS
which are associated with some aging-related human diseases such as chronic cardiovascular
diseases and cancer (Yu et al., 2002; Yu et al., 2003; Kampa et al., 2004). Within the two
categories of phenolic acids, hydrocinnamic acids are found to possess higher antioxidant
activity than hydroxybenzoic acids; this is attributed to the CH=CH-COOH group in their
structures (White and Xing, 1997; Emmons et al., 1999; Andreasenm et al., 2001; Kim et al.,
2006).
15
Table 1.1: Benzoic Acid and Its Derivatives (Adapted from Liu, 2004)
Benzoic acid derivatives Substitutions
R1 R2 R3
p-Hydroxybenzoic H OH H
Protocatechuic H OH OH
Vannilic CH3O OH H
Syringic CH3O OH CH3O
Gallic OH OH OH
Table 1.2: Cinnamic Acid and Its Derivatives (Adapted from Liu, 2004)
Cinnamic acid derivatives Substitutions
R1 R2 R3
p-Coumaric H OH H
Caffeic OH OH H
Ferulic CH3O OH H
Sinapic CH3O OH CH3O
Flavonoids are a group of phenolic compounds located in the pericarp (Dykes & Rooney,
2007), which are responsible for the different colors of corn (Žilić et al., 2012), including orange,
red, yellow, blue, violet and ivory (Harborne, 1976). A major portion (91%) of the flavonoids in
corn is in bound form (Adom & Liu, 2002). The basic structure of flavonoids possesses two
aromatic rings (A & B), which are linked through three carbons in an oxygenated heterocycle
ring (Figure 1.5). Depending on the structural differences in heterocycle C ring, flavonoids are
divided into six groups: flavonols, flavones, flavanols, flavanones, anthocyanidins, and
isoflavonoids (Figure 1.6) (Liu, 2004). The antioxidant activity of flavonoids also mainly
depends on the position and number of hydroxyl groups in their structures (Noroozi et al., 1998).
Anthocyanins are the major flavonoids especially in dark-colored corn, whose dominant
compounds include cyaniding-3-glucoside, pelargonidin-3-glucoside, peonidin-3-glucoside and
their acylated counterparts (Pedreschi, 2007; Lopez-Martinez et al., 2009; Žilić et al., 2012).
Other major flavonoids present in corn are identified as kaempferol, hesperitin, quercetin,
leucopelargonidin, naringenin, and their derivatives (Dykes & Rooney, 2007; Pedreschi, 2007;
16
Ramos-Escudero, 2012). According to Adom & Liu (2002), the total flavonoid content in corn is
the highest among wheat, oats, and rice.
Figure 1.5: The Basic Structure of Flavonoids (from Liu, 2004)
Figure 1.6: The Structures of Major Classes of Flavonoids (from Liu, 2004)
Health benefits related to flavonoids include antioxidant activity (Noroozi et al., 1998),
preventing atherosclerosis (Naderi et al., 2003), decreasing capillary fragility and permeability
(Bentsáth et al., 1936), treating progressive neurodegenerative disorders (Weinreb et al., 2004),
anticancer (Fink et al., 2007), anti-inflammatory (Rathee et al., 2009), anti-allergic (kawai et al.,
2007), and gastroprotective properties (Mota et al., 2009). The health-enhancing effects of
17
flavonoids primarily result from their antioxidant activity. It is reported that flavonoids could
inhibit low-density lipoprotein (LDL) oxidation attributed to its antioxidant capacity, thus may
be helpful in preventing coronary artery disease (Naderi et al., 2003). In another study conducted
by Noroozi et al. (1998), the antioxidant activities of a series of flavonoid compounds were
examined, and they were found to exert protective effects towards oxygen radical generated
DNA damage in human lymphocytes.
Among the multiple phenolic compounds identified in corn, two most predominant ones,
ferulic acid and anthocyanin, which belong to the group of phenolic acids and flavonoids
respectively, will be discussed.
1.2.3.1.1. Ferulic Acid
Ferulic acids are the most abundant phenolic compounds in corn (Hu & Xu, 2011), which
mainly exists in bound form (> 93%) (Adom & Liu, 2002; Lopez-Martinez, 2009). A majority of
the ferulic acids in corn are bound to cell wall components as esters (Lozovaya, 2000). Adom &
Liu (2002) conducted a study comparing ferulic acid content in corn to those of wheat, rice, and
oats, and found corn contained the highest level at 906 μmol/100 g. Different ferulic acid
contents are present among different corn types. According to Lopez-Martinez (2009), orange
corn had the highest total ferulic acid content among 18 corn genotypes with different colors.
Figure 1.7: The Structure of Ferulic Acid
18
The methoxy and hydroxyl groups in the structure of ferulic acid (Figure 1.7) can donate
electrons to quench free radicals, and the unsaturated C-C double bond on the side chain can also
act as attack site for free radicals, which contribute to the antioxidant potency of ferulic acid
(Srinivasan et al., 2007; Luo & Wang, 2012). The carboxylic acid in the ferulic acid structure is
also able to conjugate with the bilayer of lipids to prevent lipid peroxidation (Luo & Wang,
2012). Ferulic acid is more bioavailable than the other phenolics, and remains in blood longer to
scavenge free radicals (Srinivasan et al., 2007). Due to its antioxidant potency, ferulic acid is
able to display a wide variety of health-beneficial effects, such as anti-inflammatory (Sakai et al.,
1997; Ou et al., 2003), antidiabetic (Ohnishi et al., 2004), anticancer (Asanoma et al., 1993;
Kawabata et al., 2000), hypotensive (Suzuki et al., 2002), neuroprotective (Kanski et al., 2002),
cholesterol-lowering (Kim et al., 2003), and anti-atherogenic effects (Perfilava et al., 2005, as
cited in Srinivasan et al., 2007).
1.2.3.1.2. Anthocyanin
Anthocyanins are a group of water-soluble vacuolar pigments responsible for orange, red
purple and blue colors of plants, which belong to a class of flavonoids (Giusti & Wrolstad, 2003;
Abdel-Aal et al., 2006). Anthocyanins are glycosides of anthocyanidins, and the structures of
common anthocyanins are shown in Figure 1.8 and Table 1.3. Mainly located in the aleurone
layer and pericarp, anthocyanins contribute to the color of corn kernels (Betran, 2000; Moreno et
al., 2005). The colors of anthocyanin compounds are also affected by the pH of the solution
(Moreno et al., 2005).
19
Figure 1.8: The Basic Structure of Common Anthocyanins (From Abdel-Aal et al., 2006)
Anthocyanins are the major free phenolic compounds in corn (Lopez-Martinez et al., 2009).
Anthocyanin composition in corn depends primarily on corn type and maturity stage (Hu & Xu,
2011). Pigmented corn species like black, purple, red, and blue phenotypes have higher
anthocyanin levels than orange, yellow, and white ones (Lopez-Martinez et al., 2009), since in
these light-colored corn species, carotenoids are the major pigments (Kurilich et al., 1999).
Among multiple corn types with different colors, purple corn is the one with the highest
anthocyanin content (Abdel-Aal et al., 2006). In the study of Pedreschi et al. (2007), anthocynins
in Andean purple corn extract accounted for 77.7% of the total phenolics. According to Žilić et al.
(2012), major anthocyanins that have been identified in corn include cyanidin-3-glucoside,
cyanidin-3,5-diglucoside, cyanidin-3-rutinoside, cyanidin-3,6-ethylmalonylglucoside,
pelargonidin-3-glucoside, pelargonidin-3,5-diglucoside, peonidin-3-glucoside, and delphinidin-
3-glucose. Scarlet red corn contains the highest number (27) of anthocyanin compounds (Abdel-
Aal et al., 2006). Cyanidin, pelargonidin, and peonidin are the major anthocyanins in corn,
among which, cyanidin is the most predominant form (Abdel-Aal et al., 2006; Žilić et al., 2012),
accounting for 73-87% of total anthocyanins (Moreno et al., 2005). Two forms of anthocyanins
20
exist in corn are acylated and nonacylated, and the proportion of acylated anthocyanins in
degermed corn kernels is between 55.2% and 63.3% (Moreno et al., 2005).
Table 1.3: Structures of Common Anthocyanins (Adapted from Abdel-Aal et al., 2006)
Anthocyanins Substitutions
R1 R2
Pelargonidin-3-glucoside H H
Cyanidin-3-glucoside OH H
Delphinidin-3-glucoside OH OH
Peonidin-3-glucoside OCH3 H
Petunidin-3-glucoside OCH3 OH
Malvidin-3-rutinoside OCH3 OCH3
Besides the color attributes, anthocyanins are also correlated to several health-enhancing
effects, such as antioxidant capacity (Satue-Gracia et al., 1997; Hu & Xu, 2011; Žilić et al.,
2012), preventing obesity (Tsuda et al., 2003; Jay aprakasam et al., 2006), anti-inflammatory
(Wang et al., 1999), ameliorating hyperglycemia (Tsuda et al., 2003), reducing colon cancer risk
(Zhao et al., 2004; Jing et al., 2008), suppressing tumor cells (Kamei et al., 1995), treating
circulatory disorders (Bettini et al., 1985), and maintaining normal vascular permeability (Wang
et al., 1997). Hence, anthocyanins can work as potential functional food ingredients and
functional colorants (Abdel-Aal et al., 2006).
1.2.3.2. Existence Forms of Phenolic Compounds in Corn
Phenolic compounds in plants generally exist in three forms: soluble free, soluble conjugated
and insoluble bound forms (Adom & Liu, 2002; Žilić et al., 2012). Phenolics in free form are
mainly flavanols, while the bound ones mostly consist of phenolic acids (Montilla, 2011). Unlike
phenolics in fruits and vegetables that are mainly present in free or soluble conjugated forms
(Vinson, 1998; Vinson, 2001), phenolics in corn tend to be in the bound form (Montilla, 2011).
According to the study conducted by Adom & Liu (2002), 85% of phenolics in corn are bound.
21
Thus, total antioxidant capacity is closely associated with phenolic content in bound extractions
of grains, while a low correlation is presented for free extracts (Adom & Liu, 2002). Additionally,
bound phenolics are able to survive digestion in the GI tract, reach the colon, and thus pose
beneficial health effects in preventing cancers (Adom & Liu, 2002).
Corn phenolics mainly occur as esters, less commonly as ethers, covalently bound to cell
wall components (Lozovaya, 2000; Sun et al., 2012). Ferulic acid, which is the most
predominant phenolic in corn (Hu & Xu, 2011), is generally esterified to form covalent cross-
links with cell wall components such as polysaccharides (Meyer et al., 1991; Wallace & Fry,
1994), including glucuronoarabinoxylans, xyloglucans and pectins (Wong, 2006), glycoproteins
(Fausch et al., 1963), polyamines (Legaz et al., 1998; Ou & Kwok, 2004; Underwood, 2012),
and lignin (Meyer et al., 1991). Different phenolic acids in plants tend to be bound with different
cell wall components. A majority of p-coumaric acids in plant are bound to lignin (Ralph, 2010),
while ferulic acids are prone to bind with polysaccharides (Ishii, 1997). This linkage is supported
by hydrogen bond formation between the phenolic hydroxyl group and the oxygen atoms from
glycosidic linkages of polysaccharides, hydrophobic interactions, as well as covalent bonds
between phenolic compounds and polysaccharides (Saura-Calixto, 2011).
Food processing methods like fermentation and malting, extrusion cooking, and alkaline
hydrolysis can facilitate release of bound phenolics (Acosta-Estrada, 2014). For analytical
purposes, enzymatic (Fazary & Ju, 2007), ultrasound (Peričin et al., 2009), microwave (Jokić et
al., 2012), thermal (Montilla, 2011), acid and alkaline hydrolyses (White et al., 2010) can be
used to break the ester bond and liberate bound phenolics. Alkaline hydrolysis is one of the most
common method to obtain the cell wall-linked bound phenolics in grains (Adom & Liu, 2002;
Dewanto et al., 2002; Kim et al., 2006; Parra et al., 2007; Žilić et al., 2012), reducing the loss of
22
corn ferulic acids from 78% to 4.8% compared with acid hydrolysis (Krygier et al., 1982). After
liberation, the released phenolics are capable of being extracted through specific solvent systems
(Acosta-Estrada, 2014).
Apart from insoluble phenolic forms that are bound to cell wall components, phenolics can
also be esterified with low molecular mass compounds like ethanol, or other phenolics through
carboxylic and hydroxyl groups in their structures (Sun, 2012). Phenolic compounds are also
able to be covalently conjugated with mono- and oligosaccharides (Ou & Kwok, 2004). These
soluble phenolics in corn, including free and conjugated fraction (ex. esterified and glycosylated
phenolics), can be solvent extracted directly. Commonly used solvents include ethanol (Adom &
Liu, 2002; Santiago, 2007; Montilla, 2011), methanol (Bacchetti et al., 2013), and acetone
(Krygier et al., 1982). Since conjugated phenolic compounds are still able to be oxidized, they
can be quantified together with free phenolics as a soluble fraction, through Folin-Ciocalteu
colorimeric reaction (Adom & Liu, 2002).
Free phenolics contribute little to the total phenolic content in corn. Only less than 0.6% of
ferulic acids are in free form (Adom & Liu, 2002). Free phenolic compounds identified in corn
include protocatechuic, vanillic, p-coumaric, o-coumaric, and ferulic acids (Hu & Xu, 2011;
Žilić et al., 2012). As corn matures, some free phenolics may be metabolized or synthesized into
bound phenolic compounds, thus causing a significant decrease in free phenolics of corn during
maturation (Hu & Xu, 2011).
1.2.3.3. Antioxidant Properties of Corn Phenolics and Potential Health Benefits
Phenolic compounds can act as antioxidants, scavenging reactive oxygen species (ROS) and
23
reactive nitrogen species (RNS) which mainly include superoxide, hydroxyl, peroxyl, alkoxyl,
peroxynitrite and oxides of nitrogen (Morton et al., 2000). ROS and RNS may derive from the
human body, in which are metabolically produced, or of exogenous origin such as ultraviolet
radiation, cigarette smoke, and air pollutant exposure (Morton et al., 2000). A state of oxidative
stress may be reached if the balance is perturbed between ROS and RNS generation and
antioxidant defense system in human body (Halliwell, 1994), thus damage will be produced to
cells and in vivo biological molecules (Morton et al., 2000).
Phenolics in corn possess considerable antioxidant capacity in vitro, and are able to delay the
cellular damage caused by oxidative stress (Rice-Evans et al., 1997; Adom & Liu, 2002; Alía et
al., 2006a; Hu & Xu, 2011; Žilić et al., 2012). Adom & Liu (2002) reported that the total
antioxidant activity of corn is 181.42 μmol Vitamin C equiv/g, which is higher than that of wheat,
rice, and oats. A large variation is found in antioxidant activity among different genotypes of
corn, due to their differences in phenolic profiles (Jacobo-VelÁzquez & Cisneros-Zevallos, 2009;
Lopez-Martinez et al., 2009). Corn with dark colors possesses higher antioxidant capacity than
light colored ones (Žilić et al., 2012). Several studies have indicated the positive relationship
between corn phenolic content and its antioxidant capacity. According to Adom & Liu (2002),
the total antioxidant activity of corn is closely related to the phenolic content (R2=0.983),
especially for bound phenolics (R2=0.991). Bacchetti et al. (2013) also demonstrated a
significant positive correlation between corn total phenolics and oxygen radical absorbance
capacity (ORAC) values. For a certain phenolic compound, its antioxidant activity is correlated
to available hydroxyl groups and their positions in its structure (Rice-Evans et al., 1996; Jacobo-
VelÁzquez & Cisneros-Zevallos, 2009). Common methods used to measure antioxidant capacity
in corn include total oxyradical scavenging capacity (TOSC) assay (Adom & Liu, 2002), ORAC
24
method (Li et al., 2007; Bacchetti, et al., 2013), and 1,1-diphenyl-2-picrylhydrazyl (DPPH) assay
(Mohsen & Ammar, 2009; Sarepoua et al., 2013). Choosing different assays will also alter the
measured antioxidant capacity of corn (Žilić et al., 2012).
The major pathway for antioxidant action of phenolics is free radical scavenging, in which
the free radical chain reaction is broken (Morton et al., 2000). Thus, some negative oxidative
effects such as free radical mediated cytotoxicity and lipid peroxidation are inhibited (Sonee et
al., 2004; Alía et al., 2006a). Several studies have shown the capability of phenolic compounds
in scavenging ROS and RNS such as peroxyl radicals (Chimi et al., 1991), alkyl peroxyl radicals
(Nakao et al., 1998; Sawa et al., 1999), superoxide (Kashima, 1999), hydroxyl radicals (Chimi et
al., 1991; Kashima, 1999), nitric oxide radical (Vanacker et al., 1995), and peroxynitrite (Heijnen
et al., 2001).
The other mechanisms related to phenolic antioxidant activity include metal ion chelating,
enzyme regulation, oxidative damage repair, and peroxide metabolizing (Duthie et al., 2000;
Morton et al., 2000). Phenolics are capable of chelating divalent metal ions that work as catalysts
in ROS production, such as Fe and Cu, thus Fenton’s reaction is inhibited and the formation of
free radicals is prevented. It has also been reported that phenolics are able to modulate a variety
of enzymes such as lipoxygenase, cyclooxygenases, phosphatidyl-3-kinase, glutathione reductase,
glutathione peroxidase, superoxide dismutase and catalase (Kato et al., 1983; Lipkin et al., 1999;
Murakami et al., 2002; Alía et al., 2006a; Alía et al., 2006b). When a proper dose of a certain
phenolic compound is given, some changes may be occurred towards the activity and/or gene
expression of the antioxidant enzyme system in cells (Alía et al., 2006a). These antioxidant
enzymes play an important role in defense against oxidative stress. Catalase catalyzes the
conversion of H2O2 into H2O, and glutathione reductase enables the oxidized glutathione to be
25
reduced back to its original form (Goldberg et al., 1987; Ursini et al., 1995; Alía et al., 2006a).
Glutathione participates in the intracellular antioxidant defense mechanism, being capable of
scavenging free radicals and other ROS (Wu et al., 2004). According to Murakami et al. (2002),
by treating HepG2 cells with epigallocatechin 3-O-gallate (EGCG), the cytotoxicity induced by
H2O2 is significantly reduced, and oxidative enzymes such as Mn-superoxide dismutase and
glutathione peroxidase are enhanced. Similarly, another study conducted by Alía et al. (2006a)
indicated that higher dose of quercetin, a flavonoid compound, could induce a significant
increase in glutathione concentration within cells, and thus strengthen the antioxidant defense
system.
Attributed to their antioxidant capacity, phenolics are considered to have the potential to
prevent several chronic diseases. Phenolic compounds in corn possess anti-mutagenic capacity,
which is achieved by blocking or scavenging mutagen electrophiles and inhibiting enzymes
involved in mutagen activation (Pedreschi & Cisneros-Zevallos, 2006). Moreover, various
phenolic compounds are able to suppress proliferation of several types of cancer cells in vitro,
including ovary (Scambia et al., 1994; Peng et al., 2008), colon (Agullo et al., 1994; Yi et al.,
2005), breast (Mehta et al., 1997; Kampa et al., 2004), lung (Caltagirone et al., 1997), and liver
cancer cells (Tanaka et al., 1993; Chi et al., 1997). One of the major mechanisms for the anti-
carcinogenic effect of phenolic compounds is related to their antioxidant capacity, through which
oxidative DNA damage caused by ROS and RNS as potential carcinogens is inhibited (Duthie et
al., 2000), cellular oxidative stress is reduced, and cell-overgrowth is prevented (Duthie et al.,
1997; Noroozi et al., 1998; Alía et al., 2006a). Apart from direct ROS and RNS scavenging
capacity, phenolic compounds are also able to alter procarcinogenic metabolism by suppressing
phase I enzymes and enhancing phase II enzymes that have potential to inhibit tumor
26
development (Maliakal & Wanwimolruk, 2001; Schwarz & Roots, 2003; Ramos, 2008).
Additionally, phenolics are found to have inhibitory effect against cancer by inducing apoptosis
in a selective manner (Nair et al., 2004; Ramos, 2008). Although the anti-cancer effects of
phenolics are noted in a number of in vivo and animal studies, epidemiological evidence is not
well defined, and even some contradictory results are shown (Hertog et al., 1994; Duthie et al.,
2000; Spormann et al., 2008).
Another major health benefit of phenolics is related to their function in preventing heart
disease. LDL is susceptible to be oxidized by free radicals (Schuh et al., 1978; Duthie et al.,
2000), thus may contribute to atherogenesis (Steinberg, 1997). However, phenolic compounds
are able to suppress LDL oxidation and play a protective role in heart disease, through possible
mechanisms such as scavenging oxidizing species and binding LDL protein (Frankel et al., 1993;
Ishikawa et al., 1997; Geleijnse et al., 1999; Kerry & Abbey, 1999; Wang & Goodman, 1999;
Chang et al., 2000; Duthie et al., 2000).
1.2.3.4. Impact of Processing on Phenolic Compounds
During some food processes such as cooking, alkaline hydrolysis, and fermentation, bound
phenolics are able to be released into soluble ones (Acosta-Estrada et al., 2014). Since ferulic
acid is the most predominant phenolic acid in corn, it is typically used as a marker to show the
processing effects on phenolic components. Under heat treatment, insoluble-bound ferulic acids
in corn tended to be released into solubilized feruloylated oligosaccharides and free ferulic acids;
thus, bound phenolic content decreased during processing while free and conjugated phenolics
increased (Dewanto et al., 2002). The majority of the released bound phenolics were in soluble-
conjugated form before enzymatic treatment, chemical treatment or severe heat treatment
27
(temperature > 180 °C) was applied to liberate them into free form (Saulnier et al., 2001;
Dewanto et al., 2002). According to Parra et al. (2007), bound ferulic acid in corn was released
into free and soluble-conjugated ferulic acids during lime-cooking for production of corn masa.
However, with masa baked into tortillas and fried into tortilla chips, ferulic acids were
complexed again. In the study conducted by Đorđević et al. (2010), total phenolic contents of
buckwheat, wheat germ, barley, and rye all significantly increased after fermentation with L.
rhamnosus or S. cerevisiae.
Although phenolics are enhanced during fermentation, other processing operations may
result in degradation of phenolic compounds. The nixtamalization process used for production of
masa, tortillas, and tortilla chips induced a significant decrease in total phenolics and antioxidant
activities of corn (Parra et al., 2007). Cooking of corn decreased total phenolic content with
increased cooking time (Dewanto et al., 2002). Boiling destroyed more phenolic and antioxidant
compounds than steam cooking (Harakotr et al., 2014). The loss in phenolic compounds and
antioxidant activity of corn during cooking resulted from degradation or decomposition of
antioxidant compounds and leaching or diffusion of these compounds into cooking water
(Harakotr et al., 2014). During extrusion cooking of corn meals with blueberry and grape juice
concentrates, 74% of anthocyanins were degraded (Camire ei al., 2002). Some oxidative and
hydrolytic enzymes can be liberated from the cell wall when it is destroyed through some
processing methods, thus antioxidants in foods may be disrupted (Chism & Haard, 1996).
28
CHAPTER 2: PHENOLIC CONTENT OF CORN AS AFFECTED BY GENOTYPE,
GROWTH YEAR, AND CORN FLAKE PROCESSING STAGES
2.1. Introduction
Phenolics, a group of powerful bioactive compounds present in corn, are a class of
compounds possessing one or more hydroxyl groups (-OH) bonded directly to one or more
aromatic rings (Liu, 2004). Phenolic compounds in plants generally exist in three forms: soluble-
free, soluble-conjugated, and insoluble-bound (Adom & Liu, 2002; Žilić et al., 2012). Unlike
phenolics in fruits and vegetables that are mainly present in free or soluble conjugated forms
(Vinson, 1998; Vinson, 2001), phenolics in corn tend to be in the bound form (Montilla, 2011).
According to Adom & Liu (2002), 85% of phenolics in corn are bound. For whole corn kernels,
phenolic acids and flavonoids are the most predominant forms of phenolics (Žilić et al., 2012).
Free phenolic acids and flavonoids were concentrated in the pericarp, aleurone layer, and germ
fractions of corn (Sen et al., 1994), while bound phenolic acids are mainly esterified to cell wall
components (Dykes & Rooney, 2007). Total phenolic content of corn varied from genotype to
genotype (Žilić et al., 2012), and were higher than that in rice, wheat, and oats (Adom & Liu,
2002). Phenolic compounds display a wide variety of potential health-enhancing functions, such
as anti-mutagenicity (Cardador-Martínez, 2002; Pedreschi & Cisneros-Zevallos, 2006), anti-
carcinogenicity (Owen et al., 2000), anti-inflammation (Jiang & Dusting, 2003), microbial
inhibition (Nohynek et al., 2006), and prevention of coronary heart disease (Morton et al., 2000).
Hence, phenolic content is an important nutritional factor of corn products.
Corn flakes are a major component of corn products in the market of ready-to-eat breakfast
cereals. U.S. No. 1 or No. 2 yellow dent corn is the common source for producing flaking grits,
which could be further processed into corn flakes (Caldwell and Fast, 1990). Corn whole kernels
29
are first dry milled to have the corn fractions of pericarp, germ and endosperm separated (Rausch
et al., 2009). Flaking grits are then obtained from the endosperm fraction, and further cooked,
delumped, dried and tempered, flaked, and toasted into flakes (Fast & Caldwell, 2000). A large
number of studies have been conducted to analyze phenolic compounds in various corn types;
however, few studies have been focused on the phenolics in corn flakes.
The objectives of this study were to investigate the effects of genotype, growing year, and
processing stage on phenolic content in corn, and to have an overall understanding of how
phenolics change during the corn-flaking procedure. Significant changes in phenolics are
expected during production of corn flakes.
2.2. Materials and Methods
2.2.1. Corn Sample and Sample Preparation
Three commercially available yellow dent corn hybrids were used in this study. These
hybrids were grown at the University of Illinois at Urbana-Champaign and harvested in 2009,
2010, and 2011. Three replications of each hybrid were collected from the corn samples
harvested each year. The whole kernels were dry milled to obtain flaking grits using methods
described by Rausch et al. (2009). Before phenolic analyses, the whole kernel and flaking grit
samples were ground into powder using a coffee grinder and dried at 60°C in an drying oven
(Fisher Scientific, Fair Lawn, NJ) until they reached constant weight.
2.2.2. Chemicals and Reagents
Folin-Ciocalteu reagent, gallic acid, and sodium carbonate were purchased from Sigma
Chemical Company (St. Louis, MO). Sodium Chloride, sodium hydroxide, hydrochloric acid,
30
hexane, ethyl acetate, methanol, and acetone were obtained from Fisher Scientific (Fair Lawn,
NJ). Ethanol was purchased from Decon Labs (King of Prussia, PA). Salt, sugar, and molasses
were purchased from a local supermarket.
2.2.3. Production of Corn Flakes
Flakes were produced based on the methods described by Kandhola (2015). The formulation
for cooking was created by mixing 2 g salt, 6 g sugar, and 2 g molasses with 200 mL double
deionized water. This formulation (200 mL) was added to 100 g flaking grits and mixed in a jar.
The mixture was cooked in a pressure cooker (Wisconsin Aluminum Foundry Co., Inc., WI) at
15 psi for 1 hr, and the top layer of cooked grits was removed using a spatula once cooking
finished. The solid cooked grits were baked in a convection oven (Oster, China) at 107.2°C for
50 min, to reduce the moisture content of the cooked grits from 60 to 50%. Samples were stirred
in middle of baking time to ensure even drying. Baked grits were kept at room temperature for
30 min to equilibrate moisture. The dough of baked grits was pressed through the flaking
machine, and cut into 1 inch square pieces using a pizza cutter. Raw flakes were kept at room
temperature for 16 hrs and toasted in the convection oven at 204.4°C for 80 s to produce toasted
flakes. Samples were removed at each processing stage, dried at 60°C until they reached constant
weight, and ground into powder using a coffee grinder, prior to analysis.
2.2.4. Extraction of Soluble Phenolic Compounds
Methods to extract soluble phenolics in corn were modified based on the protocol described
by Adom & Liu (2002). Corn sample (2.5 g) was extracted by blending with 10 mL 80% chilled
ethanol using a Fisher vortex (Fisher Scientific, NY). Samples were homogenized using a
31
Polytron homogenizer (Kinematica AG, Switzerland) for 3 min and centrifuged at 1935 g for 17
min. Supernatant was removed and the residues were extracted one more time. Two supernatants
were combined and evaporated to 5 mL under nitrogen at 45°C using an analytical evaporator
(Organomation Associates Inc., MA), and reconstituted with double deionized water to a final
volume of 10 mL. This solution would be cloudy. It was added with 5 mL 4M sodium chloride,
vortexed 2 min, and centrifuged (1935 g, 10 min). Supernatant was removed and kept in the
refrigerator until use. Duplicate analysis was conducted for each sample.
2.2.5. Extraction of Bound Phenolic Compounds
Bound phenolics were extracted from corn using a method modified from the protocol
described by Adom & Liu (2002). Corn samples (0.5 g) were blended with 5 mL 80% chilled
ethanol using a Fisher vortex to extract soluble phenolics. Samples were further homogenized
using a Polytron homogenizer for 2 min and centrifuged at 1935 g for 10 min. Supernatant was
discarded, and extraction was repeated. Residues were digested with 10 mL of 2M sodium
hydroxide under nitrogen, and shaken for 1 hr. Hydrochloric acid (2 mL, 12N) was added to
neutralize the solution. Hexane (5 mL) was added, mixture was vortexed, and centrifuged (1935
g, 10 min) to remove lipids. The solution was further extracted 5 times with 5 mL ethyl acetate.
Ethyl acetate fractions were combined and evaporated to dryness under nitrogen at 45°C using an
analytical evaporator, and reconstituted in 5 mL 50% methanol. Bound phenolic extracts were
stored at 4 °C until use. Duplicate analysis was conducted for each sample.
2.2.6. Determination of Phenolic Content
Corn phenolic content was determined based on the Folin-Ciocalteu colorimetric method
32
described by Singleton et.al. (1999). Corn samples were diluted with 50% methanol. A 10%
dilution was made for bound extracts of whole kernels and flaking grits samples, while a 20%
dilution was made for all the soluble extracts, and bound extracts of cooked grits, baked grits,
and toasted flakes samples. Gallic acid was used as a standard. Diluted extracts (250 µL) and
gallic acid solutions were oxidized with 200 µL Folin-Ciocalteu reagent, and neutralized with
550 µL sodium carbonate. The solutions were vortexed and incubated at 42°C (9 min).
Absorbance was measured at 765 nm using a spectrometer (Spectronic Instruments, USA) after
the solutions were cooled in the dark. Results were expressed as micrograms gallic acid
equivalents (GAE) per gram sample.
2.2.7. Statistical Analysis
Analysis of variance (ANOVA) was performed to determine the effect of genotype, growing
year, biological replication and processing stage on phenolic content of corn samples using the
generalized linear mixed model (GLMM). Genotype and processing stage were treated as fixed
effects, while growing year and replicate nested within year were treated as random effects.
Mean values were compared using the Tukey’s multiple comparison test at 5% level. All
analyses were performed using Statistical Analysis System (SAS) software, version 9.4 (SAS
institute, Cary, NC).
2.3. Results
2.3.1. Moisture Content
The moisture content of whole corn kernels was 8.57% (Table 2.1). After dry-milling into
flaking grits, the moisture content increased to 8.89%. Grits absorbed moisture during cooking;
33
thus, after this process, cooked grits reached a high moisture content of 63.67%. Cooked grits
were then dried during baking, which resulted in a decrease in moisture content to 53.71%.
Baked grits were tempered and processed into raw flakes, and the subsequent toasting process
resulted in a decrease in moisture content to 6.04%. The moisture content of corn was
significantly influenced by corn-flaking processing stages, while effects of genotypes, years, and
replicates within years were not detected (Appendix A.1).
2.3.2. Soluble, Bound and Total Phenolics
There were significant main effects of genotypes and processing stages for soluble, bound,
and total phenolics, but the effects of years and replicates within years were not significant
(Table 2.2). Significant interactions of genotype × processing stage, and genotype × replicate
within year were observed. Genotype × processing stage × replicate within year interaction was
also significant. The complete ANOVA tables for soluble, bound, and total phenolics were listed
in the Appendix A.
The soluble phenolic contents obtained represent free as well as soluble-conjugated phenolics.
To assess the impact of processing on soluble phenolics, mean soluble phenolic contents during
the corn-flaking procedure were calculated by combining hybrids A-C (Table 2.3 & Figure 2.1).
There was no significant difference in soluble phenolic content between whole kernels and
flaking grits. After the grits were cooked, a decrease in soluble phenolics occurred. Subsequent
baking did not affect soluble phenolic content in grits. However, after baked grits were processed
into raw flakes and toasted, the soluble phenolic content of the toasted flakes reached 710 µg
GAE/g, which was significantly higher than those of all the other processing stages. Soluble
phenolic content of commercial hybrid C was significantly higher than hybrid B (Figure 2.2).
34
There was no difference presented between hybrid A and B or C. No difference was detected in
soluble phenolic content among corn grown in 2009, 2010, and 2011 for all five processing
stages (Table 2.4 & Figure 2.3).
There was no difference in bound phenolic content between corn whole kernels and flaking
grits (Table 2.5 & Figure 2.4). The cooking process induced a decrease in bound phenolic
content of corn grits. Subsequent baking and toasting processes did not further alter bound
phenolic content in corn grits. Bound phenolic content of corn hybrid C was higher than that of
hybrid B in all processing stages (Figure 2.5). The difference between hybrid A and B, or A and
C was not significant. There was no difference in bound phenolic content among corn grown in
2009, 2010, and 2011 (Table 2.6 & Figure 2.6).
Whole kernels contained the highest total phenolic content among processed corn samples
from five processing stages (Table 2.7 & Figure 2.7). The total phenolic content of flaking grits
did not differ from whole kernels. After grits were cooked, the total phenolic content decreased,
and remained unchanged during baking. The subsequent toasting process induced an increase in
total phenolic content, as a result of increased soluble phenolics. Corn hybrid C contained higher
total phenolic content than hybrid B (Figure 2.8). Total phenolics of hybrid A did not differ from
hybrid B or C. There was no difference in total phenolics among corn grown in 2009, 2010, and
2011 for all five corn-flaking processing stages (Table 2.8 & Figure 2.9).
2.3.3. Percentage of Bound Phenolics
For the percentage of bound phenolics, significant main effects of processing stages and
replicates within years were observed (Table 2.2). Bound phenolic percentage was not
significantly influenced by different corn hybrids and growing years. Interaction of genotype ×
35
processing stage × replicate within year was significant. The complete ANOVA tables for bound
phenolic percentage were listed in the Appendix A.
During the corn-flaking procedure, percent bound phenolics decreased with bound phenolics
released into soluble ones (Table 2.9 & Figure 2.10). The bound phenolic percentages in corn
whole kernels and flaking grits were not different. The cooking process helped release bound
phenolics, resulting in reduced bound phenolic percentages compared to flaking grits. No
difference in bound phenolic percentage was observed between cooked and baked grits. After
grits were toasted, another decrease in bound phenolic percentage occurred; the percentage
reduced to a final value of 64.49%. There was no significant genotype effect for percentage of
bound phenolics. The only difference occurred in flaking grits, with bound phenolic percentage
of hybrid C significantly higher than A and B (Table 2.9). No difference among growing years
was observed for all five processing stages (Table 2.10).
2.4. Discussion
2.4.1. Effects of Genotype, Growing year, and Processing Stage on Phenolics in Corn
Variations in soluble, bound, and total phenolics were all significant among different corn
commercial hybrids across three growing years and five processing stages (Table 2.2).
Commercial hybrid C contained the highest phenolic content, while hybrid B was the lowest.
The non-significant year effect for soluble, bound, and total phenolics indicated that the traits of
corn were consistent across different growing years. According to study conducted by Harakotr
et al. (2015), in which 49 genotypes of waxy corn were tested, genotype was a more significant
source of variation in total phenolic content and antioxidant activity than growing season.
Similar results were also reported by Chander et al. (2008) and Mahan et al. (2013). The
36
interaction of genotype × year was not significant by every individual processing stage, which
indicated that phenolic contents of different corn hybrids growing in one year were able to
predict their phenolic performances in other growing years (Harakotr et al., 2015). Hence,
breeding of corn for higher phenolic concentration was feasible, with similar relative
performance in phenolics across years (Knievel et al., 2009; Harakotr et al., 2015).
Variations in soluble, bound, and total phenolic contents were also significantly influenced
by corn-flaking processing stages. Strong interaction of genotype × processing stage was
observed for soluble, bound, and total phenolics, indicating that different corn hybrids may
respond differently with phenolic changes during corn-flaking. This can be explained by the
different phenolic content (Lopez-Martinez et al., 2009; Žilić et al., 2012), phenolic composition
(Hu & Xu, 2011; Ramos-Escudero et al., 2012; Pandey, 2013), and phenolic distribution (Dykes
& Rooney, 2007) of different corn hybrids, which may result in varied responses during thermal
processing. Processing stage also contributed the most to the total variations in bound phenolic
percentages. This was because bound phenolics tended to be released into soluble phenolics
under thermal treatment, which resulted in a decrease of bound phenolic percentage during
processing (Dewanto et al., 2002).
Significant variations for phenolics were observed among replicates within years of
individual hybrids (Appendix A.5, A.9 & A.13), while a significant processing stage × replicate
within year interaction was also observed within each hybrid. Additionally, the interaction of
genotype × replicate within year was significant among all the hybrids, which indicated that
hybrid ranking in phenolics was altered by different replicates. These suggested that corn
genotypes used in our study may not come from a widely diverse genetic background. More
37
replicates involved in our analyses may help in improving the estimates of genotype, year, and
processing stage effects (Connor et al., 2005).
2.4.2. Changes in Phenolics during Corn-Flaking Procedure
Total phenolic contents of whole kernels of yellow dent corn were 2390, 2161, and 2657 µg
GAE/g of sample in our study (Table 2.7), separately for commercial hybrid A, B, and C, which
were in good agreement with results obtained by Adom & Liu (2002) which was 2645 µg GAE/g.
Commercial hybrid C contained the highest total phenolic content among the three corn hybrids.
Percentage of bound phenolics varied across corn hybrids from 71.22 to 76.65% (Table 2.9),
which was lower than the 85% presented in Adom & Liu (2002), but higher than the 69.2%
published by Sosulski et al. (as cited in Dewanto et al., 2002).
Corn flaking grits were obtained from whole kernels through a dry-milling process, in which
fractions of pericarp and germ were removed (Rausch et al., 2009). Endosperm, germ, and
pericarp account for 82-83%, 10-11%, and 5-6% of the corn whole kernel, respectively (Singh et
al., 2014). Phenolic acids and flavonoids are the two major forms of phenolic compounds in corn
(Žilić et al., 2012). Free phenolic acids are primarily located in the outer layer of pericarp, while
the bound phenolic acids are mostly esterified to cell wall components in the endosperm (Dykes
& Rooney, 2007; Singh et al., 2014). Flavonoids are also mainly found in cereal pericarp (Dykes
& Rooney, 2007). These were demonstrated in the study conducted by Sen et al. (1994), in
which a microspectrofluorometer was used to detect phenolic acids and flavonoids in corn
kernels. The results showed that free phenolic acids as well as flavonoids were intensively
presented in the pericarp, aleurone layer, and germ fractions of corn, while only a few traces
were observed in the endosperm. This is credible since the endosperm consists of numerous cells,
38
with phenolic acids bound to the cell wall components (Singh et al., 2014), and may contain low
concentrations of free phenolic acids to be detected through fluorescence. According to Adom &
Liu (2002), free, soluble-conjugated, and bound ferulic acids account for 0.10%, 0.99%, and
98.91% of total ferulic acids in corn kernels, respectively. After removal of pericarp and germ
during dry-milling, even less free phenolics would remain in the corn flaking grits. Hence, we
have reason to believe that the soluble phenolic content of flaking grits determined in our study
mainly represents soluble-conjugated phenolics in corn. Although a large proportion of free
phenolics were removed during dry milling, there was still no significant difference in the overall
soluble and bound phenolic contents between whole kernels and flaking grits (Table 2.3 &
Table 2.5). Significant differences were only observed within hybrid A and B. This can be
explained by the low proportion of pericarp (5-6%) and germ (10-11%) in whole kernel (Singh et
al., 2014), and the low contribution of free phenolics to total phenolics in corn (Adom & Liu,
2002).
A significant decrease occurred in both soluble and bound phenolic content when the corn
flaking grits were pressure cooked (Table 2.3 & Table 2.5). These phenolic values were
expressed as µg GAE per gram sample. The addition of other ingredients such as water, sugar,
salt, and molasses to flaking grits for the cooking process would reduce the proportion of corn in
the subsequent processed corn samples. If calculating phenolic content of cooked grits on a corn
basis instead of a sample basis, no difference in soluble phenolics was observed between flaking
grits and cooked grits. However, there was a significant decrease in bound phenolics. Under mild
heat treatment in cooking, insoluble-bound phenolics tended to be released primarily into
soluble-conjugated phenolics, while a little amount was liberated into free phenolics (Dewanto et
al., 2002). Hence, the decrease in bound phenolic content of cooked grits in our study can be
39
explained by the released bound phenolics during heat treatment. The unchanged soluble
phenolic content of cooked grits indicated possible loss of phenolic compounds during pressure
cooking. The loss may be due to the breakdown of phenolics under thermal treatment (Harakotr
et al., 2014). In the study conducted by Dewanto et al. (2002), increased soluble phenolics were
observed with corn kernels cooked without any ingredients added. Therefore, we hypothesize
that removed pericarp and germ fractions of corn may have protective effects on phenolics
during heat treatment. Additionally, phenolics may also react with the ingredients added to the
cooking system to cause the loss. During cooking, typical reactions of starch gelatinization,
Maillard browning, Strecker degradation, and lipid oxidation will occur (Culbertson, 2004).
Phenolics in corn may act as free radical scavengers to delay lipid oxidation, and thus may cause
loss in phenolic content.
After cooked grits were baked to reduce moisture content, the percentage of bound phenolics
slightly decreased. However, the change did not reach a significant level (Table 2.9). According
to Parra et al. (2007), when corn masa was baked into tortillas, slight increases in soluble
phenolics and decreases in bound phenolics were observed, although not significant. It was also
reported by Li et al. (2007) that baking at 177°C for 20 minutes did not affect total phenolic
content in purple wheat bran. Our results in baking were consistent with their work. In the study
of Dewanto et al. (2002), for thermal processing at 100°C, a significant release of bound
phenolics was observed. With increased temperature, the level of bound phenolics releasing
significantly increased. Baking was conducted under a temperature of 107.2°C which was higher
than 100°C, so we propose that release of bound phenolics may occur together with degradation
of solubilized phenolic compounds, which finally resulted in the unchanged bound phenolic
percentage.
40
After baked grits were further flaked and toasted at 204.4°C, a significant decrease in bound
phenolic percentage from 70.03% to 64.49% was observed, with a 31.30% increase in soluble
phenolics (Table 2.3 & Table 2.9). According to Saulnier et al. (2001), at a heat treatment over
180°C, auto-hydrolysis reaction occurred and thus a significant amount of free phenolics were
released from maize bran. Our results were in good agreement with theirs. While soluble
phenolic content increased, bound phenolic content in flakes remained unchanged during
toasting, which resulted in increased total phenolics (Table 2.5 & Table 2.7). These indicated
that the alkaline hydrolysis in bound phenolic extraction method may not be able to release all
the insoluble-bound phenolics linked to cell wall materials. During thermal treatment at 204.4°C
for toasting, cell wall matrix was disintegrated, and more firmly bound phenolics were exposed
and able to be extracted through alkaline hydrolysis for analysis. Increased total phenolics in
wheat, buckwheat, corn, and oat sprouts were also observed by Randhir et al. (2008) during
thermal processing, and they suggested that released bound phenolic acids from the breakdown
of cellular constituents and cell walls might be the possible reason. Another study on the effects
of thermal processing on selected legume sprouts and seedlings also indicated enhanced total
phenolic content and antioxidant activity under thermal treatment (Randhir et al., 2009). Hence,
we suppose that toasting may also increase bioavailability of phenolic compounds to pose more
health benefits to the human body while consuming corn flakes.
The overall changes in soluble, bound, and total phenolics during corn-flaking were shown in
Table 2.11 and Figure 2.11. In conclusion, significant changes in phenolics for corn flakes
production occurred during cooking and toasting. Total phenolic content decreased during
cooking with both reduced soluble and bound phenolics, and increased again during toasting
41
with increased soluble phenolics and more exposed bound phenolics. The results accorded with
our hypothesis that processing would induce changes to phenolics in corn.
42
2.5. Tables
Table 2.1: Mean Moisture Content (MC%) of Commercial Corn Hybrids during Five Processing
Stages a,b
Processing
Stages Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
Stage Mean 8.57±0.38D 8.89±0.54
C 63.67±0.55
A 53.71±0.68
B 6.04±0.21
E
a Values expressed as mean ± standard error of three corn hybrids growing in three growing years
with three replications per year, and with duplicate phenolic analysis per replication. b
Means in the same row followed by the same letter are not different (P<0.05).
Table 2.2: Analysis of Variance for Soluble, Bound, and Total Phenolic Content, and Bound
Phenolic Percenrage (BP%) of Different Corn Hybrids Growing in Different Years at Different
Processing Stages a,b
Source DF Pr > F
Soluble Phenolics Bound Phenolics Total phenolics BP%
Genotype 2 0.0318 0.0249 0.0241 0.1651
Processing Stage 4 <.0001 <0.0001 <0.0001 <0.0001
G×P 8 0.0100 0.0091 0.0097 0.1305
Year 2 0.5631 0.2675 0.2989 0.4761
Rep(Y) 6 0.2079 0.2552 0.2964 0.0293
G×Y 4 0.2054 0.0787 0.0921 0.3432
G×Rep(Y) 12 0.0002 <0.0001 <0.0001 0.3004
P×Y 8 0.5109 0.4843 0.4716 0.6098
P×Rep(Y) 24 0.0700 0.4981 0.4102 0.3103
G×Y× P 15 0.2120 0.4452 0.5247 0.1444
G×P×Rep(Y) 46 <.0001 <0.0001 <0.0001 <0.0001
Residual 132 - - - - a Analysis of variance is performed using the generalized linear mixed model (GLMM).
b “G”=”Genotype”; “P”= “Processing Stage”; “Y”= “Year”.
43
Table 2.3: Mean Soluble Phenolic Content of Three Commercial Corn Hybrids during Five Processing Stages (µg gallic acid
equivalents/g sample) a,b,c
Hybrid Processing Stages
Hybrid Mean Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
A 620±13B,a
594±36B,ab
532±36C,ab
521±50C,ab
751±41A,a
604±53 ab
B 618±12A,a
510±6B,b
477±10B,b
491±8B,b
589±26A,b
537±37b
C 613±32B,a
669±13B,a
606±27B,a
611±23B,a
790±10A,a
658±45a
Stage Mean 617±2B 591±46
B 538±37
C 541±36
C 710±62
A
a Values expressed as mean ± standard error of three growing years with three replications per year, and with duplicate phenolic
analysis per replication. b
Means in the same row followed by the same letter (capital) are not different (P<0.05). c Means in the same column followed by the same letter (small) are not different (P<0.05).
Table 2.4: Mean Soluble Phenolic Content of Corn Growing in Three Years at Five Processing Stages (µg gallic acid equivalents/g
sample) a,b,c
Year Processing Stages
Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
2009 629±24B,a
568±52B,a
498±30C,a
497±40C,a
691±47A,a
2010 616±18B,a
598±52B,a
548±45B,a
549±47B,a
725±59A,a
2011 608±14B,a
608±44B,a
569±45B,a
577±40B,a
716±89A,a
Stage Mean 617±2B 591±46
B 538±37
C 541±36
C 710±62
A
a Values expressed as mean ± standard error of three corn hybrids with three replications which are duplicate analyzed.
b Means in the same row followed by the same letter (capital) are not different (P<0.05).
c Means in the same column followed by the same letter (small) are not different (P<0.05).
44
Table 2.5: Mean Bound Phenolic Content of Three Commercial Corn Hybrids during Five Processing Stages (µg gallic acid
equivalents/g sample) a,b,c
Hybrid Processing Stages
Hybrid Mean Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
A 1770±99A,ab
1649±132B,b
1282±120C,ab
1268±97C,ab
1315±151C,a
1457±136ab
B 1541±57A,b
1423±18A,b
1130±30B,b
1092±22B,b
1117±58B,a
1261±119b
C 2044±93A,a
2125±98A,a
1482±69B,a
1452±81B,a
1450±80B,a
1711±198a
Stage Mean 1785±145A 1732±207
A 1298±102
B 1271±104
B 1294±97
B
a Values expressed as mean ± standard error of three growing years with three replications per year, and with duplicate phenolic
analysis per replication. b
Means in the same row followed by the same letter (capital) are not different (P<0.05). c Means in the same column followed by the same letter (small) are not different (P<0.05).
Table 2.6: Mean Bound Phenolic Content of Corn Growing in Three Years at Five Processing Stages (µg gallic acid equivalents/g
sample) a,b,c
Year Processing Stages
Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
2009 1707±79A,a
1589±187A,a
1195±113B,a
1185±69B,a
1212±69B,a
2010 1765±187A,a
1811±254A,a
1288±64B,a
1264±101B,a
1246±113B,a
2011 1883±190A,a
1797±203A,a
1412±150B,a
1364±279B,a
1424±174B,a
Stage Mean 1785±145A 1732±207
A 1298±102
B 1271±104
B 1294±97
B
a Values expressed as mean ± standard error of three corn hybrids with three replications which are duplicate analyzed.
b Means in the same row followed by the same letter (capital) are not different (P<0.05).
c Means in the same column followed by the same letter (small) are not different (P<0.05).
45
Table 2.7: Mean Total Phenolic Content of Three Commercial Corn Hybrids during Five Processing Stages (µg gallic acid
equivalents/g sample) a,b,c
Hybrid Processing Stages
Hybrid Mean Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
A 2390±109A,ab
2244±168B,b
1814±150D,ab
1789±146D,ab
2066±1856C,ab
2061±152ab
B 2162±53A,b
1934±22B,b
1608±25C,b
1583±25C,b
1706±75C,b
1798±142b
C 2657±63A,a
2794±106A,a
2088±92B,a
2063±101B,a
2241±90B,a
2369±194a
Stage Mean 2403±131A 2324±252
A 1837±139
C 1812±139
C 2004±157
B
a Values expressed as mean ± standard error of three growing years with three replications per year, and with duplicate phenolic
analysis per replication. b
Means in the same row followed by the same letter (capital) are not different (P<0.05). c Means in the same column followed by the same letter (small) are not different (P<0.05).
Table 2.8: Mean Total Phenolic Content of Corn Growing in Three Years at Five Processing Stages (µg gallic acid equivalents/g
sample) a,b,c
Year Processing Stages
Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
2009 2336±103A,a
2157±238B,a
1693±143D,a
1682±106D,a
1903±103C,a
2010 2381±171A,a
2409±304A,a
1836±107B,a
1812±148B,a
1970±167B,a
2011 2492±184A,a
2405±244A,a
1981±192C,a
1941±201C,a
2140±263B,a
Stage Mean 2403±131A 2324±252
A 1837±139
C 1812±139
C 2004±157
B
a Values expressed as mean ± standard error of three corn hybrids with three replications which are duplicate analyzed.
b Means in the same row followed by the same letter (capital) are not different (P<0.05).
c Means in the same column followed by the same letter (small) are not different (P<0.05).
46
Table 2.9: Mean Percentage of Bound Phenolics (BP%) of Three Commercial Corn Hybrids during Five Processing Stages a,b,c
Hybrid Processing Stages
Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
A 74.01±0.82A,a
73.36±0.58AB,b
70.42±1.12C,a
70.91±0.49BC,a
63.38±1.49D,a
B 71.22±1.33AB,a
73.61±0.19A,b
70.30±0.93B,a
68.94±0.50B,a
65.49±1.17C,a
C 76.65±1.89A,a
76.02±0.73A,a
70.83±0.55B,a
70.23±0.74B,a
64.58±1.10C,a
Stage Mean 73.96±1.57A 74.33±0.85
A 70.52±0.16
B 70.03±0.58
B 64.49±0.61
C
a Values expressed as mean ± standard error of three growing years with three replications per year, and with duplicate phenolic
analysis per replication. b
Means in the same row followed by the same letter (capital) are not different (P<0.05). c Means in the same column followed by the same letter (small) are not different (P<0.05).
Table 2.10: Mean Percentage of Bound Phenolics (BP%) of Corn Growing in Three Years at Five Processing Stages a,b,c
Year Processing Stages
Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
2009 72.92±0.06A,a
73.52±0.69A,a
70.22±0.65B,a
70.34±0.79B,a
63.58±1.44C,a
2010 73.72±2.49A,a
74.87±1.01A,a
70.23±1.00B,a
69.70±0.34B,a
63.30±0.71C,a
2011 77.24±1.32A,a
74.59±1.02A,a
71.10±0.91B,a
70.04±1.09B,a
66.58±0.17C,a
Stage Mean 73.96±1.57A 74.33±0.85
A 70.52±0.16
B 70.03±0.58
B 64.49±0.61
C
a Values expressed as mean ± standard error of three corn hybrids with three replications which are duplicate analyzed.
b Means in the same row followed by the same letter (capital) are not different (P<0.05).
c Means in the same column followed by the same letter (small) are not different (P<0.05).
47
Table 2.11: Mean Soluble, Bound, and Total Phenolics, and Percentage of Bound Phenolics
(BP%) of Three Commercial Corn Hybrids during Five Processing Stages (µg gallic acid
equivalents/g sample) a,b
Phenolics Processing Stages
Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
Soluble 617±2B 591±46
B 538±37
C 541±36
C 710±62
A
Bound 1785±145A 1732±207
A 1298±102
B 1271±104
B 1294±97
B
Total 2403±131A 2324±252
A 1837±139
C 1812±139
C 2004±157
B
BP% 73.96±1.57A 74.33±0.85
A 70.52±0.16
B 70.03±0.58
B 64.49±0.61
C
a Values expressed as mean ± standard error of three hybrids grown in three years with three
replications per year, and with duplicate phenolic analysis per replication. b
Means in the same row followed by the same letter are not different (P<0.05).
48
2.6. Figures
Figure 2.1: Soluble Phenolic Contents of Corn during the flaking procedure.
Figure 2.2: Soluble Phenolic Contents of Three Corn Hybrids during the Corn-Flaking Procedure.
200
250
300
350
400
450
500
550
600
650
700
750
800
850
Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
Solu
ble
Ph
en
olic
Co
nte
nt
(µg
galli
c ac
id
eq
uiv
ale
nts
/g s
amp
le)
0
100
200
300
400
500
600
700
800
900
Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
Solu
ble
Ph
en
olic
Co
nte
nt
(µg
galli
c ac
id
eq
uiv
ale
nts
/g s
amp
le)
Hybrid A
Hybrid B
Hybrid C
49
Figure 2.3: Soluble Phenolic Contents of Corn Grown in Three Years during the Corn-Flaking
Procedure.
Figure 2.4: Bound Phenolic Contents during the Corn-Flaking Procedure.
0
100
200
300
400
500
600
700
800
Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
Solu
ble
Ph
en
olic
Co
nte
nt
(µg
galli
c ac
id
eq
uiv
ale
nts
/g s
amp
le 2009
2010
2011
400
550
700
850
1000
1150
1300
1450
1600
1750
1900
2050
Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
Bo
un
d P
he
no
lic C
on
ten
t (µ
g ga
llic
acid
e
qu
ival
en
ts/g
sam
ple
)
50
Figure 2.5: Bound Phenolic Contents of Three Corn Hybrids during the Corn-Flaking Procedure.
Figure 2.6: Bound Phenolic Content of Corn Grown in Three Years during the Corn-Flaking
Procedure.
0
200
400
600
800
1000
1200
1400
1600
1800
2000
2200
2400
Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
Bo
un
d P
he
no
lic C
on
ten
t (µ
g ga
llic
acid
e
qu
ival
en
ts/g
sam
ple
Hybrid A
Hybrid B
hybrid C
0
200
400
600
800
1000
1200
1400
1600
1800
2000
2200
Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
Bo
un
d P
he
no
lic C
on
ten
t (µ
g ga
llic
acid
e
qu
ival
en
ts/g
sam
ple
2009
2010
2011
51
Figure 2.7: Total Phenolic Contents during the Corn-Flaking Procedure.
Figure 2.8: Total Phenolic Contents of Three Corn Hybrids during the Corn-Flaking Procedure.
500
700
900
1100
1300
1500
1700
1900
2100
2300
2500
2700
Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
Tota
l Ph
en
olic
Co
nte
nt
(µg
galli
c ac
id
eq
uiv
ale
nts
/g s
amp
le)
0
300
600
900
1200
1500
1800
2100
2400
2700
3000
3300
Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
Tota
l Ph
en
olic
Co
nte
nt
(µg
galli
c ac
id
eq
uiv
ale
nts
/g s
amp
le)
Hybrid A
Hybrid B
Hybrid C
52
Figure 2.9: Total Phenolic Content of Corn Grown in Three Years during the Corn-Flaking
Procedure.
Figure 2.10: Percentage of Bound Phenolics of Corn during the Flaking Procedure.
0
300
600
900
1200
1500
1800
2100
2400
2700
3000
Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
Tota
l Ph
en
olic
Co
nte
nt
(µg
galli
c ac
id
eq
uiv
ale
nts
/g s
amp
le) 2009
2010
2011
58.00
60.00
62.00
64.00
66.00
68.00
70.00
72.00
74.00
76.00
78.00
Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
Pe
rce
nta
ge o
f B
ou
nd
Ph
en
olic
s (%
)
53
Figure 2.11: Soluble, Bound, and Total Phenolic Contents of Corn during the Flaking Procedure.
0
250
500
750
1000
1250
1500
1750
2000
2250
2500
2750
Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
Ph
en
olic
Co
nte
nt
(µg
galli
c ac
id
eq
uiv
ale
nts
/g s
amp
le)
Soluble
Bound
Total
54
CHAPTER 3: ANTIOXIDANT CAPACITY OF CORN AS AFFECTED BY GROWTH
YEAR AND CORN FLAKE PROCESSING STAGES
3.1. Introduction
Potential antioxidants in corn include carotenoids (Kurilich & Juvik, 1999; Kopsell et al.,
2009), phytosterols (Piironen et al., 2000; Yoshida & Niki, 2003), tocopherols (Kurilich & Juvik,
1999), ascorbic acid (Dewanto et al., 2002), anthocyanins (Li et al., 2008; Pedreschi & Cisneros-
Zevallos, 2007), and other phenolic compounds (Pedreschi & Cisneros-Zevallos, 2007; Ramos-
Escudero et al., 2012). According to Adom & Liu (2002), total antioxidant activity of corn was
181.42 μmol Vitamin C equiv/g, which was higher than that of wheat, rice, and oats. Phenolics
in corn possess considerable antioxidant activity in vitro, and are able to delay the cellular
damage induced by oxidative stress (Rice-Evans et al., 1997; Adom & Liu, 2002; Alía et al.,
2006a; Hu & Xu, 2011; Žilić et al., 2012). Total antioxidant activity of corn is closely related to
phenolic content (R2=0.983), especially for bound phenolics (R
2=0.991) (Adom & Liu, 2002). A
significant positive correlation between corn total phenolic content and oxygen radical
absorbance capacity (ORAC) was also established (r=0.83) by Bacchetti et al. (2013).
Attributed to their antioxidant capacity, phenolics are considered to have the potential in
preventing several chronic diseases. It is reported that phenolic compounds in corn have anti-
mutagenic capacity, which is achieved by mechanisms of blocking or scavenging mutagen
electrophiles and inhibiting enzymes involved in mutagen activation (Pedreschi & Cisneros-
Zevallos, 2006). Moreover, various phenolic compounds are able to suppress the proliferation of
several types of cancer cells in vitro, including ovarian (Scambia et al., 1994; Peng et al., 2008),
colon (Agullo et al., 1994; Yi et al., 2005), breast (Mehta et al., 1997; Kampa et al., 2004), lung
(Caltagirone et al., 1997), and liver cancer cells (Tanaka et al., 1993; Chi et al., 1997). Also,
55
phenolic compounds are able to suppress LDL oxidation and have a protective impact on heart
disease, through possible mechanisms such as scavenging oxidizing species and binding LDL
protein (Frankel et al., 1993; Ishikawa et al., 1997; Geleijnse et al., 1999; Kerry & Abbey, 1999;
Wang & Goodman, 1999; Chang et al., 2000; Duthie et al., 2000).
As a major health-enhancing function, antioxidant activity of corn has been widely studied;
however, no study has been focused on the antioxidant activity in corn flakes. Hence, the
objectives of this chapter were to investigate how antioxidant capacity is altered during the corn-
flaking procedure, and examine the growing year effect on antioxidant capacity in corn. Since
there is removal of phenolic concentrated corn fractions during dry-milling and there are
potential losses in phenolics under thermal treatment, decreased antioxidant capacity was
expected during the corn-flaking procedure.
3.2. Materials and Methods
3.2.1. Sample Preparation
Commercial corn hybrid A grown in 2009, 2010, and 2011 with three replications per year
was used in this study. Samples of whole kernels, flaking grits, cooked grits, baked grits, and
toasted flakes were collected from each corn-flaking processing stage. Samples were dried and
ground into powder using a coffee grinder.
3.2.2. Chemicals and Reagents
AAPH (2,2’-azobis (2-methylpropionamidine) dihydrochloride), Trolox ((±)-6-hydroxy-
2,5,7,8-tetramethylchromane-2-carboxylic acid) and fluorescein were purchased from Sigma-
Aldrich (St. Louis, MO). Potassium phosphate monobasic was obtained from Fisher Scientific
56
(Fair Lawn, NJ), and potassium phosphate dibasic trihydrate was obtained from Acros Organics
(Fair Lawn, NJ).
3.2.3. Determination of Antioxidant Capacity
A modified oxygen radical absorbance capacity (ORAC) assay was used to determine the
antioxidant capacity of corn samples, based on the original method described by Cao & Prior
(1998) and modified by Dávalos et al. (2004) and Wu et al. (2004). ORAC assays were carried
out in a FL600 microplate fluorescence reader (BioTek Inc., VT) with AAPH (12 mM) as
peroxyl radical generator, fluorescein (70.3 nM) as fluorescent probe, and trolox (0-4 μM) as
antioxidant standard. Trolox was prepared in AWA (acetone: water: acetic acid = 140:59:1); all
other reagents were prepared in 75 mM phosphate buffer, pH 7. Extracts from 0.10 g corn
samples were evaporated to dryness and reconstituted in 10 mL AWA. Another 15% dilution
was made to the corn extracts (in 10 mL AWA) before ORAC assays.
Fluorescein (120 μL) and diluted corn extract or trolox standard solution (20 μL) were added
to a 96 well plate, and pre-incubated at 37°C (15 min). To avoid positional errors, a set layout
was used for filling wells (Table 3.1). Reaction was started by adding 60 μL AAPH solution
rapidly to each well using two multi-channel pipets, and the microplate was placed in the
fluorescence reader maintained at 37°C to monitor fluorescence changes. Peroxyl radicals,
generated from thermal degradation of AAPH, would induce fluorescein oxidation. Antioxidant
capacity was expressed as the degree of inhibition of fluorescence loss by scavenging peroxyl
radicals (Bacchetti et al., 2013). Fluorescence was measured every min for 80 min (emission
wavelength 515 nm and excitation wavelength 493 nm). The plate was automatically shaken for
3 s at intensity 3 before every reading. Area under the fluorescence decay curve (AUC) values
57
were calculated and expressed as micromoles Trolox Equivalents (TE) per gram sample.
Triplicate analyses were conducted for each sample.
3.2.4. Statistical Analysis
Analysis of variance (ANOVA) was performed to determine the effect of growing year,
biological replication and processing stage on antioxidant capacity of corn samples using the
generalized linear mixed model (GLMM). Processing stage was treated as fixed effects, while
growing year and replication nested within year were treated as random effects. A generalized
linear model (GLM) was used to conduct ANOVA for antioxidant capacity of corn samples at
each processing stage, separately. Mean values were compared using the Tukey’s multiple
comparison test at 5% level. Regression analysis between phenolic content and antioxidant
capacity was also conducted. Analyses were performed using the Statistical Analysis System
(SAS), version 9.4 (SAS institute, Cary, NC).
3.3. Results
3.3.1. Growing Year and Processing Effects on Antioxidant Capacity
Effects of processing stages and replicates within years were both significant for antioxidant
capacity of corn, but the year effect was not significant (Table 3.2). Interaction of processing
stages by replicates within years was significant, while the interaction between processing stages
and years was not. The complete ANOVA tables for antioxidant capacity were listed in the
Appendix A.
Differences in antioxidant capacity were observed between corn grown in year 2009 and
2010 or 2011 for every individual processing stage (Table 3.3 & Figure 3.1). Antioxidant
58
capacity of corn hybrid A grown in 2009 was lower than corn grown in 2010 at processing stages
of flaking grits, cooked grits, baked grits, and toasted flakes. There was no difference in
antioxidant capacity between whole kernels grown in 2009 and 2010. Antioxidant capacity of
corn grown in 2009 was also lower than corn grown in 2011 at all processing stages, with
exception of baked grits. No difference was observed between corn grown in 2010 and 2011,
except for the whole kernel stage, in which corn grown in 2011 had higher antioxidant capacity
than that of grown in 2010. Due to the different yearly ranking in antioxidant capacity of
different processing stages, the overall yearly effect was not significant while that for every
individual processing stage was significant.
Analysis of processing impact on antioxidant capacity was presented with years combined
(Table 3.3). When whole kernels were dry milled into flaking grits, a decrease in antioxidant
capacity occurred. Another reduction in antioxidant capacity was observed when the flaking grits
were cooked at 15 psi for 60 minutes to produce cooked grits. The subsequent corn-flaking
process did not further change the antioxidant capacity of corn samples; there was no difference
in antioxidant capacity among cooked grits, baked grits, and toasted flakes.
3.3.2. Correlations between antioxidant capacity and phenolic content
Phenolic compounds, especially bound phenolics, are significant contributors to the
antioxidant capacity in corn (Adom & Liu, 2002). Significant correlations were observed
between antioxidant capacity and soluble, bound, and total phenolics in corn (Table 3.4). There
was a weak overall correlation (R2=0.11) between antioxidant capacity and soluble phenolic
content of corn from five processing stages, while a high correlation (R2=0.66) was noted
59
between antioxidant capacity and bound phenolic content. Antioxidant capacity was also highly
correlated to the total phenolic content in corn (R2=0.60).
For individual processing stage analysis, no significant linear relationship was observed
between antioxidant capacities and soluble, bound, and total phenolic contents in corn whole
kernels (Table 3.4). High linear correlations were observed with soluble phenolics and
antioxidant capacity in corn flaking grits (R2=0.64) and cooked grits (R
2=0.70). Correlations
became weaker in baked grits (R2=0.45) and toasted grits (R
2=0.32). Linear correlations between
antioxidant capacity and bound phenolics in flaking grits (R2=0.75), cooked grits (R
2=0.70),
baked grits (R2=0.63), and toasted flakes (R
2=0.61) were all significant. Significant linear
relationships were also observed between total phenolics and antioxidant capacity in flaking grits
(R2=0.76), cooked grits (R
2=0.76), baked grits (R
2=0.59), and toasted flakes (R
2=0.62).
3.4. Discussion
3.4.1. Effects of Growing Year and Processing Stage on Antioxidant Capacity
Commercial hybrid A was used in this study to predict the effects of growing year and
processing stage on antioxidant capacity of corn. Similar to phenolics, variation in antioxidant
capacity was also significantly influenced by corn-flaking processing stage (Table 3.2), since
there is a large contribution of phenolics to antioxidant capacity of corn (Adom & Liu, 2002).
The influence of growing years on antioxidant capacity was not significant, which was consistent
with results obtained by Harakotr et al. (2015), who found that growing season showed small
effect on antioxidant activity of waxy corn. However, substantial year-to-year variation occurred
in every individual processing stage (Table 3.3). For the original whole kernels, antioxidant
capacity of corn grown in 2011 was higher than in 2009 and 2010. Different climate conditions
60
among different growing years, such as different ultraviolet radiation, temperature, water stress,
and mineral nutrient availability may influence the phenolic content and antioxidant activity of
corn (Connor et al., 2002; Jing et al., 2007). The non-significant processing stage × year
interaction indicated that the trend of changes in antioxidant capacity of corn during corn-flaking
was able to predict their performances in other years (Harakotr et al., 2015). Variation for
antioxidant capacity was significant among replicates within years, and a substantial processing
stage × replicate within year interaction was also observed, which indicated that the effects of
growing year and processing stage may be better predicted with more biological replications
(Connor et al., 2005). Additionally, since a significant interaction of genotype × processing stage
was observed in phenolics, more hybrids from diverse genetic background would be needed to
have a comprehensive understanding of the processing effects on antioxidant capacity in corn.
3.4.2. Changes in Antioxidant Capacity during Corn-Flaking Procedure
ORAC assay was used in our study to measure the potencies of antioxidants to protect
biological molecules from being attacked by free radicals, which could represent the antioxidant
activities of antioxidants (Zhou & Yu, 2004; Li et al., 2007). Our results showed that mean
ORAC values of corn whole kernels was 50.06±2.00 μmol TE/g sample (Table 3.3), which was
consistent with the values of 45.00 and 48.89 μmol TE/g sample reported by Li et al. (2007) for
two typical corn types, but much higher than that reported by Bacchetti et al. (2013). After whole
kernels were dry-milled into flaking grits, the antioxidant capacity decreased significantly. This
may be due to the loss of antioxidants located in the pericarp and germ such as anthocyanins and
free phenolic acids; these two fractions were removed during dry milling (Sen et al., 1994;
Betran, 2000; Moreno et al., 2005).
61
Continuous decrease in antioxidant capacity occurred when the flaking grits were cooked,
which was in agreement with results reported by Harakotr et al. (2014). According to Dewanto et
al. (2002), total antioxidant capacity of cooked yellow sweet corn decreased with extended
cooking time, as a result of increased antioxidant capacity of soluble phenolic extracts and
decreased antioxidant capacity of bound phenolic extracts. In the present study, the decrease in
antioxidant capacity during cooking was attributed to both decreased soluble and bound phenolic
contents. Harakotr et al. (2014) indicated that loss in corn antioxidant activity during cooking
was mainly attributed to the breakdown of antioxidant compounds. Antioxidants may also
participate in reactions that occur during cooking, such as scavenging free radicals generated in
lipid oxidation (Culbertson, 2004), and thus induce a loss in total antioxidant capacity.
There was no difference in antioxidant capacity between cooked grits and baked grits, due to
the unchanged phenolic content during baking. However, the antioxidant capacity of toasted
flakes still remained unchanged from baked grits, while a significant increase in total phenolics
was observed during toasting (Table 2.7). This may be explained by the results of research
conducted by Ohta et al. (1994) that soluble-conjugated ferulic acids possessed stronger
antioxidant activity than the released ferulic acids. The temperatures treated for cooking and
baking would induce the release of bound phenolics into soluble ones; however, most of the
released phenolics were in soluble-conjugated form (Dewanto et al., 2002). During toasting, a
temperature of 204.4°C was applied, under which auto-hydrolysis reaction occurred, and soluble-
conjugated phenolics were liberated into free form (Saulnier et al., 2001). Thus, although total
phenolics of corn flakes increased during toasting, the antioxidant capacity did not arise with
increased phenolics due to the lowered antioxidant capacity of released free phenolic acids (Ohta
et al., 1994).
62
In conclusion, cooking was the critical point for antioxidant capacity changes during corn-
flaking procedure. Antioxidant capacity decreased during dry-milling and cooking, and remained
unchanged during baking and toasting.
3.4.3. Correlations between Antioxidant Capacity and Phenolic Content
Significant linear correlations were observed between antioxidant capacities and soluble
(R2=0.11), bound (R
2=0.66), and total phenolic contents (R
2=0.60) (Table 3.4). Since the
majority of phenolics in corn were in bound form, antioxidant capacity was closely associated
with bound phenolic content, while a low correlation was presented for soluble phenolics, which
was consistent with the results reported by Adom & Liu (2002). The highest correlations
between antioxidant capacity and soluble, bound, and total phenolics were observed in flaking
grits and cooked grits. After the grits were further processed, correlations between bound
phenolics and antioxidant capacity slightly decreased due to the gradually released bound
phenolic compounds during thermal processing. The significant decrease in correlations between
soluble phenolics and antioxidant capacity in baked grits and toasted grits may result from the
lowered antioxidant activity of free phenolics released from soluble-conjugated phenolics (Ohta
et al., 1994). The presence of antioxidants other than phenolics in the pericarp and germ, and the
different proportions of these antioxidants in corn kernels may be the reason of the low
correlations presented between antioxidant capacity and whole kernel phenolic contents. Another
reason might be the limited variation between whole kernel samples used for the correlation
analysis, which were from the same corn hybrid with similar original phenolic contents. Samples
collected from different hybrids with various phenolic contents are better to be used for the
correlation analysis between antioxidant capacity and phenolic content in future studies.
63
Additionally, we also observed that for samples with the same total phenolic content, whole
kernel samples always possessed higher antioxidant capacity than the other processed samples,
while antioxidant capacity of toasted grits were always lower than the other corn samples. This
may be explained by the decreased contribution of other antioxidants such as ascorbic acids to
total antioxidant capacity during thermal processing, in which they were destroyed significantly
(Dewanto et al., 2002).
64
3.5. Tables
Table 3.1: Set Layout for Filling 96-Wells Microplate a,b
Blank Blank 1 2 3 4 4 3 2 1 Blank Blank
Blank 1 A B C D D C B A 1 Blank
Blank 1 B C D A A D C B 1 Blank
Blank 1 C D A B B A D C 1 Blank
Blank 1 D A B C C B A D 1 Blank
a 1-4 represent trolox of 1-4 µM.
b A-D represent corn extract samples 1-4.
Table 3.2: Analysis of Variance for Antioxidant Capacity of Corn Hybrid A Growing in
Different Years at Different Processing Stages a
Source DF Mean Square Error DF F value Pr > F
ProcessingStage 4 1389.11 8 37.58 <0.0001
Year 2 637.49 5.12 3.56 0.1073
Rep(year) 6 189.56 24 3.98 0.0067
ProcessingStage×Year 8 36.97 24 0.78 0.6277
ProcessingStage×Rep(year) 24 47.66 90 7.42 <0.0001
Residual 90 6.42 - - - a Analysis of variance is performed using the generalized linear mixed model (GLMM).
Table 3.3: Antioxidant Capacity of Corn Hybrid A at Five Processing Stages in Different
Growing Years (μmol Trolox equiv/g sample) a,b,c
Growing
years
Processing Stages
Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
2009 47.26±2.43A,b
36.51±1.50AB,b
28.75±1.01B,b
32.04±2.30B,b
30.25±2.11B,b
2010 48.97±1.13A,b
46.01±1.03B,a
36.27±1.38C,a
36.36±0.95C,a
38.01±0.96C,a
2011 53.95±1.16A,a
47.16±2.08B,a
34.89±1.95C,a
34.90±1.67C,ab
38.05±1.55C,a
Stage Mean 50.06±2.00A 43.23±3.38
B 33.30±2.31
C 34.43±1.27
C 35.43±2.59
C
a Values expressed as mean ± standard error of three replications per year with triplicate analysis.
b Means in the same row followed by the same letter (capital) are not different (P<0.05).
c Means in the same column followed by the same letter (small) are not different (P<0.05).
65
Table 3.4: Correlation Analysis of Antioxidant Capacity (AC) and Soluble Phenolics, Bound
Phenolics, and Total Phenolics of Corn Hybrid A from Different Processing Stages a,b,c
Phenolic Content Soluble Phenolics Bound Phenolics Total Phenolics
Total AC
Whole Kernel 0.0001 0.0007 0.0004
Flaking Grits 0.6392**
0.7545**
0.7578***
Cooked Grits 0.7039**
0.7018**
0.7633***
Baked Grits 0.4477* 0.6280
** 0.5853
**
Toasted Flakes 0.3208 0.6112**
0.6167**
Overall 0.1087* 0.6573
*** 0.6019
***
a Values listed as correlation coefficient R-square.
b *,**, and *** indicate significance at p<0.05, p<0.01, and p<0.001, respectively.
c For each processing stage, correlations are based on n = 10; For overall item, correlations are
based on n = 50.
3.6. Figures
Figure 3.1: Antioxidant Capacity of Corn during the Flaking Procedure.
0.00
10.00
20.00
30.00
40.00
50.00
60.00
Whole Kernel Flaking Grits Cooked Grits Baked Grits Toasted Flakes
An
tio
xid
ant
Cap
acit
y (μ
mo
l Tro
lox
eq
uiv
/g s
amp
le)
2009
2010
2011
66
CHAPTER 4: EFFECT OF PROCESSING CONDITIONS ON THE PHENOLIC
CONTENT OF CORN FOR PRODUCTION OF CORN FLAKES
4.1. Introduction
Epidemiological studies have suggested that regular consumption of breakfast cereals would
help in reducing the risks of obesity and cardiovascular diseases (Geliebter et al., 2015). Corn is
a common source of grains to produce ready-to-eat breakfast cereals, whose phenolic content
was higher than rice, wheat, and oats (Adom & Liu, 2002). Corn contains a large variety of
phenolics, which are the major contributors of antioxidant activity in corn (Velioglu et al., 1998;
Hu & Xu, 2011).
Previous studies have been conducted to evaluate how processing impacted phenolics in corn.
Under thermal treatment, in-soluble bound phenolics tended to be released mainly into soluble-
conjugated phenolics. An enzymatic treatment, chemical treatment or a severe heat treatment
with a temperature higher than 180°C was needed to further liberate the soluble-conjugated
phenolics into free form (Saulnier et al., 2001; Dewanto et al., 2002). According to Parra et al.
(2007), bound ferulic acids in corn were released into free and soluble-conjugated ferulic acids
during lime-cooking for production of corn masa. However, with masa baked into tortilla and
fried into tortilla chips, ferulic acids were complexed again. Losses in phenolics may also occur
during thermal treatment due to degradation or decomposition of phenolic compounds (Harakotr
et al., 2014). More information was needed about the overall effect of processing on phenolics in
production of corn flakes.
The average nutritional quality of ready-to-eat breakfast cereals in the market has been
declining since the late 1980s (Wang et al., 2015). Improving the nutritional values of corn flakes
is needed to meet the needs of consumers. Hence, the objective of this chapter was to better
67
understand how processing conditions of corn-flaking impact phenolics, in order to provide
information for elevating the phenolic content in final flake product. Our hypothesis is that
optimization of processing conditions is feasible to obtain corn flakes with a higher phenolic
level. Higher temperature and pressure applied with extended time may help in liberating more
phenolics from the cell wall materials of corn.
4.2. Materials and Methods
4.2.1. Sample Preparation
Corn samples of commercial hybrid A grown in 2009 were used for this study. Flaking grits
samples were cooked under a pressure of 15 psi for 45, 60, 75, and 90 min, and cooked under a
pressure of 5 and 10 psi for 60 min. Samples cooked 60 min under a pressure of 15 psi were
baked at 225°F (107.2°C) for 30, 40, 50, and 60 min; and at 200°F (93.3°C), 250°F (121.1°C),
and 275°F (135.0°C) for 50 min. For toasting, samples cooked 60 min at 15 psi and baked at
225°F (107.2°C) for 50 min were subjected to different treatments. These baked samples were
toasted at 400°F (204.4°C) for 60, 70, 80, and 90s, and at 300°F (148.9°C), 350°F (176.7°C), and
450°F (232.2°C) for 80s. Three replications were conducted for each treatment. All samples were
dried and ground into powder using a coffee grinder.
4.2.2. Chemicals and Reagents
Folin-Ciocalteu reagent, gallic acid, and sodium carbonate were purchased from Sigma
Chemical Company (St. Louis, MO). Sodium chloride, sodium hydroxide, hydrochloric acid,
hexane, ethyl acetate, methanol, and acetone were obtained from Fisher Scientific (Fair Lawn,
68
NJ). Ethanol was purchased from Decon Labs (King of Prussia, PA). Salt, sugar, and molasses
were purchased from a local supermarket.
4.2.3. Extraction of Phenolic Compounds
Methods used to extract soluble and bound phenolic compounds in corn samples were
described in section 2.2.4 and section 2.2.5., respectively.
4.2.4. Determination of Phenolic Content
Methods for determination of phenolic content in corn were described in section 2.2.6.
4.2.5. Statistical Analysis
Analysis of variance (ANOVA) was performed to determine the effect of processing
conditions on phenolic content of corn samples using the generalized linear model (GLM). Mean
values were compared using the Fisher’s Least Significant Difference (LSD) test at 5% level.
Analyses were performed using the Statistical Analysis System (SAS), version 9.4 (SAS institute,
Cary, NC).
4.3. Results
4.3.1. Effect of Pressure Cooking Conditions on Phenolic Content in Corn
4.3.1.1. Effect of Pressure Cooking Time on Phenolic Content in Corn
The soluble phenolic content of raw flaking grits was 605 µg GAE/g sample (Table 4.1 &
Figure 4.1). After cooking at 15 psi for 45 minutes, the soluble phenolic content of these grits
was 636 µg GAE/g, indicating no significant change with cooking. With increased cooking time
69
at 15 psi for 60, 75, and 90 minutes, soluble phenolic content dropped to 629, 579, and 533 µg
GAE /g, respectively. The difference in soluble phenolics between cooking times of 45 and 60
minutes was not significant. However, significant reductions were noted when cooking time
increased to 75 and 90 minutes.
The bound phenolic content of raw flaking grits was 1726 µg GAE/g. After grits were
cooked at 15 psi for 45 minutes, the bound phenolic content dropped significantly to 1026 µg
GAE /g. There was an increase in bound phenolics when cooking time was extended from 45 to
60 minutes. However, with increased cooking time at 15 psi for 75 and 90 minutes, bound
phenolic content decreased significantly from that of the 60 minute cooked grits.
The total phenolic content of raw flaking grits was 2331 µg GAE/g. Subsequent cooking
process at 15 psi for 45 minutes induced a decrease in total phenolics of grits to 1662 µg GAE/g.
When pressure cooking time was increased from 45 to 60 minutes, a significant increase in total
phenolics was observed. However, after 60 minutes, extended cooking times of 75 and 90
minutes resulted in reduced total phenolic content.
There were no significant differences in bound phenolic percentages among flaking grits
cooked for 60, 75, and 90 minutes. The percentage of bound phenolics of grits cooked for 45
minutes was lower than the other cooked grit samples with longer cooking time.
4.3.1.2. Effect of Pressure Cooking Pressure on Phenolic Content in Corn
The soluble phenolic content of raw flaking grits was 605 µg GAE/g of sample (Table 4.2 &
Figure 4.2). After cooking for 60 minutes at 5 psi, soluble phenolic content of these grits
decreased to 462 µg GAE/g. However, with cooking pressure increased from 5 to 10 and then 15
psi, soluble phenolic content significantly increased again.
70
The bound phenolic content of raw flaking grits was 1726 µg GAE/g of sample. After
cooking for 60 minutes at 5 psi, bound phenolic content of these grits decreased to 883 µg
GAE/g. There was no difference in bound phenolic content between corn grits cooked for 60
minutes at 5 and 10 psi. However, a significant increase was observed when cooking pressure
was increased to 15 psi.
The total phenolic content of raw flaking grits was 2331 µg GAE/g. Subsequent cooking at 5
psi for 60 minutes resulted in a decrease in total phenolics to 1345 µg GAE/g of sample.
However, with cooking pressure increased from 5 to 10 psi, and from 10 to 15 psi, significant
increases in total phenolic content were observed.
There was no significant difference in bound phenolic percentage between grits cooked at 10
psi and 15 psi. The bound phenolic percentage of flaking grits cooked at 5 psi was significantly
higher than that of grits cooked at 10 and 15 psi.
4.3.2. Effect of Baking Conditions on Phenolic Content in Corn
4.3.2.1. Effect of Baking Time on Phenolic Content in Corn
After pressure cooking at 15 psi for 60 minutes, the soluble phenolic content of cooked grits
was 629 µg GAE/g (Table 4.3 & Figure 4.3). Subsequent baking at 225°F for 30 minutes
resulted in decreased soluble phenolic content in these cooked grits, but with extended baking
time, soluble phenolic content in grits increased again. There was no difference in soluble
phenolic content between grits baked for 30 and 50 minutes. Cooked grits baked for 40 minutes
had higher soluble phenolic content than 30 and 50 minute treatments. The soluble phenolic
content of cooked grits baked at 225°F for 60 minutes was higher than the other baking time
treatments.
71
The bound phenolic content of flaking grits cooked at 15 psi for 60 minutes was 1119 µg
GAE/g. These cooked grits were baked at 225°F for 30 minutes subsequently, and the bound
phenolic content decreased to 891.91 µg GAE/g. However, with increased baking time from 30
to 40 minutes and to 50 minutes, bound phenolic content of these baked grits increased again.
There was no difference in bound phenolic content between grits baked for 50 and 60 minutes at
225°F (107.2°C).
The total phenolic content of flaking grits cooked at 15 psi for 60 minutes was 1749 µg
GAE/g. After baking at 225°F for 30 minutes, the total phenolic content of these grits decreased
to 1303 µg GAE/g of sample. However, with baking time increased from 30 to 40 minutes, a
significant increase in total phenolic content of grits was observed. No difference in total
phenolic content was noted between grits baked for 40 and 50 minutes. When baking time was
extended to 60 minutes, another increase in total phenolic content was observed.
With baking time extended from 30 to 40 minutes, bound phenolic percentage significantly
decreased. There was no difference in bound phenolic percentage between grits baked for 40 and
60 minutes.
4.3.2.2. Effect of Baking Temperature on Phenolic Content in Corn
After pressure cooking at 15 psi for 60 minutes, the soluble phenolic content of cooked grits
was 629.21 µg GAE/g (Table 4.4 & Figure 4.4). Subsequent baking at 200°F for 50 minutes
resulted in decreased soluble phenolic content in these cooked grits to 399 µg GAE/g. There was
no difference in soluble phenolic content between grits baked at 200 and 225°F. However, with
increased baking temperature from 225 to 250°F, and to 275°F, significant increases in soluble
phenolic content were observed.
72
The bound phenolic content of flaking grits cooked at 15 psi for 60 minutes was 1119 µg
GAE/g. Subsequent baking at 200°F for 50 minutes induced a significant reduction in bound
phenolic content to 933 µg GAE/g. With baking temperature increased from 200 to 225°F, bound
phenolic content in grits significantly increased. After that, no difference in bound phenolic
content was observed among grits baked at 225, 250, and 275°F for 50 minutes.
The total phenolic content of flaking grits cooked at 15 psi for 60 minutes was 1749 µg
GAE/g. After baking at 200°F for 50 minutes, the total phenolic content of these corn grits
dropped to 1332 µg GAE/g of sample. With baking temperature increased from 200 to 225, 250,
and 275°F, significant increases in total phenolic content were observed between every two
treatments.
There was no difference in bound phenolic percentage between grits baked at 200 and 225°F.
Significant reductions in bound phenolic percentage were observed when baking temperature
was increased from 225 to 250 and 275°F.
4.3.3. Effect of Toasting Conditions on Phenolic Content in Corn
4.3.3.1. Effect of Toasting Time on Phenolic Content in Corn
The soluble phenolic content of grits cooked at 15 psi for 60 minutes and then baked at
225 °F for 50 minutes was 418 µg GAE/g, which was not different from the soluble phenolic
content obtained after they were toasted for 60 seconds at 400°F (Table 4.5 & Figure 4.5).
When toasting time was increased from 60 to 70 seconds, an increase in soluble phenolic content
was observed. No difference was noted between corn flakes toasted for 70 and 80 seconds. With
toasting time increase to 90 seconds, another increase in soluble phenolic content was observed.
73
The bound phenolic content of grits cooked at 15 psi for 60 minutes and then baked at 225°F
for 50 minutes was 980 GAE/g of sample. After the baking process for 60 seconds at 400°F, the
bound phenolic content dropped to 906 GAE/g. When toasting time was increased from 60 to 70
seconds, an increase in bound phenolic content was observed. There was no difference in bound
phenolic content between corn flakes toasted for 70 and 80 seconds. When toasting time was
increased to 90 seconds, another increase in bound phenolic content was observed.
The total phenolic content of grits cooked at 15 psi for 60 minutes and then baked at 225°F
for 50 minutes was 1398 µg GAE/g, which was not different from the total phenolic content
obtained after they were toasted for 60 seconds at 400°F. With toasting time extended from 60 to
70 seconds, an increase in total phenolic content was presented. There was no difference in total
phenolic content between corn flakes toasted for 70 and 80 seconds. When toasting time was
increased to 90 seconds, another increase in total phenolic content was observed.
There was a decrease in bound phenolic percentage when toasting time was extended from
60 to 70 seconds. No difference in bound phenolic percentage was observed between flakes
toasted for 70 and 80 seconds. With toasting time extended from 80 to 90 seconds, another
reduction was noted in bound phenolic percentage.
4.3.3.2. Effect of Toasting Temperature on Phenolic Content in Corn
The soluble phenolic content of corn samples cooked at 15 psi for 60 minutes and then baked
at 225 °F for 50 minutes was 418 µg GAE/g (Table 4.6 & Figure 4.6). After toasting at 300°F
for 80 seconds, the soluble phenolic content of corn flakes increased to 492 µg GAE/g. With
increased toasting temperature from 300 to 350°F, the soluble phenolic content of corn flakes
significantly increased. No difference was noted between flakes toasted at 350 and 400°F. When
74
toasting temperature was increased from 400 to 450°F, another increase in soluble phenolic
content of corn flakes was observed.
The bound phenolic content of grits cooked at 15 psi for 60 minutes and baked at 225 °F for
50 minutes was 980 GAE/g. The subsequent toasting process at 300°F for 80 seconds did not
induce a difference to the bound phenolic content of corn samples. When the toasting
temperature increased from 300 to 350°F, bound phenolic content in corn flakes decreased
significantly. No difference was observed with continuously increased toasting temperature from
350 to 400 and 450°F.
The total phenolic content of grits cooked at 15 psi for 60 minutes and baked at 225°F for 50
minutes was 1398 µg GAE/g. After toasting at 300°F for 80 seconds, the total phenolic content
of these corn samples increased to 1525 µg GAE/g. However, with increased toasting
temperature from 300 to 350, 400, and 450°F, no difference in total phenolic content of corn
flakes was observed.
When toasting temperature was increased from 300 to 350°F, a significant reduction in
bound phenolic percentage was observed. There was no difference between corn flakes toasted at
350 and 400°F. Another decrease in bound phenolic percentage was observed when toasting
temperature increased from 400 to 450°F.
4.4. Discussion
4.4.1. Effect of Pressure Cooking Conditions on Phenolic Content in Corn
After flaking grits were cooked 45 minutes at 15 psi, the bound phenolic content decreased,
while soluble phenolic content remained the same (Table 4.1). This decrease in bound phenolic
percentage indicated the release of bound phenolics into free and soluble-conjugated phenolics
75
during thermal processing, which was consistent with what observed by Dewanto et al. (2002).
With extended pressure cooking time (except for 60 minutes), both soluble and bound phenolics
in corn declined, which was in good agreement with the results reported by Harakotr et al. (2014),
who found significant losses in phenolics during both boiling and steam cooking in purple waxy
corn. The increase in bound phenolics when grits were cooked from 45 to 60 minutes may be
explained by the disruption of cell wall matrix after long-time cooking that more firmly bound
phenolics were exposed and able to be measured. Dewanto et al. (2002) also described the
release of bound phenolic acids from the breakdown of cellular constituents during thermal
processing. After cooking 60 minutes, increased cooking time did not further alter the bound
phenolic percentage, which meant that release of bound phenolics no longer occurred. However,
losses in phenolics still occurred, which indicated the continuous breakdown of phenolic
compounds during thermal treatment (Harakotr et al., 2014). It may also indicate that the
treatment condition of 15 psi was not able to expose more firmly bound phenolics from cell wall
components after 60 minutes of cooking.
On the other hand, soluble and bound phenolic contents both significantly increased with
enhanced cooking pressure (Table 4.2), indicating that a proper cooking pressure would help in
liberating more bioavailable phenolics from the cell wall complex. According to Butz et al.
(2003), 30 minute pressurization with thermal treatment induced a 25% degradation of
antioxidant capacity in apple juice, while only 10% degradation occurred with thermal treatment
alone (Sanchez-Moreno et al., 2009). Although greater degradation of phenolics would occur
under more severe cooking conditions (Hiemori et al., 2009), the rate of bound phenolic
liberation was still higher than phenolic degradation, thus, there was an increase in phenolic
76
contents in our study. Thus, cooking at 15 psi for 60 minutes was found to be an optimal cooking
condition for producing higher phenolic contents in processed corn products.
4.4.2. Effect of Baking Conditions on Phenolic Content in Corn
Grits cooked 60 minutes at 15 psi were used to examine the effect of different baking
conditions on phenolic content in corn. In chapter 2, the results indicated no significant
difference in phenolics between cooked grits and baked grits (Table 2.15), and we hypothesized
that release of bound phenolics may occur together with the degradation of phenolic compounds,
which finally resulted in the unchanged phenolic contents during baking. These were confirmed
by the results showed in Table 4.3, in which a significant decrease was observed for both soluble
and bound phenolics in grits baked for 30 minutes at 225°F, compared to unbaked grits. Phenolic
contents significantly increased again with extended baking time. These indicated that a large
amount of phenolic compounds were degraded or decomposed under thermal treatment during
baking (Patras et al., 2010); however, after a long baking time, the cell wall network was
gradually disrupted (Zivanovic & Buescher, 2004), from which more bound phenolics were
liberated. After baking 30 minutes, the liberation rate became higher than degradation; this
resulted in increased phenolic contents with extended baking time.
With increased baking temperature, bound phenolic percentage decreased significantly
(Table 4.4), indicating that more bound phenolics were released into soluble phenolics under
higher heating temperature. During baking, phenolic antioxidants tended to be oxidized to
quinones and their polymers, while the esters and glucosides of antioxidants were prone to be
hydrolyzed (Nayak et al., 2015). Other reactions such as Maillard reaction, caramelization, and
Strecker degradation would also occur, which may result in the loss of phenolic compounds
77
during baking. As shown in Chen & Lin (2007), losses of total phenolic contents in yams
increased with enhanced heating temperature. However, with more firmly bound phenolics
liberating from cell wall networks with increasing temperature, phenolics still increased
significantly. Randhir et al. (2008) indicated that the increase in total phenolic content during
thermal processing may be the result of disassociation of conjugated phenolics followed by
polymerization or oxidation of phenolic constituents.
Although more phenolic compounds were obtained in processed corn samples with increased
baking temperature and baking time, the moisture content of baked grits may become too low to
be further processed into flakes if exposed to a high temperature for too long. Hence, moisture
contents should be also taken into account while choosing optimal baking conditions.
4.4.3. Effect of Toasting Conditions on Phenolic Content in Corn
During toasting, bound phenolics were further released into soluble phenolics with extended
toasting time (Table 4.5), while soluble-conjugated phenolics were also auto-hydrolyzed into
free phenolics (Saulnier et al., 2001; Dewanto et al., 2002). Increases in both soluble and bound
phenolic contents indicated the presence of alkali-stable bound phenolics in the cell wall matrix,
which were able to be liberated by thermal treatment. Hassan & Youssef (2012) also reported the
increases in total phenolics and antioxidant activity of white beans during toasting with extended
time, which was consistent with our results. The unchanged total phenolic contents with
increasing toasting temperature (Table 4.6) indicated that the amount of bound phenolics
liberated from the cell wall network highly depended on toasting time, while higher temperature
did not result in faster liberation. However, increased temperature did assist in releasing bound
phenolics that could be alkaline hydrolyzed during extraction into soluble phenolics, which
78
resulted in a lower bound phenolic percentage. Jannat et al. (2013) examined the effects of
roasting conditions on Iranian sesame seeds, and also found significantly increased total phenolic
and γ-tocopherol contents with enhanced roasting time and temperature, until the temperature
reached 200°C. Temperatures higher than 200°C would induce higher losses in phenolics.
During toasting, Maillard reaction may also occur. Additionally, the temperature was also
reached for caramelization of sugars (mainly sucrose) which were added as ingredients before
cooking, to further generate desired color and flavor for the final flakes (Culbertson, 2004).
Hence, color and flavor attributes of flakes were also important parameters while choosing the
optimum toasting time and temperature. Although extended toasting time is able to produce more
bioavailable phenolics, over-toasting may result in undesired brown color in flakes.
Solubilized phenolic compounds in foods are able to be absorbed in the human stomach and
small intestine (Acosta-Estrada et al., 2014), and enter the circulatory system to induce health-
enhancing functions such as preventing coronary heart diseases (Morton et al., 2000) and anti-
inflammation (Jiang & Dusting, 2003). High bioavailability in vivo was demonstrated for soluble
phenolics, while a fast absorption was observed in 15 minutes for hydrolyzed Trichilia emetica
phenolic extracts (Germanò et al., 2006). Bound phenolics are also bioavailable, and capable of
posing beneficial effects on human health (Pérez-Jiménez et al., 2009). It was demonstrated by
Andreasen et al. (2001) that esterases in the human gastrointestinal (GI) tract were able to release
the esterified diferulates in orally ingested cereal brans into free diferulic acid, which could be
absorbed and participate in peripheral circulation. Adom & Liu (2002) indicated that insoluble-
bound phenolics in grains may survive digestion of the upper GI tract and reach the colon, thus
pose beneficial health effects on preventing colon cancer. In humans, more than 95% of the total
release of feruloyl groups from wheat bran occurred in the colon, in which they were fermented.
79
Esterified feruloyl groups were solubilized through the activities of ferulic acid esterase and
xylanase from the microflora in the human GI tract (Kroon et al., 1997). Other phenolic acid
esters such as chlorogenic acids that were esters of caffeic and quinic acids could also be
released through colonic microflora (Plumb et al., 1999). Hence, soluble and bound phenolics
function towards different targets in human body to promote different health effects. Whether
higher temperature is needed to release more bound phenolics into soluble ones during toasting
depends on different demands for health-promoting effects.
Alkaline hydrolysis is the most common method to release the cell wall-linked bound
phenolics in corn (Adom & Liu, 2002; Dewanto et al., 2002; Parra et al., 2007; Lopez-Martinez
et al., 2009; Žilić et al., 2012), reducing the loss of corn ferulic acids from 78% to 4.8%
compared with acid hydrolysis (Krygier et al., 1982). However, increases in total phenolics
during thermal processing in our study indicated that alkaline hydrolysis may still not be able to
release all the bound phenolics from the cell wall components, thus the bound phenolics reported
may be underestimated. Future studies are needed to examine a more effective way to
disintegrate the cell wall matrix, and have the insoluble-bound phenolics in corn liberated and
prone to be extracted. On the other hand, since those firmly-bound alkali-stable phenolics, as
well as other heat-resistant phenolic cross-links may not be able to be released and absorbed in
human body (Scalbert & Williamson, 2000), the bound phenolic contents obtained through
alkaline hydrolysis in our study may represent the bioavailable bound phenolics present in corn.
In this study, we only examined the effects of processing conditions on phenolics in corn.
The effects of processing conditions on antioxidant capacity in corn need to be further
investigated. Based on the results obtained in chapters 2 and 3, we predict that higher cooking
pressure would facilitate an increase in antioxidant capacity of corn, while longer cooking time
80
may cause loss in antioxidants. Increased baking temperature and time may enhance the
antioxidant capacity of corn; however, toasting with higher temperature or longer time may not
make changes to the antioxidant capacity of corn flakes.
81
4.5. Tables
Table 4.1: Effect of Pressure-Cooking Time on Phenolic Content in Corn (µg gallic acid
equivalents/g sample) a,b
Pressure Time Soluble Phenolics Bound Phenolics Total Phenolics BP%c
15 psi
0 min 605±52a 1726±6
a 2331±58
a 74.10±1.58
a
45 min 636±2a 1026±14
c 1662±16
c 61.72±0.25
c
60 min 629±10a 1119±16
b 1749±26
b 64.01±0.12
b
75 min 579±10b 1027±6
c 1606±14
c 63.93±0.34
b
90 min 533±11c 972±4
d 1505±15
d 64.59±0.37
b
Whole kernels 561±7 1674±96 2236±103 74.91±0.86 a Values expressed as mean ± standard error of three replications.
b Means in the same column followed by the same letter are not different (p<0.05).
c BP% = Bound phenolics / Total phenolics × 100%
Table 4.2: Effect of Pressure-Cooking Pressure on Phenolic Content in Corn (µg gallic acid
equivalents/g sample) a,b
Time Pressure Soluble Phenolics Bound Phenolics Total Phenolics BP% c
60 min
5 psi 462±5c 883±18
b 1345±22
c 65.64±0.26
a
10 psi 548±6b 937±17
b 1486±18
b 63.09±0.49
b
15 psi 629±10a 1119±16
a 1749±26
a 64.01±0.12
b
Whole kernels 561±7 1674±96 2236±103 74.91±0.86 a Values expressed as mean ± standard error of three replications.
b Means in the same column followed by the same letter are not different (p<0.05).
c BP% = Bound phenolics / Total phenolics × 100%
Table 4.3: Effect of Baking Time on Phenolic Content in Corn (µg gallic acid equivalents/g
sample) a,b
Temp Time Soluble Phenolics Bound Phenolics Total Phenolics BP% c
225 °F
0 min 629±10a 1119±16
a 1749±26
a 64.01±0.12
d
30 min 411±6d 892±6
d 1303±12
d 68.43±0.23
b
40 min 465±18c 933±11
c 1398±21
c 66.73±0.91
c
50 min 418±12d 980±12
b 1398±24
c 70.10±0.33
a
60 min 511±10b 1001±12
b 1512±21
b 66.20±0.21
c
Whole kernels 561±7 1674±96 2236±103 74.91±0.86 a Values expressed as mean ± standard error of three replications.
b Means in the same column followed by the same letter are not different (p<0.05).
c BP% = Bound phenolics / Total phenolics × 100%
82
Table 4.4: Effect of Baking Temperature on Phenolic Content in Corn (µg gallic acid
equivalents/g sample) a,b
Time Temp Soluble Phenolics Bound Phenolics Total Phenolics BP% c
50 min
200 °F 399±5c 933±8
b 1332±12
d 70.06±0.19
a
225 °F 418±12c 980±12
a 1398±24
c 70.10±0.33
a
250 °F 521±11b 965±11
ab 1487±22
b 64.93±0.23
b
275 °F 595±13a 985±7
a 1579±21
a 62.36±0.35
c
Whole kernels 561±7 1674±96 2236±103 74.91±0.86 a Values expressed as mean ± standard error of three replications.
b Means in the same column followed by the same letter are not different (p<0.05).
c BP% = Bound phenolics / Total phenolics × 100%
Table 4.5: Effect of Toasting Time on Phenolic Content in Corn (µg gallic acid equivalents/g
sample) a,b
Temp Time Soluble Phenolics Bound Phenolics Total Phenolics BP% c
400 °F
0 s 418±12d 980±12
a 1398±24
c 70.10±0.33
a
60 s 451±7c 906±7
c 1356±14
c 66.77±0.18
b
70 s 547±12b 950±14
b 1496±25
b 63.45±0.26
c
80 s 547±14b 947±11
b 1494±25
b 63.39±0.36
c
90 s 669±16a 985±10
a 1655±26
a 59.55±0.36
d
Whole kernels 561±7 1674±96 2236±103 74.91±0.86 a Values expressed as mean ± standard error of three replications.
b Means in the same column followed by the same letter are not different (p<0.05).
c BP% = Bound phenolics / Total phenolics × 100%
Table 4.6: Effect of Toasting Temperature on Phenolic Content in Corn (µg gallic acid
equivalents/g sample) a,b
Time Temp Soluble Phenolics Bound Phenolics Total Phenolics BP% c
80 s
300 °F 492±11c 1033±18
a 1525±28
a 67.74±0.20
a
350 °F 547±14b 951±10
b 1498±24
a 63.51±0.38
b
400 °F 547±14b 947±11
b 1494±25
a 63.39±0.36
b
450 °F 623±14a 932±6
b 1555±20
a 59.92±0.40
c
Whole kernels 561±7 1674±96 2236±103 74.91±0.86 a Values expressed as mean ± standard error of three replications.
b Means in the same column followed by the same letter are not different (p<0.05).
c BP% = Bound phenolics / Total phenolics × 100%
83
4.6. Figures
Figure 4.1: Effect of Pressure-Cooking Time on Phenolic Content in Corn (at pressure of 15 psi)
Figure 4.2: Effect of Pressure-Cooking Pressure on Phenolic Content in Corn (cooking for 60
min)
0
200
400
600
800
1000
1200
1400
1600
1800
2000
2200
2400
0 min 45 min 60 min 75 min 90 min
Ph
en
olic
Co
nte
nt
(µg
galli
c ac
id e
qu
ival
en
ts/g
sa
mp
le)
Soluble
bound
total
0
200
400
600
800
1000
1200
1400
1600
1800
2000
5 psi 10 psi 15 psi
Ph
en
olic
Co
nte
nt
(µg
galli
c ac
id
eq
uiv
ale
nts
/g s
amp
le)
Soluble
Bound
Total
84
Figure 4.3: Effect of Baking Time on Phenolic Content in Corn (at a temperature of 225 °F)
Figure 4.4: Effect of Baking Temperature on Phenolic Content in Corn (baking for 50 min)
0
200
400
600
800
1000
1200
1400
1600
1800
2000
0 min 30 min 40 min 50 min 60 min
Ph
en
olic
Co
nte
nt
(µg
galli
c ac
id e
qu
ival
en
ts/g
sa
mp
le)
Soluble
Bound
Total
0
200
400
600
800
1000
1200
1400
1600
1800
200 ⁰F 225 ⁰F 250 ⁰F 275 ⁰F
Ph
en
olic
Co
nte
nt
(µg
galli
c ac
id
eq
uiv
ale
nts
/g s
amp
le)
Soluble
Bound
Total
85
Figure 4.5: Effect of Toasting Time on Phenolic Content in Corn (at a temperature of 400 °F)
Figure 4.6: Effect of Toasting Temperature on Phenolic Content in Corn (Toasting for 80 s)
0
200
400
600
800
1000
1200
1400
1600
1800
0 s 60 s 70 s 80 s 90 s
Ph
en
olic
Co
nte
nt
(µg
galli
c ac
id e
qu
ival
en
ts/g
sa
mp
le)
Soluble
Bound
Total
0
200
400
600
800
1000
1200
1400
1600
1800
300 ⁰F 350 ⁰F 400 ⁰F 450 ⁰F
Ph
en
olic
Co
nte
nt
(µg
galli
c ac
id
eq
uiv
ale
nts
/g s
amp
le) Soluble
Bound
Total
86
CHAPTER 5: CONCLUSIONS AND FUTURE STUDIES
5.1. Conclusions
In this study, commercial corn hybrids A, B, and C that were grown in three different years
with three replicates per year were processed into corn flakes through five major processing
stages. The effects of genotype, growing year, and processing on phenolics and antioxidant
capacity in corn were examined. The hypotheses of this research are that processing will impact
on phenolic content and antioxidant capacity of corn, and corn flakes with higher phenolic
content can be obtained with optimized processing conditions.
This study of changes in soluble, bound, and total phenolics in three commercial corn hybrids
demonstrated significant variations among genotypes and processing stages, together with
significant genotype × processing stage and genotype × replicate within year interactions. The
non-significant year effect and genotype × year interaction indicated the feasibility of breeding
corn for higher phenolic concentration. More replicates may help in improving the estimates of
genotype, year, and processing stage effects.
The trend of phenolic changing during production of corn flakes was discussed in this study.
During thermal processing, bound phenolics tended to be released into soluble phenolics, and
more firmly bound phenolics in the cell wall matrix were able to be liberated. Cooking and
toasting were the two critical processing points to induce phenolic changes during production of
corn flakes. Total phenolic content significantly decreased during cooking with breakdown of
phenolic compounds, and significantly increased again during toasting with increased soluble
phenolics and more exposed bound phenolics from the disrupted cell wall network.
Corn commercial hybrid A was used to predict the effects of growing year and processing
stage on antioxidant capacity of corn. Significant variation in antioxidant capacity was presented
87
among five corn-flaking processing stages and replicates within years, but not among growing
years. More hybrids from diverse genetic background would be needed to have a comprehensive
understanding of the year and processing effects on antioxidant capacity in corn.
The ORAC assay was used to measure the antioxidant capacity of corn samples. Significant
losses in antioxidant capacity were observed during dry-milling and pressure cooking, due to the
removal of pericarp and germ fractions which contained concentrated free phenolic acids and
flavonoids, and the breakdown of antioxidants under thermal treatment. Baking and toasting did
not significantly alter the antioxidant capacity of corn. Hence, we conclude that processed corn
flakes had lower antioxidant capacity than raw corn kernels. Significant linear correlations were
observed between antioxidant capacities and soluble, bound, and total phenolic contents in corn.
However, antioxidant capacity was more closely related to the bound phenolics rather than
soluble phenolics. Correlations also varied for different corn-flaking processing stages.
The effects of processing conditions on phenolic content in corn were also examined in this
study. Total phenolic content in corn decreased with extended pressure cooking time, but were
enhanced with higher cooking pressure. Increased baking time and temperature would induce
significant increase in phenolics. Extended toasting time could also liberate more bound phenolic
compounds to increase total phenolic content, but higher temperature in toasting did not help in
faster liberation. Our findings may help in optimizing the processing conditions for higher
phenolic content and antioxidant capacity in corn flakes. Soluble and bound phenolics are both
bioavailable, but are absorbed in different parts of human GI tract. Hence, the ideal phenolic
form for ingestion depends on different demands of health-promoting effects.
88
5.2. Recommendations for Future Studies
1. Future studies are needed to examine a more effective way to measure the overall bound
phenolics in corn. We found in our study that alkaline hydrolysis that we used in bound phenolic
extraction may not be able to release all the firmly bound phenolics from the cell wall matrix.
Thus, bound phenolic contents reported may be underestimated. A new method is needed to
disintegrate the cell wall matrix, and have more insoluble-bound phenolics in corn liberated and
prone to be extracted.
2. More corn hybrids were better to be used in predicting the effect of corn-flaking
processing on antioxidant capacity. A significant interaction of genotype × processing stage was
observed in phenolics, which indicated that different corn hybrids may performed differently in
phenolic changes during corn-flaking procedure. Since the high correlation of phenolics and
antioxidant capacity, same interaction may also occur between genotype and antioxidant capacity.
Hence, more hybrids from diverse genetic background would be needed to have a comprehensive
understanding of the processing effects on antioxidant capacity in corn.
3. The effects of processing conditions on antioxidant capacity of processed corn could be
further examined in a future study. This research only explored how phenolics changed with
different treatment conditions during cooking, baking, and toasting. However, according to our
results, changes in antioxidant capacity during corn-flaking may perform differently from
phenolics. Hence, it will be better to see how antioxidant capacity was altered by different
processing conditions, and thus with more information to choose the optimal combinations.
4. An overall optimization of corn-flaking processing conditions could be done in future
studies to obtain higher phenolics and antioxidant capacity in final flake products. This study
only involved single factor experiments in Chapter 4, but response surface methodology could be
89
used to further optimize the corn-flaking processing conditions. Other nutrient changes during
processing such as resistant starch, fibers, and vitamins, and final product attributes such as color,
flavor, and crispness are also needed to be measured and taken into account in the overall
optimization.
5. Data obtained in this study needs to be compared with that of commercial corn flakes.
Since in this study, a lab scale method was used to produce corn flakes, differences in the final
attributes and nutritional levels may present between lab-produced corn flakes and commercial
corn flakes. Data comparison is needed to see if the results obtained in this study are applicable
in the industry.
90
BIBLIOGRAPHY
Abdel-Aal, E.-S. M., Young, J. C., & Rabalski, I. (2006). Anthocyanin composition in black,
blue, pink, purple, and red cereal grains. Journal of Agricultural and Food Chemistry, 54,
4696-4704.
Acosta-Estrada, B. A., Gutiérrez-Uribe, J. A., & Serna-Saldívar, S. O. (2014). Bound phenolics
in foods, a review. Food Chemistry, 152, 46-55.
Adom, K. K., & Liu, R. H. (2002). Antioxidant activity of grains. Journal of Agricultural and
Food Chemistry, 50, 6182-6187.
Agullo, G., Gamet, L., Besson, C., Demigne, C., Demigne, C., & Remesy, C. (1994). Quercetin
exerts a preferential cytotoxic effect on active dividing colon carcinoma HT29 and Caco-
2 cells. Cancer Letters, 87, 55-63.
Alía, M., Mateos, R., Ramos, S., Lecumberri, E., Bravo, L., & Goya, L. (2006a). Influence of
quercetin and rutin on growth and antioxidant defense system of a human hepatoma cell
line (HepG2). European Journal of Nutrition, 45(1), 19-28.
Alía, M., Ramos, S., Mateos, R., Gramado-Serrano, A. B., Bravo, L., & Goya, L. (2006b).
Quercetin protects human hepatoma HepG2 against oxidative stress induced by tert-butyl
hydroperoxide. Toxicology and Applied Pharmacology, 212(2), 110-118.
Ames, B. (1989). Endogenous DNA damage as related to cancer and aging. Mutation Research,
214(1), 41-6.
Andreasen, M. F., Kroon, P. A., Williamson, G., & Garcia-Conesa, M. T. (2001). Esterase
activity able to hydrolyze dietary antioxidant hydroxycinnamates is distributed along the
intestine of mammals. Journal of Agricultural and Food Chemistry, 49(11), 5679-84.
91
Andreasen, M. F., Kroon, P. A., Williamson, G., & Garcia-Conesa, M-T. (2001). Intestinal
release and uptake of phenolic antioxidant diferulic acids. Free Radical Biology and
Medicine, 31(3), 304-314.
Asanoma, M., Takahashi, K., Miyabe, M., Yamamoto, K., Yoshimi, N., Mori, H., & Kawazoe, Y.
(1993). Inhibitory effect of topical application of polymerized ferulic acid, a synthetic
lignin, on tumor promotion in mouse skin two stage tumorigenesis. Carcinogenesis, 14,
1321-1325.
Bacchetti, T., Masciangelo, S., Micheletti, A., & Ferretti, G. (2013). Carotenoids, phenolic
compounds and antioxidant capacity of five local Italian corn (Zea Mays L.) kernels.
Journal of Nutrition and Food Science, 3(6), 237.
Bartłomiej, S., Justyna, R. K., & Ewa, N. (2011). Bioactive compounds in cereal grains -
occurrence, structure, technological significance and nutritional benefits - a review. Food
Science and Technology International, 18(6), 559-568.
Belitz, H.-D., Grosch, W., & Schieberle, P. (2009). Lipids. Food Chemistry (pp. 158-246). Berlin,
Heidelberg: Spring-Verlag.
Bentsáth, A., Rusznyák, S. T., & Szent-Györgyi, A. (1936). Vitamin nature of flavones. Nature,
138, 798-798.
Betran, J., Bocholt, A. J., & Rooney, L. W. (2000). Blue corn. In A. R. Hallauer (Ed.), Speciality
Corns (pp. 293−301). Boca Raton, FL: CRC Press.
Bettini, V., Fiori, A., Martino, R., Mayellaro, R. & Ton, P. (1985). Study of the mechanism
whereby anthocyanosides potentiate the effect of catecholamines on coronary vessels.
Fitoterapia, 54(2), 67-72.
92
Butz, P., Garcı́a, A. F., Lindauer, R., Dieterich, S., Bognár, A., & Tauscher, B. (2003). Influence
of ultra high pressure processing on fruit and vegetable products. Journal of Food
Engineering, 56(2-3), 233-236.
Caldwell, E. F., & Fast, R. B. (1990). The cereal grains. In R. B. Fast, & E. F. Caldwell (Eds.),
Breakfast Cereal and How They Are Made (pp. 1-34). St. Paul, MN: American
Association of Cereal Chemists, Inc.
Caldwell, E. F., Fast, R. B., Lauhoff, C., Miller, R. C. (1990). Unit operations and equipment. I.
Blending and cooking. In R. B. Fast, & E. F. Caldwell (Eds.), Breakfast Cereals and How
They Are Made (pp. 56-78). St. Paul, MN: American Association of Cereal Chemists, Inc.
Caltagirone, S., Ranelletti, F. O., Rinelli, A., Maggiano, N., Colasante, A., Musiani, P., Aiello, F.
B., & Piantelli, M. (1997). Interaction with type II estrogen binding sites and
antiproliferative activity of tamoxifen and quercetin in human non-small-cell lung cancer.
American Journal of Respiratory Cell & Molecular Biology, 17, 51-59.
Camire, M. E., Chaovanalikit, A., Dougherty, M. P., & Briggs, J. (2002). Blueberry and grape
anthocyanins as breakfast cereal colorants. Journal of Food Science, 67, 438-441.
Cao, G., & Prior, R. (1998). Comparison of different analytical methods for assessing total
antioxidant capacity of human serum. Clinical Chemistry, 44(6), 1309-1315.
Cardador-Martínez, A., Castaño-Tostado, E., & Loarca-Piña, G. (2002). Antimutagenic activity
of natural phenolic compounds present in the common bean (Phaseolus vulgaris) against
aflatoxin B1. Food Additives and Contaminants, 19(1), 62-9.
Carpentier, S., Knaus, M., & Suh, M. (2009) Associations between lutein, zeaxanthin, and age-
related macular degeneration: An overview. Critical Reviews in Food Science and
Nutrition, 49, 313−326.
93
Chander, S., Meng, Y., Zhang, Y., Yan, J., & Li, J. (2008). Comparison of nutritional traits
variability in selected eighty-seven inbreds from Chinese maize (zea mays L.) germplasm.
Journal of Agricultural and Food Chemistry, 56, 6506-6511.
Chang, S., Tan, C., & Frankel, E. N., & Barrett, D. M. (2000). Low-density lipoprotein
antioxidant activity of phenolic compounds and polyphenol oxidase activity in selected
clingstone peach cultivars. Journal of Agricultural and Food Chemistry, 48(2), 147-51.
Chaudhary, D. P., Kumar, S., & Yadav, O. P. (2014). Maize: Grain structure, composition,
milling, and starch characteristics. In D. Chaudhary, S. Kumar, & S. Langyan (Eds.),
Maize: Nutrition Dynamics and Novel Uses (pp.3-20). India: Springer.
Chaudhary, D. P., Kumar, S., & Yadav, O. P. (2014). Nutritive values of maize: improvements,
applications and constraints. In D. Chaudhary, S. Kumar, & S. Langyan (Eds.), Maize:
Nutrition Dynamics and Novel Uses (pp. 3-20). India: Springer.
Chen, Y-T., Lin, K-W. (2007). Effects of heating temperature on the total phenolic compound,
antioxidative ability and the stability of dioscorin of various yam cultivars. Food
Chemistry, 101(3), 955-963.
Cheresh, P., Kim, S. J., Tulasiram, S., & Kamp, D. W. (2012). Oxidative stress and pulmonary
fibrosis. Biochimica et Biophysica Acta, 1832(7), 1028-40.
Chi, C. W., Chang, Y. F., Ou, Y. R., Hsieh, C. C., Lui, Y. W., Peng, F. K., & Liu, T. Y. (1997).
Effect of quercetin on the in vitro and in vivo growth of mouse hepatoma cells. Oncology
Reports, 4, 1021-1024.
Chimi, H., Cillard, J., Cillard, P., Rahmani, M. (1991). Peroxyl and hydroxyl radical scavenging
activity of some natural phenolic antioxidants. Journal of the American Oil Chemists
Society, 68(5), 307-312.
94
Chism, G. W., Haard, N. F. (1996). Characteristics of edible plant tissues. In O. R. Fennema
(Ed.), Food Chemistry (pp. 943-1011). Dekker: New York.
Connor, A. M., Finn, C. E., Alspach, P. A. (2005). Genotypic and environmental variation in
antioxidant activity and total phenolic content among blackberry and hybridberry
cultivars. Journal of the American Society for Horticultural Science, 130(4), 527-533.
Connor, A. M., Luby, J. J., & Tong, C. (2002). Genotypic and environmental variation in
antioxidant activity, total phenolic content, and anthocyanin content among blueberry
cultivars. Journal of the American Society for Horticultural Science, 127(1), 89-97.
Cook, N. C., & Samman, S. (1996). Flavonoids-chemistry, metabolism, cardioprotective effects,
and dietary sources. Nutritional Biochemistry, 7, 66-76.
Culbertson, J. D. (2004). Grain, cereal: ready-to-eat breakfast cereals. In J. S. Smith & Y. H. Hui
(Eds.), Food Processing: Principles and Applications (pp. 239-248). Lowa, USA: Black
well Publishing Professional.
Dai, J., & Mumper, R. J. (2010). Plant phenolics: extraction, analysis and their antioxidant and
anticancer properties. Molecules, 15, 7313-7352.
Dávalos, A., Gómez-Cordovés, C., & Bartolomé, B. (2004). Extending applicability of the
oxygen radical absorbance capacity (ORAC-fluorescein) assay. Journal of Agricultural
and Food Chemistry, 52, 48-54.
Decker, E. A. (1997). Phenolics: prooxidants or antioxidants? Nutrition Reviews, 55(11), 396-
407.
Dewanto, V., Wu, X., & Liu, R. (2002). Processed sweet corn has higher antioxidant activity.
Journal of Agricultural and Food Chemistry, 50, 4959-4964.
95
Đorđević, T. M., Šiler-Marinković, S. S., & Dimitrijević-Branković, S. I. (2010). Effect of
fermentation on antioxidant properties of some cereals and pseudo cereals. Food
Chemistry, 119(3), 957-963.
Duthie, G. G., Duthie, S. J., & Kyle, J. A. M. (2000). Plant polyphenols in cancer and heart
disease: implications as nutritional antioxidants. Nutrition Research Reviews, 13, 79-106.
Duthie, S. J., Johnson, W., & Dobson, V. L. (1997). The effect of dietary flavonoids on DNA
damage (strand breaks and oxidized pyrimidines) and growth in human cells. Mutation
Research, 390, 141-151.
Dykes, L., & Rooney, L. W. (2007). Phenolic compounds in cereal grains and their health
benefits. Cereal Foods World, 52(3), 105-111.
Earl, F. R., Curtis, J. J., & Hubbard, J. E. (1946). Composition of the component parts of the corn
kernel. Cereal Chemistry, 23, 504-511.
Emmons, C. L., Peterson, D. M., & Paul, G. L. (1999). Antioxidant capacity of oat (Avena sativa
L.) extracts. 2. In vitro antioxidant activity and contents of phenolic and tocol
antioxidants. Journal of Agricultural and Food Chemistry, 47(12), 4894-4898.
Ewaidah, E. E., & Alkahtani, H. A. (1992). Nutrient composition and biological evaluation of
wheat flakes processed from Saudi wheat. Cereal Foods World, 37(5), 386-392.
Fast, R. B., & Caldwell, E. F. (2000). Breakfast cereals and how they are made (2nd ed.). St.
Paul, MN: American Association of Cereal Chemists.
Fausch, H., Kündig, W., & Neukom, H. (1963). Ferulic acid as a component of a glycoprotein
from wheat flour. Nature, 199(4890), 287.
Fazary, A. E., & Ju, Y.-H. (2007). Feruloyl esterases as biotechnological tools: Current and
future perspectives. Acta Biochimica et Biophysica Sinica, 39(11), 811-828.
96
Fink, B. N., Steck, S. E., Wolff, M. S., Britton, J. A., Kabat, G. C., Schroeder, J. C., Teitelbaum,
S. L., Neugut, A. I., & Gammon, M. D. (2007). Dietary flavonoid intake and breast
cancer risk among women on long island. American Journal of Epidemiology, 165(5),
514-523.
Frankel, E. N., Kanner, J., German, J. B., Parks, E., Kinsella, J. E. (1993). Inhibition of oxidation
of human low-density lipoprotein by phenolic substances in red wine. Lancet, 341(8843),
454-7.
Frankel, E. N. (2012). Free radical oxidation. Lipid oxidation (pp. 15-24). Cambridge, UK:
Woodhead Publishing Limited.
Frei, B., Stocker, R., & Ames, B. N. (1988). Antioxidant defense and lipid peroxidation in
human blood plasm. Proceedings of the National Academy of Sciences, 85, 9748-9752.
Geleijnse, J. M., Launer, L. J., Hofman, A., Pols, H. A., Witteman, J. C. (1999). Tea flavonoids
may protect against atherosclerosis: the Rotterdam Study. Archives of Internal Medicine,
159(18), 2170-4.
Geliebter, A., Grillot, C. L., Aviram-Friedman, R., Haq, S., Yahav, E., & Hashim, S. A. (2015).
Effects of oatmeal and corn flakes cereal breakfasts on satiety, gastric emptying, glucose,
and appetite-related hormone. Annals of Nutrition and metabolism, 66, 93-103.
Germanò, M. P., D’Angelo, V., Biasini, T., Sanogo, R., Pasquale, R. D., Catania, S. (2006).
Evaluation of the antioxidant properties and bioavailability of free and bound phenolic
acids from Trichilia emetica Vahl. Journal of Ethnopharmacology, 105(3), 368-373.
Giusti, M. M., & Wrolstad, R. E. (2003). Acylated acthocyanins from edible sources and their
applications in food systems. Biochemical Engineering Journal, 14, 217-225.
97
Goldberg, D. M., & Spooner, R. J. (1987). Glutathione reductase. In H. V. Bergmeyer (Ed.),
Methods of enzymatic analysis (pp. 258-265). Weinheim: Verlag-Chemie.
Grunwald, C. (1975). Plant sterols. Annual Review of Plant Physiology, 26(1), 209-236.
Halliwell, B. (1987). Oxidants and human disease: some new concepts. FASEB Journal, 1(5),
358-364.
Halliwell, B. (1994). Free radicals, antioxidants, and human disease: curiosity, cause or
consequence? Lancet, 344, 721-4.
Halliwell, B. (1995). Antioxidant characterization: methodology and mechanism. Biochemical
Pharmacology, 49(10), 1341-1348.
Harakotr, B., Suriharn, B., Scott, M. P., & Lertrat, K. (2015). Genotypic variability in
anthocyanins, total phenolics, and antioxidant activity among diverse waxy corn
germplasm. Euphytica, 203, 237-248.
Harakotr, B., Suriharn, B., Tangwongchai, R., Scott, M. P., Lertrat, K. (2014). Anothocyanin,
phenolics and antioxidant activity changes in purple waxy corn as affected by traditional
cooking. Food chemistry, 164, 510-517.
Harborne, J. B. (1976). Function of flavonoids in plants. In T. W. Goodwin (Ed.), Chemistry and
Biochemistry of Plant Pigmens (pp. 736-778). London, New York, San Francisco: Academic
Press.
Hassan, M., & Youssef, A. (2012). Effect of Toasting and Microwaving on gross chemical
composition, total phenolics, antioxidant activity and phenolic acids fractionation of
white beans flour (Phaseolus vulgaris L.). World Applied Science Journal, 18(6), 731-
736.
98
Heijnen, C. G., Haenen, G. R., Acker, F. A., Vijgh, W. J., & Bast, A. (2001). Flavonoids as
peroxynitrite scavengers: the role of the hydroxyl groups. Toxicology in Vitro, 15(1), 3-6.
Hertog, M. G. L., Feskens, E. J. M., Hollman, P. C. H., Katan, M. B., & Kromhout, D. (1994).
Dietary flavonoids and cancer risk in the Zutphen elderly study. Nutrition & Cancer, 22,
175-184.
Hiemori, M., Koh, E., & Mitchell, A. E. (2009). Influence of cooking on anthocyanins in black
rice (Oryza sativa L. japonica var. SBR). Journal of Agricultural and Food Chemistry,
57, 1908-1914.
Hopkins, C. G., Smith, L. H., & East, E. M. (1903). The structure of the corn kernel and the
composition of its different parts. Bulletin No. 87 (pp. 77-112). Urbana, IL: University of
Illinois Agricultural Experiment Station.
Hu, Q., & Xu, J. (2011). Profiles of carotenoids, anthocyanins, phenolics, and antioxidant
activity of selected color waxy corn grains during maturation. Journal of Agricultural
and Food Chemistry, 59, 2026-2033.
Ishii, T. (1997). Structure and functions of feruloylated polysaccharides. Plant Science, 127, 111-
127.
Ishikawa, T., Suzukawa, M., Ito, T., Yoshida, H., Ayaori, M., Nishiwaki, M., Yonemura, A.,
Hara, Y., & Nakamura, H. (1997). Effect of tea flavonoid supplementation on the
susceptibility of low density lipoprotein to oxidative modification. American Journal of
Clinical Nutrition, 66, 261-266.
Jacobo-VelÁzquez, D. A., & Cisneros-Zevallos, L. (2009). Correlations of antioxidant activity
against phenolic content revisited: a new approach in data analysis for food and
medicinal plants. Journal of Food Science, 74(9), R107-113.
99
Jannat, B., Oveisi, M. R., Sadeghi, N., Hajimahmoodi, M., Behzad, M., Nahavandi, B., Tehrani,
S., Sadeghi, F., & Oveisi, M. (2013). Effect of Roasting Process on Total Phenolic
Compounds and γ-tocopherol Contents of Iranian Sesame Seeds (Sesamum indicum).
Iranian Journal of Pharmaceutical Research, 12(4), 751-758.
Jayaprakasam, B., Olson, L. K., Schutzki, R. E., Tai, M. H., & Nair, M. G. (2006). Amelioration
of obesity and glucose intolerance in high-fat-fed C57BL/6 mice by anthocyanins and
ursolic acid in Cornelian cherry (Cornus mas). Journal of Agricultural and Food
Chemistry, 54(1), 243-8.
Jiang, F., & Dusting, G. J. (2003). Natural phenolic compounds as cardiovascular therapeutics:
potential role of their antiinflammatory effects. Current Vascular Pharmacology, 1(2),
135-56.
Jing, P., Bomser, J. A., Schwartz, S. J., He, J., Magnuson, B. A., & Giusti, M. M. (2008).
Structure−function relationships of anthocyanins from various anthocyanin-rich extracts
on the inhibition of colon cancer cell growth. Journal of Agricultural and Food
Chemistry, 56, 9391-9398.
Jing, P., Noriega, V., Schwartz, S. J., & Giusti, M. M. (2007). Effects of growing conditions on
purple corn cob (Zea mays L.) anthocyanins. Journal of Agricultural and Food Chemistry,
55, 8625-8629.
Jokić, S., Cvjetko, M., Božić, D., Fabek, S., Toth, N., Vorkapić-Furač, J., & Redovniković, I. R.
(2012). Optimisation of microwave-assisted extraction of phenolic compounds from
broccoli and its antioxidant activity. International Journal of Food Science & Technology,
47(12), 2613-2619.
100
Kamei, H., Kojima, T., Hasegawa, M., Koide, T., Umeda, T., Yukawa, T.; & Terabe, K. (1995).
Suppression of tumor cell growth by anthocyanins in vitro. Cancer Investigation, 13(6),
590-594.
Kampa, M., Alexaki, V. I., Notas, G., Nifli, A. P., Nistikaki, A., Hatzoqlou, A., Bakogeorgou, E.,
Kouimtzoglou, E., Blekas, G., Boskou, D., Gravanis, A., & Castanas, E. (2004).
Antiproliferative and apoptotic effects of selective phenolic acids on T47D human breast
cancer cells: potential mechanisms of action. Breast Cancer Research, 6(2), R63-74.
Kandhola, G. (2015). Processing and genetic effects on resistant starch in corn flakes
(unpublished master of science dissertation). University of Illinois at Urbana-Champaign,
IL.
Kanski, J., Aksenova, M., Stoyanova, A., Butterfield, D. A. (2002). Ferulic acid antioxidant
protection against hydroxyl and peroxyl radical oxidation in synaptosomal and neuronal
cell culture systems in vitro: structure-activity studies. Journal of Nutritional
Biochemistry, 13, 273-281.
Kashima, M. (1999). Effects of catechins on superoxide and hydroxyl radical. Chemical and
Pharmaceutical Bulletin, 47, 279-283.
Katan, M. B., Grundy, S. M., Jones, P., Law, M., Miettinen, T., & Paoletti, R. (2003). Efficacy
and safety of plant stanols and sterols in the management of blond cholesterol levels.
Mayo Clinic Proceedings, 78(8), 965-978.
Kato, R., Nakadate, T., Yamamoto, S., & Sugimura, T. (1983). Inhibition of 12-O-
tetradecanoylphorbol-13-acetate-induced tumor promotion and ornithine decarboxylase
activity by quercetin: possible involvement of lipoxygenase inhibition. Carcinogenesis,
4(10), 1301-1305.
101
Kawabata, K., Yamamoto, T., Hara, A., Shimizu, M., Yamada, Y., Matsunaga, K., Tanaka, T., &
Mori, H. (2000). Modifying effects of ferulic acid on azoxymethane-induced colon
carcinogenesis in F344 rats. Cancer Letters, 157, 15-21.
Kawai, M., Hirano, T., Higa, S., Arimitsu, J., Maruta, M., Kuwahara, Y., Ohkawara, T.,
Hagihara, K., Yamadori, T., Shima, Y., Ogata, A., Kawase, I., & Tanaka, T. (2007).
Flavonoids and related compounds as anti-allergic substances. Allergology International,
56(2), 113-23.
Kerry, N., & Abbey, M. (1999). The isoflavone genistein inhibits copper and peroxyl radical
mediated low density lipoprotein oxidation in vitro. Atherosclerosis, 140, 341-347.
Kim, H. K., Jeong, T. S., Lee, M. K., Park, Y. B., & Choi, M. S. (2003). Lipid-lowering efficacy
of hesperetin metabolites in high-cholesterol fed rats. Clinica Chimica Acta, 327(1-2),
129-137.
Kim, K.-H., Tsao, R., Yang, R., & Cui, S. W. (2006). Phenolic acid profiles and antioxidant
activities of wheat bran extracts and the effect of hydrolysis conditions. Food Chemistry,
95(3), 466-473.
King, D. L., Hahm, T. S., Min, D. B. (1993). Chemistry of antioxidants in relation to shelf life of
foods. Developments in Food Science, 33, 629-705.
Knekt, P., Heliövaara, M., Rissanen, A., Aromaa, A., &Aaran, R. (1992). Serum antioxidant
vitamins and risk of cataract. British Medical Journal, 305(6866), 1392−4.
Knievel, D. C., Abdel-Aal, E., Rabalski, I., Nakamura, T., & Hucl, P. (2009). Grain color
development and the inheritance of high anthocyanin blue aleurone and purple pericarp in
spring wheat (Triticum aestivum L.). Journal of Cereal Science, 50(1), 113-120.
102
Kopsell, D. A., Armel, G. R., Mueller, T. C., Sams, C. E., Deyton, D. E., Mcelroy, J. S., &
Kopsell, D. E. (2009). Increase in nutritionally important sweet corn kernel carotenoids
following mesotrione and atrazine applications. Journal of Agricultural and Food
Chemistry, 57, 6362-6368.
Kritchevsky, S. B. (1999). β-Carotene, carotenoids and the prevention of coronary heart disease.
The journal of nutrition, 129(1), 5-8.
Kroon, P. A., Faulds, C. B., Ryden, P., Robertson, J. A., & Williamson, G. (1997). Release of
covalently bound ferulic acid from fiber in the human colon. Journal of Agricultural and
Food Chemistry, 45, 661-667.
Krygier, K., Sosulski, F., & Hogge, L. (1982). Free, esterified, and insoluble-bound phenolic
acids. 1. Extraction and purification procedure. Journal of Agricultural and Food
Chemistry, 30(2), 330-334.
Kujawski, D.M. (1990). Designing flavors for breakfast cereals. Cereal Foods World, 35(3),
312-314.
Kurilich, A. C., & Juvik, J. A. (1999). Quantification of carotenoids and tocopherol antioxidants
in Zea mays. Journal of Agricultural and Food Chemistry, 47, 1948-1955.
Lagarda, M. J., Garcia-Llatas, G., & Farre, R. (2006). Analysis of phytosterols in foods. Journal
of Pharmaceutical and Biomedical Analysis, 41(5), 1486-1496.
Lawton, J. W., Wilson, C. M. (1987). Proteins of the kernel. In: L. A. Johnson & P. J. White
(Eds.), Corn chemistry and technology (pp. 313–354). St. Paul, MN: American
Association of Cereal Chemists.
103
Legaz, M., Armas, R., Piñón, D., & Vicente, C. (1998). Relationships between phenolics-
conjugated polyamines and sensitivity of sugarcane to smut (Ustilago scitaminea).
Journal of Experimental Botany, 49(327), 1723-1728.
Leopoldini, M., Marino, T., Russo, N., & Toscano, M. (2004). Antioxidant properties of
phenolic compounds: H-atom versus electron transfer mechanism. The Journal of
Physical Chemistry, 108, 4916-4922.
Li, C., Kim, H., Won, S., Min, H., Park, K., Park, J., Ahn, M., & Rhee, H. (2008). Corn husk as a
potential source of anthocyanins. Journal of Agricultural and Food Chemistry, 56,
11413-11416.
Li, W., Pickard, M. D., & Beta, T. (2007). Effect of thermal processing on antioxidant properties
of purple wheat bran. Food Chemistry, 104(3), 1080-1086.
Li, W., Wei, C., White, P. J., & Beta, T. (2007). High-amylose corn exhibits better antioxidant
activity than typical and waxy genotypes. Journal of Agricultural and Food Chemistry,
55, 291-298.
Ling, W. H., & Jones, P. J. (1995). Dietary phytosterols: a review of metabolism, benefits and
side effects. Life Sciences, 57(3), 195-206.
Lipkin, M., Reddy, B., Newmark, H., & Lamprecht, S. A. (1999). Dietary factors in human
colorectal cancer. Annual Review of Nutrition, 19, 545-586.
Liu, R. H. (2004). Potential Synergy of Phytochemicals in Cancer Prevention: Mechanism of
Action. The Journal of Nutrition, 134(12), 3479S-3485S.
Lopez-Martinez, L. X., Oliart-Ros, R. M., Valerio-Alfaro, G., Lee, C.-H., Parkin, K. L., &
Garcia, H. S. (2009). Antioxidant activity, phenolic compounds and anthocyanins content
of eighteen strains of Mexican maize. Food Science and Technology, 42, 1187-1192.
104
Lopez-Martinez, L. X., Parkin, K. L., & Garcia, H. S. (2012). Effect of processing of corn for
production of masa, tortillas and tortilla chips on the scavenging capacity of reactive
nitrogen species. International Journal of Food Science and Technology, 47, 1321-1327.
Lozovaya, V. V., Gorshkova, T. A., Rumyantseva, N. I., Ulanov, A. V., Valieva, A. I.,
Yablokova, E. V., Mei, C. S. & Widholm, J. M. (2000). Cell wall-bound phenolics in
cells of maize (Zea mays, Gramineae) and buckwheat (Fagopyrum tataricum,
Polygonaceae) with different plant regeneration abilities. Plant Science, 152, 79-85.
Luthria, D. L. (2008). Influence of experimental conditions on the extraction of phenolic
compounds from parsley (Petroselinum crispum) flakes using a pressurized liquid
extractor. Food Chemistry, 107, 745-752.
Luo, Y., & Wang, Q. (2012). Bioactive compounds in corn. In L. Yu, R. Tsao, & F. Shahidi
(Eds.), Cereals and Pulses: Nutraceutical properties and health benefits (pp. 85-103).
John Wiley & Sons, Inc.
Mahan, A. L., Murray, S. C., Rooney, L. W., Crosby, K. M. (2013). Combining ability for total
phenols and secondary traits in a diverse set of colored (red, blue, and purple) maize.
Crop Science, 53, 1248-1255.
Maliakal, P., & Wanwimolruk, S. (2001). Effect of herbal teas on hepatic drug metabolizing
enzymes in rats, Journal of Pharmacology and Pharmacotherapeutics, 53, 1323-1329.
Mehta, K., Pantazis, P., McQueen, T., & Aggarwal, B. B. (1997). Antiproliferative effect of
curcumin (diferuloylmethane) against human breast tumor cell lines. Anticancer Drugs, 8,
470-481.
Meyer, K., Kohler, A., & Kauss, H. (1991). Biosynthesis of ferulic acid esters of plant cell wall
polysaccharides in endomembranes from parsley cells. FEBS Letters, 290, 209-212.
105
Michaud, D.S., Feskanich, D., Rimm, E. B., Colditz, G. A., Speizer, F. E., Willett, W. C., &
Giovannucci, E. (2000). Intake of specific carotenoids and risk of lung cancer in 2
prospective US cohorts. American Journal of Clinical Nutrition, 72(4), 990-7.
Moghadasian, M. H., & Frohlich, J. J. (1999). Effects of dietary phytosterols on cholesterol
metabolism and atherosclerosis: clinical and experimental evidence. American Journal of
Medicine, 107, 588-594.
Mohsen, S. M., & Ammar, A. S. (2009). Total phenolic contents and antioxidant activity of corn
tassel extracts. Food Chemistry, 112, 595-598.
Montilla, E. C., Hillebrand, S., Antezana, A., & Winterhalter, P. (2011). Soluble and bound
phenolic compounds in different bolivian purple corn (Zea mays L.) cultivars. Journal of
Agricultural and Food Chemistry, 59, 7068-7074.
Moreno, Y. S., Sánchez, G. S., Hernández, D. R., & Lobato, N. R. (2005). Characterization of
anthocyanin extracts from maize kernels. Journal of Chromatographic Science, 43, 483-
487.
Morton, L. W., Caccetta, R. A., Puddey, I. B., & Croft, K. D. (2000). Chemistry and biological
effects of dietary phenolic compounds: relevance to cardiovascular disease. Clinical and
Experimental Pharmacology and Physiology, 27, 152-159.
Mota, K. S., Dias, G. E., Pinto, M. E., Luiz-Ferreira, A., Souza-Brito, A. R., Hiruma-Lima, C. A.,
Barbosa-Filho, J. M., & Batista, L. M. (2009). Flavonoids with gastroprotective activity.
Molecules, 14(3), 979-1012.
Murakami, C., Hirakawa, Y., Inui, H., Nakano, Y., & Yoshida, H. (2002). Effects of
epigallocatechin 3-O-gallate on cellular antioxidative system in HepG2 cells. Journal of
Nutritional Science and Vitaminology (Tokyo), 48(2), 89-94.
106
Naderi, G. A., Asgary, S., Sarraf-Zadegan, N., & Shirvany, H. (2003). Antioxidant effect of
flavonoids on the susceptibility of LDL oxidation. Molecular and Cellular Biochemistry,
246(1-2), 193-6.
Nair, H., Rao, K., Aalinkeel, R., Mahajan, S., Chawda, R., & Schwartz, S. (2004). Inhibition of
prostate cancer cell colony formation by the flavonoid quercetin correlates with
modulation of specific regulatory genes. Clinical and Diagnostic Laboratory
Immunology, 11(1), 63-69.
Nakao, M., Takio, S., Ono, K. (1998). Alkyl peroxyl radical-scavenging activity of catechins.
Phytochemistry, 49, 2379-2382.
Nayak, B., Liu, R., & Tang, J. (2015). Effect of processing on phenolic antioxidants of fruits,
vegetables, and grains-A review. Critical Reviews in Food Science and Nutrition, 55,
887-918.
Nohynek, L. J., Alakomi, H. L., Kähkönen, M. P., Heinonen, M., Helander, I. M., Oksman-
Caldentey, K. M., Puupponen-Pimiä, R. H. (2006). Berry phenolics: antimicrobial
properties and mechanisms of action against severe human pathogens. Nutrition &
Cancer, 54(1), 18-32.
Noroozi, M., Angerson, W. J., & Lean, M. E. J. (1998). Effects of flavonoids and vitamin C on
oxidative DNA damage to human lymphocytes. The American Journal of Clinical
Nutrition, 67, 1210-8.
Ohnishi, M., Matuo, T., Tsuno, T., Hosoda, A., Nomura, E., Taniguchi, H., Susaki, H ., &
Morishita, H. (2004). Antioxidant activity and hypoglycemic effect of ferulic acid in
streptozotocin induced diabetic mice and KK-AY mice. Biofactors, 21, 315-319.
107
Ohta T., Yamasaki, S., Egashira, Y., & Sanada, H. (1994). Antioxidant activity of corn bran
hemicellulose fragments. Journal of Agricultural and Food Chemistry, 42, 653-656.
Ostlund, R. E. Jr., Racette, S. B., Okeke, A., & Stenson, W. F. (2002). Phytosterols that are
naturally present in commercial corn oil significantly reduce cholesterol absorption in
humans. American Journal of Clinical Nutrition, 75, 1000-4.
Ou, L., Kong, L. Y., Zhang, X. M., & Niwa, M. (2003). Oxidation of ferulic acid by momordica
charantia peroxidase and related anti-inflammation activity changes. Biolofical and
Pharmaceutical Bulletin, 26, 1511-1516.
Ou, S., & Kwok, K. (2004). Ferulic acid: pharmaceutical functions, preparations and applications
in foods. Journal of the Science of Food and Agriculture, 84, 1261-1269.
Owen, R. W., Giacosa, A., Hull, W. E., Haubner, R., Spieqelhalder, B., & Bartsch, H. (2000).
The antioxidant/anticancer potential of phenolic compounds isolated from olive oil.
European Journal Cancer, 36(10), 1235-47.
Palozza, P., & Krinsky, N. I. (1992). Antioxidant effects of carotenoids in vivo and in vitro: an
overview. Methods in Enzymology, 213, 403-420.
Pandey, R., Singh, A., Maurya, S., Singh, U. P., & Singh, M. (2013). Phenolic acids in different
preparations of maize (Zea mays) and their role in human health. International Journal of
Current Microbiology and Applied Sciences, 2(6), 84-92.
Panfili, G., Fratianni, A., & Irano, M. (2004). Improved normal-phase high-performance liquid
chromatography procedure for the determination of carotenoids in cereals. Journal of
Agricultural and Food Chemistry, 52, 6373-6377.
108
Parra, C. D., Serna-Saldivar, S. O., & Liu, R. H. (2007). Effect of processing on the
phytochemical profiles and antioxidant activity of corn for production of masa, tortillas,
and tortilla chips. Journal of Agricultural and Food Chemistry, 55, 4177-4183.
Patras, A., Brunton, N. P., Donnell, C. O., & Tiwari, B. K. (2010). Effect of thermal processing
on anthocyanin stability in foods; mechanisms and kinetics of degradation. Trends in
Food Science and Technology, 21(1), 3-11.
Pedreschi, R., & Cisneros-Zevallos, L. (2006). Antimutagenic and antioxidant properties of
phenolic fractions from Andean purple corn (Zea mays L.). Journal of Agricultural and
Food Chemistry, 54, 4557-4567.
Pedreschi, R., & Cisneros-Zevallos, L. (2007). Phenolic profiles of Andean purple corn (Zea
mays L.). Food Chemistry, 100, 956-963.
Peng, B., Chang, Q., Wang, L., Hu, Q., Wang, Y., Tang, J., & Liu, X. (2008). Suppression of
human ovarian SKOV-3 cancer cell growth by Duchesnea phenolic fraction is associated
with cell cycle arrest and apoptosis. Gynecologic Oncology, 108(1), 173-81.
Pérez-Jiménez, J., Serrano, J., Tabernero, M., Arranz, S., Díaz-Rubio, M. E., García-Diz, L.,
Goñi, I., & Saura-Calixto, F. (2009). Bioavailability of phenolic antioxidants associated
with dietary fiber: plasma antioxidant capacity after acute and long-term intake in
humans. Plant Foods for Human Nutrition, 64(2), 102-7.
Perfilova, V. N., D’iakova, A. V., & Tiurenkov, I. N. (2005). Cardioprotective action of ferulic
acid upon heart under stressor damage condition. Eksperimental'naia i klinicheskaia
farmakologiia, 68, 19-22.
109
Peričin, D., Krimer, V., Trivić, S., & Radulović, L. (2009). The distribution of phenolic acids in
pumpkin’s hull-less seed, skin, oil cake meal, dehulled kernel and hull. Food Chemistry,
113(2), 450-456.
Piironen, V., Lindsay, D. G., Miettinen, T. A., Toivo, J., & Lampi, A. (2000). Plant sterols:
biosynthesis, biological function and their importance to human nutrition. Journal of the
Science of Food and Agriculture, 80, 839-966.
Plumb, G. W., Garcia-Conesa, M. T., Kroon, P. A., Rhodes, M., Ridley, S., & Williamson, G.
(1999). Metabolism of chlorogenic acid by human plasma, liver, intestine and gut
microflora. Journal of the Science of Food and Agriculture, 79(3), 390-392.
Prasanna, B. M., Vasal, S. K., Kassahun, B., & Singh, N. N. (2001). Quality protein maize.
Current Science, 81, 1308-1319.
Ralph, J. (2010). Hydroxycinnamates in lignification. Phytochemistry Reviews, 9, 65–83.
Ramos, S. (2008). Cancer chemoprevention and chemotherapy: dietary polyphenols and
signalling pathways. Molecular Nutrition & Food Research, 52, 507-526.
Ramos-Escudero, F., Muñoz, A. M., Alvarado-Ortíz, C., Alvarado, Á., & Yáñez, J. A. (2012).
Purple corn (Zea mays L.) phenolic compounds profile and its assessment as an agent
against oxidative stress in isolated mouse organs. Journal of Medical Food, 15(2), 206-
215.
Randhir, R., Kwon, Y-I., Lin, Y-T., & Shetty, K. (2009). Effect of thermal processing on the
phenolic associated health-relevant functionality of selected grain sprouts and seedlings.
Journal of Food Biochemistry, 33, 89-112.
110
Randhir, R., Kwon, Y-I., & Shetty, K. (2008). Effect of thermal processing on phenolics,
antioxidant activity and health-relevant functionality of select grain sprouts and seedlings.
Innovative Food Science and Emerging Technologies, 9(3), 355-364.
Rathee, P., Chaudhary, H., Rathee, S., Rathee, D., Kumar, V., & Kohli, K. (2009). Mechanism of
action of flavonoids as anti-inflammatory agents: a review. Inflammation & Allergy –
Drug Targets, 8(3), 229-35.
Rausch, K., Pruiett, L., Wang, P., Xu, L., Belyea, R., & Tumbleson, M. (2009). Laboratory
measurement of yield and composition of dry-milled corn fractions using a shortened,
single-stage tempering procedure. Cereal Chemistry, 86(4), 434-438.
Rice-Evans, C. A., Miller, N. J., & Paganga, G. (1996). Structure-antioxidant activity
relationships of flavonoids and phenolic acids. Free Radical Biology and Medicine, 20(7),
933-56.
Sakai, S., Ochiai, H., Nakajima, K., & Terasawa, K. (1997). Inhibitory effect of ferulic acid on
macrophage inflammatory protein-2 production in a murine macrophage cell line,
Raw264.7. Cytokine, 9(4), 242-248.
Sanchez-Moreno, C., De Ancos, B., Plaza, L., Elez-Martinez, P. & Cano, M. P. (2009).
Nutritional approaches and health related properties of plant foods processed by high
pressure and pulsed electric fields. Critical Reviews in Food Science and Nutrition, 49,
552-576.
Santiago, R., Reid, L. M., Arnason, J. T., Zhu, X. Y., Martinez, N., & Malvar, R. A. (2007).
Phenolics in maize genotypes differing in susceptibility to gibberella stalk rot (fusarium
graminearum schwabe). Journal of Agricultural and Food Chemistry, 55, 5186-5193.
111
Sarepoua, E., Tangwongchai, R., Suriharn, B., & Lertrat, K. (2013). Relationships between
phytochemicals and antioxidant activity in corn silk. International Food Research
Journal, 20(5), 2073-2079.
Satue-Gracia, M., Heinonen, I. M., & Frankel, E. N. (1997). Anthocyanins as antioxidants on
human low-density lipoprotein and lecithinliposome systems. Journal of Agricultural and
Food Chemistry, 45, 3362-3367.
Saulnier, L., Marot, C., Elgorriaga, M., Bonnin, E., & Thibault, J.-F. (2001). Thermal and
enzymatic treatments for the release of free ferulic acid from maize bran. Carbohydrate
Polymers, 45(3), 269-275.
Saura-Calixto, F. (2011). Dietary fiber as a carrier of dietary antioxidants: an essential
physiological function. Journal of Agricultural and Food Chemistry, 59, 43-49.
Sawa, T., Nakao, M., Akaike, T., Ono, K., & Maeda, H. (1999). Alkylperoxyl radical-scavenging
activity of various flavonoids and other phenolic compounds: implications for the anti-
tumour effect of vegetables. Journal of Agricultural and Food Chemistry, 47, 397-402.
Scalbert, A., & Williamson, G. (2000). Dietary intake and bioavailability of polyphenols.
Journal of Nutrition, 130(8), 2073S-2085S.
Scambia, G., Ranelletti, F. O., Panici, P. B., Devincenzo, R., Bonanno, G., Ferrandina, G.,
Piantelli, M.,Masciullo, V., Bonanno, G., Isola, G., & Mancuso, S. (1994). Quercetin
enhances transforming growth-factor β1 secretion by human ovarian-cancer cells.
International Journal of Cancer, 57, 211-215.
Schaich, K. M., Shahidi, F., Zhong, Y., & Eskin, N. A. (2013). Lipid oxidation. Biochemistry of
Foods (pp. 419-478). Academic Press.
112
Schuh, J., Falrclough, G. F., & Haschemeyer, R. H. (1978). Oxygen-mediated heterogeneity of
apo-low-density lipoprotein. Proceedings of the National Academy of Sciences of the
United States of America, 75(7), 3173-3177.
Schwarz, D., & Roots, I. (2003). In vitro assessment of inhibition by natural polyphenols of
metabolic activation of procarcinogens by human CYP1A1. Biochemical and Biophysical
Research Communications, 303, 902-907.
Sen, A., Bergvinson, D., Miller, S., Atkinson, J., Fulcher, R. G., & Arnason, J. T. (1994).
Distribution and microchemical detection of phenolic acids, flavonoids, and phenolic acid
amides in maize kernels. Journal of Agricultural and Food Chemistry, 42, 1879-1883.
Singh, V., & Johnston, D. (2004). An enzymatic process for corn wet milling. In S. Taylor (Ed.),
Advances in food and nutrition research (pp. 151-171). San Diego, CA: Elsevier
Academic press.
Singh, N., Kaur, A., & Shevkani, K. (2014). Maize: Grain structure, composition, milling, and
starch characteristics. In D. Chaudhary, S. Kumar, & S. Langyan (Eds.), Maize: Nutrition
Dynamics and Novel Uses (pp. 65-76). India: Springer.
Singleton, V. L., Orthofer, R., Lamuela-Raventos, R. M. (1999). Analysis of total phenols and
other oxidation substrates and antioxidants by means of Folin-Ciocalteu reagent. Methods
in Enzymology, 299, 152-178.
Slater, T. F. (1984). Free-radical mechanisms in tissue injury. Biochemical Journal, 222, 1-15.
Sonee, M., Sum, T., Wang, C., & Mukherjee, S. K. (2004). The Soy Isoflavone, Genistein,
Protects Human Cortical Neuronal Cells from Oxidative Stress. NeuroToxicology, 25(5),
885-891.
Spormann, T.M., Albert, F.W., Rath, T., Dietrich, H., Will, F., Stockis, J.P., Eisenbrand, G., &
113
Janzowski, C. (2008). Anthocyanin/polyphenolic-rich fruit juice reduces oxidative cell
damage in an intervention study with patients on hemodialysis. Cancer Epidemiology,
Biomarkers & Prevention, 17, 3372-3380.
Srinivasan, M., Sudheer, A. R., & Menon, V. P. (2007). Ferulic acid: Therapeutic potential
through its antioxidant property. Journal of Clinical Biochemistry and Nutrition, 40(2),
92-100.
Stahl, W., & Sies, H. (2005). Bioactivity and protective effects of natural carotenoids.
Biochimica et Biophysica Acta, 1740(2), 101-107.
Steinberg, D. (1997). Low density lipoprotein oxidation and its pathobiological significance. The
Journal of Biological Chemistry, 272, 20963-20966.
Sumczynski, D., Bubelova, Z., Sneyd, J., Erb-Weber, S., Jiri, Mlcek. (2015). Total phenolics,
flavonoids, antioxidant activity, crude fibre and digestibility in non-traditional wheat
flakes and muesli. Food Chemistry, 174, 319-325.
Sun, L., Zhang, H., & Zhuang, Y. (2012). Preparation of free, soluble conjugate, and insoluble-
bound phenolic compounds from peels of Rambutan (Nephelium lappaceum) and
evaluation of antioxidant activities in vitro. Journal of Food Science, 77(2), 198-204.
Suzuki, A., Kagawa, D., Fujii, A., Ochiai, R., Tokimitsu, I., & Sato, I. (2002). Short and long
term effects of ferulic acid on blood pressure in spontaneously hypertensive rats.
American Journal of Hypertension, 15, 351-357.
Tanaka, T., kojima, T., Kawamori, T., Yoshimi, N., & Mori, H. (1993). Chemoprevention of
diethylnitrosamine-induced hepatocarcinogenesis by a simple phenolic acid
protocatechuic acid in rats. Cancer Research, 53, 2775-2779.
114
Torel, J., Cillard, J., & Cillard, P. (1986). Antioxidant activity of flavonoids and reactivity with
peroxy radical. Phytochemistry, 25, 383-385.
Tsuda, T., Horio, F., Uchida, K., Aoki, H., & Osawa, T. (2003). Dietary cyanidin 3-O-β-D-
glucoside-rich purple corn color prevents obesity and ameliorates hyperglycemia in mice.
Journal of Nutrition, 133, 2125-2130.
Underwood, W. (2012). The plant wall: a dynamic barrier against pathogen invasion. Frontiers
in Plant Science, 3, 85.
Ursini, F., Maiorino, M., Brigelius-Flohé, R., Aumann, K.D., Roveri, A., Schomburg, D., &
Flohé, L. (1995). Diversity of Glutathione peroxidases. Methods in Enzymology, 252,
38-114.
Vanacker, S. A. B. E., Tromp, M. N. J. L., Haenen, G. R. M. M., Vandervijgh, W. J. F., & Bast,
A. (1995). Flavonoids as scavengers of nitric oxide radical. Biochemical and Biophysical
Research Communications, 214(3), 755-759.
Velioglu, Y. S., Mazza, G., Gao, L., & Oomah, B. (1998). Antioxidant activity and total
polyphenolics in selected fruits, vegetables, and grain products. Journal of Agricultural
and Food Chemistry, 46(10), 4113-4117.
Vinson, J. A., Hao, Y., Su, X., & Zubik, L. (1998). Phenol antioxidant quantity and quality in
foods: vegetables. Journal of Agricultural and Food Chemistry, 46, 3630-3634.
Vinson, J. A., Hao, Y., Su, X., & Zubik, L. (2001). Phenol antioxidant quantity and quality in
foods: Fruits. Journal of Agricultural and Food Chemistry, 49, 5315-5321.
Wallace, G., & Fry, S. C. (1994). Phenolic components of the plant cell wall. International
Review of Cytology, 151, 229-267.
115
Wang, E., Rojas, C., & Bauner, C. (2015). Evolution of nutritional quality in the US: evidence
from the ready-to-eat cereal industry. Economics Letters, 133, 105-108.
Wang, H., Cao, G., & Prior, R. L. (1997). Oxygen radical absorbing capacity of anthocyanins.
Journal of Agricultural and Food Chemistry, 45, 304-309.
Wang, W., Goodman, M. T. (1999). Antioxidant property of dietary phenolic agents in a human
LDL-oxidation ex vivo model: Interaction of protein binding activity. Nutrition Research,
19(2), 191-202.
Wang, H., Nair, M. G., Strasburg, G. M., Chang, Y. C., Booren, A. M., Gray, J. I., & Dewitt, D.
L. (1999). Antioxidant and antiinflammatory activities of anthocyanins and their aglycon,
cyanidin, from tart cherries. Journal of Natural Products, 62(2), 294-6.
Weinreb, O., Mandel, S., Amit, T., Moussa, B., & Youdim, H. (2004). Neurological mechanisms
of green tea polyphenols in Alzheimer's and Parkinson's diseases. The Journal of
Nutritional Biochemistry, 15, 506-516.
Weirauch, J. L., & Gardner, J. M. (1978). Sterol content of foods of plant origin. Journal of the
American Dietetic Association, 73, 39-47.
White, B.L., Howard, L.R., & Prior, R.L. (2010). Release of bound procyanidins from cranberry
pomace by alkaline hydrolysis. Journal of Agricultural and Food Chemistry, 58, 7572-
7579.
White, P. J., & Xing, Y. (1997). Antioxidants from cereals and legumes. In F. Shahidi (Ed.),
Natural antioxidants, chemistry, health effects, and application (pp. 25-63). Champaign,
IL: AOCC press.
Wong, D. W. S. (2006). Feruloyl esterase: A key enzyme in biomass degradation. Applied
Biochemistry and Biotechnology, 133(2), 87-112.
116
Wu, G., Fang, Y., Yang, S., Lupton, J. R., & Turner, N. D. (2004). Glutathione metabolism and
its implications for health. The Journal of Nutrition, 134(3), 489-492.
Wu, X., Beecher, G. R., Holden, J. M., Haytowitz, D. B., Gebhardt, S. E., & Prior, R. L. (2004).
Lipophilic and hydrophilic antioxidant capacities of common foods in the United States.
Journal of Agricultural and Food Chemistry, 52, 4026-4037.
Xu, J., Hu, Q., Wang, X., Luo, J., Liu, Y., & Tian, C. (2010). Changes in the main nutrients,
phytochemicals, and antioxidant activity in yellow corn grain during maturation. Journal
of Agricultural and Food Chemistry, 58, 5751-5756.
Yi, W., Fischer, J., & Krewer, G., & Akoh, C. C. (2005). Phenolic compounds from blueberries
can inhibit colon cancer cell proliferation and induce apoptosis. Journal of Agricultural
and Food Chemistry, 53(18), 7320-9.
Yoshida, Y., Niki, E. A. (2003). Antioxidant effects of phytosterol and its components. Journal
of Nutritional Science and Vitaminology, 49(4), 277–280.
Yu, L., Haley, S., Perret, J., Harris, M., Wilson, J., & Qian, M. (2002). Free radical scavenging
properties of wheat extracts. Journal of Agricultural and Food Chemistry, 50, 1619-1624.
Yu, L., Perret, J., Harris, M., Wilson, J., & Haley, S. (2003). Antioxidant properties of bran
extracts from “Akron” wheat grown at different locations. Journal of Agricultural and
Food Chemistry, 51, 1566–1570.
Zhao, C., Giusti, M. M., Malik, M., Moyer, M. P., & Magnuson, B. A. (2004). Effects of
commercial anthocyanin-rich extracts on colonic cancer and nontumorigenic colonic cell
growth. Journal of Agricultural and Food Chemistry, 52, 6122-6128.
Zhou, K., & Yu, L. (2004). Effects of extraction solvent on wheat bran antioxidant activity
estimation. Food Science and Technology, 37, 717-721.
117
Žilić, S., Serpen, A., Akıllıoğlu, G., Gökmen, V., & Vančetović, J. (2012). Phenolic Compounds,
Carotenoids, Anthocyanins, and Antioxidant Capacity of Colored Maize (Zea mays L.)
Kernels. Journal of Agricultural and Food Chemistry, 60(5), 1224-1231.
Zivanovic, S., & Buescher, R. (2004). Changes in mushroom texture and cell wall composition
affected by thermal processing. Journal of Food Science, 69(1), 44-49.
Zweier, J. L., & Talukder, M. A. H. (2006). The role of oxidants and free radicals in reperfusion
injury. Cardiovascular Research, 70, 181-190.
118
APPENDIX A: ANALYSIS OF VARIANCE FOR MOISTURE CONTENT, PHENOLICS,
AND ANTIOXIDANT CAPACITY OF CORN HYBRIDS GROWN IN THREE
YEARS AT FIVE PROCESSING STAGES
Appendix A.1: Analysis of Variance for Moisture Content (MC%) of Different Corn Hybrids
Growing in Different Years at Different Processing Stages a,b
Source DF Sum of Squares Mean Square Error DF F value Pr > F
Genotype 2 10.51 5.26 3.98 2.38 0.2088
Processing Stage 4 63260 15815 7.96 3037.94 <0.0001
G×P 8 41.74 5.22 14.65 2.07 0.1078
Year 2 22.98 11.49 4.61 2.30 0.2026
Rep(Y) 6 2.58 0.43 0.31 1.39 0.7336
G×Y 4 8.85 2.21 5.17 1.22 0.4058
G×Rep(Y) 12 15.31 1.28 38 0.64 0.7912
P×Y 8 41.55 5.19 4.28 3.26 0.1245
P×Rep(Y) 24 24.99 1.04 38 0.53 0.9505
G×Y× P 15 37.60 2.51 38 1.27 0.2705
G×P×Rep(Y) 38 75.30 1.98 0 1.78E12 -
Residual 0 2.68E-11 1.11E-12 - - - a Analysis of variance is performed using the generalized linear mixed model (GLMM).
b “G”=”Genotype”; “P”= “Processing Stage”; “Y”= “Year”.
Appendix A.2: Analysis of Variance for Soluble Phenolic Content of Different Corn Hybrids
Growing in Different Years at Different Processing Stages a,b
Source DF Sum of Squares Mean Square Error DF F value Pr > F
Genotype 2 672560 336280 3.99 9.24 0.0318
Processing Stage 4 1056245 264061 7.91 30.45 <.0001
G×P 8 198984 24873 15 4.01 0.0100
Year 2 68904 34452 4.67 0.65 0.5631
Rep(Y) 6 222369 37061 14.63 1.63 0.2079
G×Y 4 144494 36124 12.94 1.72 0.2054
G×Rep(Y) 12 235492 19624 46 4.27 0.0002
P×Y 8 69223 8652.88 15.73 0.94 0.5109
P×Rep(Y) 24 182699 7612.45 46 1.66 0.0700
G×Y× P 15 93156 6210.41 46 1.35 0.2120
G×P×Rep(Y) 46 211310 4593.69 132 3.09 <.0001
Residual 132 195948 1484.45 a Analysis of variance is performed using the generalized linear mixed model (GLMM).
b “G”=”Genotype”; “P”= “Processing Stage”; “Y”= “Year”.
119
Appendix A (continue)
Appendix A.3: Analysis of Variance for Soluble Phenolic Content of Different Corn Hybrids Growing in Different Years at Each
Processing Stage a,b
Source DF Whole Kernel Flaking Grits Cooked Grits
MSc F P MS F P MS F P
Genotype 2 271.47 0.02 0.9798 113658 12.15 0.0200 75018 9.81 0.0287
Year 2 1601.84 0.10 0.9059 8049.26 0.44 0.6659 23899 1.71 0.2525
Rep(Y) 6 6479.01 1.76 0.2057 15809 2.27 0.1069 9335.80 3.07 0.0465
G×Y 4 13181 3.57 0.0548 9352.69 1.34 0.3102 7649.84 2.51 0.0969
G×Rep(Y) 12 3689.58 1.00 0.4735 6963.62 3.17 0.0062 3042.43 6.61 <.0001
Residual 27 3704.28 - - 2193.70 - - 460.17 - -
Source DF Baked Grits Toasted Flakes
MS F P MS F P
Genotype 2 70483 5.34 0.0743 204648 10.59 0.0252
Year 2 29604 2.28 0.2409 5576.75 0.17 0.8493
Rep(Y) 6 5747.97 0.97 0.4859 31543 1.73 0.1969
G×Y 4 13201 2.22 0.1275 19324 1.06 0.4174
G×Rep(Y) 12 5937.04 11.94 <.0001 18216 22.39 <.0001
Residual 27 497.09 - - 813.66 - - a Analysis of variance was performed using the generalized linear mixed model (GLMM).
b “G”=”Genotype”; “Y”= “Year”.
c “MS” indicates “Mean Square”.
120
Appendix A (continue)
Appendix A.4: Analysis of Variance for Soluble Phenolic Content of Processed Corn Hybrids Growing in Three Years a,b
Source DF 2009 2010 2011
MSc F P MS F P MS F P
Genotype 2 120604 6.10 0.0610 118174 6.75 0.0522 198055 9.17 0.0320
Processing Stage 4 127237 19.73 0.0003 93746 8.05 0.0066 71382 15.04 0.0009
G×P 8 5705.49 1.43 0.2591 18488 3.49 0.0160 14084 3.15 0.0321
Rep 2 2628.42 0.12 0.8910 52846 2.22 0.1906 55710 2.52 0.1976
G×Rep 4 19781 4.95 0.0087 17503 3.30 0.0374 21589 4.83 0.0117
P×Rep 8 6448.09 1.61 0.1980 11642 2.20 0.0857 4747.47 1.06 0.4395
G×P×Rep 16 4000.09 2.13 0.0237 5296.72 2.96 0.0021 4468.63 6.06 <.0001
Residual 45 1876.30 - - 1790.40 - - 736.82 - a Analysis of variance was performed using the generalized linear mixed model (GLMM).
b “G”=”Genotype”; “P”= “Processing Stage”.
c “MS” indicates “Mean Square”.
Appendix A.5: Analysis of Variance for Soluble Phenolic Content of three Processed Corn Hybrids Growing in Different Years a
Source DF Hybrid A Hybrid B Hybrid C
MSb F P MS F P MS F P
Processing Stage 4 153399 28.98 <.0001 60590 13.31 0.0022 110817 10.05 0.0033
Year 2 104076 3.70 0.1111 467.21 0.9861 0.9861 1822.85 0.09 0.9109
Rep(year) 6 31658 3.60 0.0110 33010 <.0001 <.0001 13046 2.75 0.0353
Processing Stage×Year 8 5293.29 0.60 0.7675 4551.77 0.2344 0.2344 11021 2.32 0.0527
Processing Stage×Rep(year) 24 8804.78 6.99 <.0001 3128.22 0.0264 0.0264 4744.71 2.90 0.0010
Residual 45 1259.38 - - 1563.81 - - 1635.46 - - a Analysis of variance was performed using the generalized linear mixed model (GLMM).
b “MS” indicates “Mean Square”.
121
Appendix A (continue)
Appendix A.6: Analysis of Variance for Bound Phenolic Content of Different Corn Hybrids
Growing in Different Years at Different Processing Stages a,b
Source DF Sum of Squares Mean Square Error DF F value Pr > F
Genotype 2 8511879 4255939 3.99 10.69 0.0249
Processing Stage 4 13590125 3397531 7.88 105.66 <0.0001
G×P 8 1033273 129159 15 4.09 0.0091
Year 2 1690189 845095 4.52 1.79 0.2675
Rep(Y) 6 1315120 219187 11.53 1.52 0.2552
G×Y 4 1580119 395030 11.64 2.76 0.0787
G×Rep(Y) 12 1727707 143976 46 4.69 <0.0001
P×Y 8 257207 32151 7.88 1.03 0.4843
P×Rep(Y) 24 727649 30319 46 0.99 0.4981
G×Y× P 15 473239 31549 46 1.03 0.4452
G×P×Rep(Y) 46 1411184 30678 132 8.40 <0.0001
Residual 132 482064 3652 a Analysis of variance is performed using the generalized linear mixed model (GLMM).
b “G”=”Genotype”; “P”= “Processing Stage”; “Y”= “Year”.
122
Appendix A (continue)
Appendix A.7: Analysis of Variance for Bound Phenolic Content of Different Corn Hybrids Growing in Different Years at Each
Processing Stage a,b
Source DF Whole Kernel Flaking Grits Cooked Grits
MSc F P MS F P MS F P
Genotype 2 651103 6.13 0.0872 2307770 21.20 0.0074 560556 7.61 0.0433
Year 2 232790 2.28 0.2865 276733 1.60 0.2825 213576 2.35 0.2315
Rep(Y) 6 57752 0.93 0.5152 114612 2.28 0.1062 72683 1.31 0.3247
G×Y 4 106235 1.71 0.2286 108860 2.16 0.1354 73645 1.33 0.3157
G×Rep(Y) 12 62291 6.86 <.0001 50350 15.82 <.0001 55532 26.60 <.0001
Residual 27 9079.31 - 3182.20 - - 2087.75 - -
Source DF Baked Grits Toasted Flakes
MS F P MS F P
Genotype 2 584262 7.77 0.0419 506877 2.88 0.1679
Year 2 144995 2.46 0.2976 233039 1.22 0.3818
Rep(Y) 6 34997 0.68 0.6669 66902 1.27 0.3391
G×Y 4 75209 1.47 0.2721 175949 3.35 0.0464
G×Rep(Y) 12 51212 21.11 <.0001 52572 25.18 <.0001
Residual 27 2426.10 - - 2087.69 - - a Analysis of variance was performed using the generalized linear mixed model (GLMM).
b “G”=”Genotype”; “Y”= “Year”.
c “MS” indicates “Mean Square”.
123
Appendix A (continue)
Appendix A.8: Analysis of Variance for Bound Phenolic Content of Processed Corn Hybrids Growing in Three Years a,b
Source DF 2009 2010 2011
MSc F P MS F P MS F P
Genotype 2 1827487 4.02 0.1104 1823826 33.06 0.0033 2146421 14.37 0.0149
Processing Stage 4 4525616 45.87 <.0001 1481367 31.57 <.0001 921366 47.55 <.0001
G×P 8 454498 1.47 0.2430 112034 2.97 0.0302 22248 1.63 0.2054
Rep 2 762057 1.79 0.2927 110831 1.72 0.2966 165701 1.05 0.4248
G×Rep 4 909441 5.89 0.0041 55164 1.46 0.2591 149403 10.98 0.0003
P×Rep 8 197307 0.64 0.7351 46917 1.25 0.3358 19375 1.42 0.2691
G×P×Rep 16 618033 11.73 <.0001 37662 7.78 <.0001 13611 4.93 <.0001
Residual 45 148190 - - 4842.08 - - 2761.44 - - a Analysis of variance was performed using the generalized linear mixed model (GLMM).
b “G”=”Genotype”; “P”= “Processing Stage”.
c “MS” indicates “Mean Square”.
Appendix A.9: Analysis of Variance for Bound Phenolic Content of three Processed Corn Hybrids Growing in Different Years a
Source DF Hybrid A Hybrid B Hybrid C
MSb F P MS F P MS F P
Processing Stage 4 997519 80.66 <.0001 618114 18.31 0.0008 2112520 42.76 <.0001
Year 2 1279249 5.14 0.0541 31289 0.56 0.6025 452052 2.13 0.1996
Rep(year) 6 257348 12.29 <.0001 49975 1.87 0.1316 206300 4.72 0.0026
Processing Stage×Year 8 12366 0.59 0.7758 33757 1.26 0.3130 49402 1.13 0.3788
Processing Stage×Rep(year) 24 20938 5.14 <.0001 26725 9.29 <.0001 43683 11.04 <.0001
Residual 45 4071.00 - - 2876.80 - - 3956.53 - - a Analysis of variance was performed using the generalized linear mixed model (GLMM).
b “MS” indicates “Mean Square”.
124
Appendix A (continue)
Appendix A.10: Analysis of Variance for Total Phenolic Content of Different Corn Hybrids
Growing in Different Years at Different Processing Stages a,b
Source DF Sum of Squares Mean Square Error DF F value Pr > F
Genotype 2 13905979 6952989 4.00 10.90 0.0241
Processing Stage 4 14967749 3741937 7.89 88.43 <0.0001
G×P 8 1207664 150958 15 4.03 0.0097
Year 2 2392720 1196360 4.29 1.62 0.2989
Rep(Y) 6 2106851 351142 12.00 1.39 0.2964
G×Y 4 2530188 632547 11.56 2.59 0.0921
G×Rep(Y) 12 2996491 249708 46 6.30 <0.0001
P×Y 8 338232 42279 8.09 1.05 0.4716
P×Rep(Y) 24 1018031 42418 46 1.07 0.4102
G×Y× P 15 561682 37445 46 0.94 0.5247
G×P×Rep(Y) 46 1823393 39639 132 6.48 <0.0001
Residual 132 807522 6118 a Analysis of variance is performed using the generalized linear mixed model (GLMM).
b “G”=”Genotype”; “P”= “Processing Stage”; “Y”= “Year”.
125
Appendix A (continue)
Appendix A.11: Analysis of Variance for Total Phenolic Content of Different Corn Hybrids Growing in Different Years at Each
Processing Stage a,b
Source DF Whole Kernel Flaking Grits Cooked Grits
MSc F P MS F P MS F P
Genotype 2 626755 6.95 0.0748 3417112 19.99 0.0083 1045685 10.73 0.0247
Year 2 199939 3.14 0.3381 375422 1.30 0.3438 373175 2.98 0.1786
Rep(Y) 6 44064 0.61 0.7191 203489 2.40 0.0932 102737 1.37 0.3030
G×Y 4 90209 1.25 0.3441 170925 2.01 0.1567 97439 1.30 0.3257
G×Rep(Y) 12 72371 5.90 0.0002 84939 12.69 <.0001 75154 19.02 <.0001
Residual 27 12274 - - 6693.92 - - 3951.15 - -
Source DF Baked Grits Toasted Flakes
MS F P MS F P
Genotype 2 1046227 7.58 0.0436 1338822 4.48 0.0953
Year 2 302181 2.84 0.2628 268027 0.80 0.5062
Rep(Y) 6 50038 0.61 0.7177 134726 1.36 0.3072
G×Y 4 138039 1.69 0.2174 298907 3.01 0.0621
G×Rep(Y) 12 81855 19.95 <.0001 99400 23.39 <.0001
Residual 27 4103.82 - - 4249.18 - - a Analysis of variance was performed using the generalized linear mixed model (GLMM).
b “G”=”Genotype”; “Y”= “Year”.
c “MS” indicates “Mean Square”.
126
Appendix A (continue)
Appendix A.12: Analysis of Variance for Total Phenolic Content of Processed Corn Hybrids Growing in Three Years a,b
Source DF 2009 2010 2011
MSc F P MS F P MS F P
Genotype 2 3392632 4.62 0.0914 2813793 22.77 0.0065 7251508 14.05 0.0155
Processing
Stage 4 5973454 43.26 <.0001 1540750 26.11 0.0001 3468982 25.73 0.0001
G×P 8 558843 1.52 0.2273 120540 2.27 0.0775 246180 2.08 0.1155
Rep 2 734006 1.03 0.4403 309720 2.39 0.2130 753405 1.35 0.3471
G×Rep 4 1469964 7.98 0.0010 123575 2.33 0.1006 1032228 15.26 <.0001
P×Rep 8 276180 0.75 0.6495 59020 1.11 0.4057 269692 1.99 0.1238
G×P×Rep 16 736930 8.21 <.0001 53103 6.13 <.0001 236819 4.29 0.0001
Residual 45 252457 - - 8655.71 - - 165558 - - a Analysis of variance was performed using the generalized linear mixed model (GLMM).
b “G”=”Genotype”; “P”= “Processing Stage”.
c “MS” indicates “Mean Square”.
Appendix A.13: Analysis of Variance for Total Phenolic Content of three Processed Corn Hybrids Growing in Different Years a
Source DF Hybrid A Hybrid B Hybrid C
MSb F P MS F P MS F P
Processing Stage 4 1246594 75.02 <.0001 837310 20.89 0.0005 2034812 33.47 <.0001
Year 2 2064374 4.97 0.0591 39077 0.25 0.7847 511270 1.79 0.2455
Rep(year) 6 435393 11.95 <.0001 151045 4.75 0.0030 278358 5.27 0.0014
Processing Stage×Year 8 16616 0.46 0.8744 40082 1.26 0.3143 60802 1.15 0.3670
Processing Stage×Rep(year) 24 36431 5.34 <.0001 31804 6.30 <.0001 52808 8.24 <.0001
Residual 45 6821.82 - - 5049.61 - - 6410.14 - - a Analysis of variance was performed using the generalized linear mixed model (GLMM).
b “MS” indicates “Mean Square”.
127
Appendix A (continue)
Appendix A.14: Analysis of Variance for Percentage of Bound Phenolics (BP%) of Different
Corn Hybrids Growing in Different Years at Different Processing Stages a,b
Source DF Sum of Squares Mean Square Error DF F value Pr > F
Genotype 2 120.60 60.30 3.95 2.94 0.1651
Processing Stage 4 3356.53 839.13 7.87 66.28 <0.0001
G×P 8 216.98 27.12 15 1.93 0.1305
Year 2 97.52 48.76 5.54 0.85 0.4761
Rep(Y) 6 311.27 51.88 9.53 3.96 0.0293
G×Y 4 81.82 20.45 10.13 1.27 0.3432
G×Rep(Y) 12 137.05 11.42 46 1.22 0.3004
P×Y 8 101.36 12.67 12.35 0.81 0.6098
P×Rep(Y) 24 264.94 11.04 46 1.18 0.3103
G×Y× P 15 211.30 14.09 46 1.50 0.1444
G×P×Rep(Y) 46 431.48 9.38 132 5.78 <0.0001
Residual 132 214.15 1.62 a Analysis of variance is performed using the generalized linear mixed model (GLMM).
b “G”=”Genotype”; “P”= “Processing Stage”; “Y”= “Year”.
128
Appendix A (continue)
Appendix A.15: Analysis of Variance for Percentage of Bound Phenolics of Different Corn Hybrids Grown in Different Years at Each
Processing Stage a,b
Source DF Whole Kernel Flaking Grits Cooked Grits
MSc F P MS F P MS F P
Genotype 2 69.73 1.84 0.3006 39.09 11.26 0.0227 1.44 0.07 0.9305
Year 2 36.02 0.72 0.5356 8.69 2.18 0.3432 4.53 0.15 0.8678
Rep(Y) 6 21.84 2.50 0.0965 5.28 1.11 0.4130 20.44 2.29 0.1045
G×Y 4 37.84 4.33 0.0337 3.47 0.73 0.5901 19.60 2.20 0.1308
G×Rep(Y) 12 8.75 1.74 0.1300 4.77 2.28 0.0365 8.92 28.62 <.0001
Residual 27 5.04 - - 2.09 - - 0.31 - -
Source DF Baked Grits Toasted Flakes
MS F P MS F P
Genotype 2 17.93 2.11 0.2363 20.03 1.50 0.3264
Year 2 1.84 0.13 0.8795 59.33 1.97 0.2752
Rep(Y) 6 13.35 1.66 0.2129 35.19 1.91 0.1593
G×Y 4 8.48 1.06 0.4190 13.35 0.73 0.5906
G×Rep(Y) 12 8.02 15.30 <.0001 0.53 34.91 <.0001
Residual 27 0.52 - - - - a Analysis of variance was performed using the generalized linear mixed model (GLMM).
b “G”=”Genotype”; “Y”= “Year”.
c “MS” indicates “Mean Square”.
129
Appendix A (continue)
Appendix A.16: Analysis of Variance for Percentage of Bound Phenolics of Processed Corn Hybrids Grown in Three Years a,b
Source DF 2009 2010 2011
MSc F P MS F P MS F P
Genotype 2 3.21 0.26 0.7838 41.29 8.11 0.0392 36.14 2.15 0.2317
Processing Stage 4 281.23 26.38 0.0001 368.88 21.65 0.0002 235.25 43.42 <.0001
G×P 8 15.35 1.37 0.2808 29.39 3.33 0.0194 10.06 1.27 0.3335
Rep 2 101.58 8.56 0.0845 23.68 1.78 0.2869 30.38 2.11 0.2872
G×Rep 4 12.39 1.11 0.3872 5.09 0.58 0.6833 16.77 2.11 0.1333
P×Rep 8 10.66 0.95 0.5036 17.04 1.93 0.1250 5.42 0.68 0.7006
G×P×Rep 16 11.20 4.96 <.0001 8.82 5.16 <.0001 7.94 9.37 <.0001
Residual 45 2.26 - - 1.71 - - 0.85 - - a Analysis of variance was performed using the generalized linear mixed model (GLMM).
b “G”=”Genotype”; “P”= “Processing Stage”.
c “MS” indicates “Mean Square”.
Appendix A.17: Analysis of Variance for Percentage of Bound Phenolics of three Processed Corn Hybrids Grown in Different Years a
Source DF Hybrid A Hybrid B Hybrid C
MSb F P MS F P MS F P
Processing Stage 4 320.89 31.04 <.0001 158.35 9.66 0.0056 435.02 30.21 <.0001
Year 2 42.98 1.64 0.2796 3.93 0.14 0.8754 53.72 1.77 0.2405
Rep(year) 6 25.98 2.59 0.0444 23.56 2.24 0.0777 25.25 2.71 0.0376
Processing Stage×Year 8 10.34 1.03 0.4409 16.40 1.56 0.2007 14.40 1.54 0.1948
Processing Stage×Rep(year) 24 10.03 7.30 <.0001 10.53 5.40 <.0001 9.33 5.96 <.0001
Residual 45 1.37 - - 1.95 - - 1.56 - - a Analysis of variance was performed using the generalized linear mixed model (GLMM).
b “MS” indicates “Mean Square”.
130
Appendix A (continue)
Appendix A.18: Analysis of Variance for Antioxidant Capacity of Corn Hybrid A Growing in
Different Years at Different Processing Stages a
Source DF Sum of
Squares
Mean
Square Error DF F value Pr > F
ProcessingStage 4 5556.45 1389.11 8 37.58 <0.0001
Year 2 1274.98 637.49 5.12 3.56 0.1073
Rep(year) 6 1137.38 189.56 24 3.98 0.0067
ProcessingStage×Year 8 295.74 36.97 24 0.78 0.6277
ProcessingStage×Rep(year) 24 1143.76 47.66 90 7.42 <0.0001
Residual 90 578.22 6.42 a Analysis of variance is performed using the generalized linear mixed model (GLMM).
131
Appendix A (continue)
Appendix A.19: Analysis of Variance for Antioxidant Capacity of Corn Hybrid A Growing in Different Years at Each Processing
Stage a
Source DF Whole Kernel Flaking Grits Cooked Grits
MSb F P MS F P MS F P
Year 2 216.99 15.62 0.0001 307.91 44.40 <.0001 144.13 39.74 <.0001
Rep(year) 6 490.35 11.77 <.0001 71.09 10.25 <.0001 69.84 19.26 <.0001
Error 18 6.95 - - 6.93 - - 3.63 - -
Source DF Baked Grits Toasted Flakes
MS F P MS F P
Year 2 43.31 5.69 0.0121 181.51 25.90 <.0001
Rep(year) 6 84.95 11.17 <.0001 72.59 10.36 <.0001
Error 18 7.61 - - 7.01 - - a Analysis of variance was performed using the generalized linear model (GLM).
b “MS” indicates “Mean Square”.
Appendix A.20: Analysis of Variance for Antioxidant Capacity of Processed Corn Hybrid A Growing in Three Years a
Source DF 2009 2010 2011
MSb F P MS F P MS F P
Processing Stage 4 501.74 4.62 0.0317 318.41 44.43 <.0001 642.90 23.75 0.0002
Rep 2 79.92 0.74 0.5092 112.43 15.66 0.0017 376.35 13.90 0.0025
Processing Stage× Rep 8 108.72 9.72 <.0001 7.18 1.39 0.2400 27.07 9.23 <.0001
Residual 30 11.18 - - 5.16 - - 2.93 - - a Analysis of variance was performed using the generalized linear mixed model (GLMM).
b “MS” indicates “Mean Square”.