safety and operations instructions from · 2018. 9. 25. · reference letter description dimension...
TRANSCRIPT
SAFETY AND OPERATIONS INSTRUCTIONS FROM:
PLEASE READ THIS INFORMATION CARFULLY PRIOR TO
OPERATING EQUIPMENT
PAGE 2 — MVC-82VH/VHW PLATE COMPACTOR • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08)
PROPOSITION 65 WARNING
PAGE 6 — MVC-82VH/VHW PLATE COMPACTOR • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08)
FOR YOUR SAFETY AND SAFETY OF OTHERS!
Safety precautions should be followed at alltimes when operating this equipment. Failureto read and understand the Safety Messagesand Operating Instructions could result in injuryto yourself and others.
This manual has been developed toprovide complete instructions for thesafe and efficient operation of thisequipment. Refer to the enginemanufacturer's instructions for datarelative to its safe operation.
Before using this equipment ensure that the operatingindividual has read and understood all instructions in thismanual.
SAFETY MESSAGE ALERT SYMBOLS
The three Safety Messages shown below will inform youabout potential hazards that could injure you or others. TheSafety Messages specifically address the level of exposureto the operator, and are preceded by one of three words:DANGER, WARNING, or CAUTION.
HAZARD SYMBOLS
Potential hazards associated with the operation of thisequipment will be referenced with Hazard Symbols whichappear throughout this manual, and will be referenced inconjunction with Safety Message Alert Symbols.
WARNING — Explosive Fuel Hazards
Fuel is extremely flammable and itsvapors can cause an explosion if ignited.DO NOT start the engine near spilled fuelor combustible fluids.
DO NOT fill the fuel tank while the engineis running or hot. DO NOT overfill tank, since spilledfuel could ignite if it comes into contact with hot engineparts or sparks from the ignition system. Store fuel inapproved containers, in well-ventilated areas and awayfrom sparks and flames.
WARNING — Respiratory Hazards
ALWAYS wear approved respiratoryprotection when required.
WARNING — Burn Hazards
Engine components can generate extremeheat. To prevent burns, DO NOT touchthese areas while the engine is running orimmediately after operation. Never operatethe engine with heat shields or heat guardsremoved.
WARNING — Lethal Exhaust Gas Hazards
Engine fuel exhaust gases containpoisonous carbon monoxide. This gas iscolorless and odorless, and can causedeath if inhaled. NEVER operate thisequipment in a confined area or enclosedstructure that does not provide ample freeflow air.
DANGER
You WILL be KILLED or SERIOUSLY INJURED if youDO NOT follow these directions.
WARNING
You CAN be KILLED or SERIOUSLY INJURED if youDO NOT follow these directions.
CAUTION
You CAN be INJURED if you DO NOT follow thesedirections.
SAFETY
MVC-82VH/VHW • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08) — PAGE 7
SAFETY
CAUTION — Rotating Parts Hazards
NEVER operate equipment with covers orguards removed. Keep fingers, hands, hairand clothing away from all moving partsto prevent injury.
CAUTION — Equipment Damage Hazards
Other important messages are provided throughout thismanual to help prevent damage to your equipment, otherproperty, or the surrounding environment.
CAUTION — Accidental Starting Hazards
ALWAYS place the equipment ON/OFFswitch in the OFF position when theequipment is not in use.
CAUTION — Eye and Hearing Hazards
ALWAYS wear approved eye and hearingprotection.
CAUTION — Overspeed Conditions
NEVER tamper with the factory setting ofthe engine governor. Personal injury andequipment damage can result if operatingin speed ranges above the maximumallowable.
PAGE 8 — MVC-82VH/VHW PLATE COMPACTOR • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08)
RULES AND REGULATIONS
NEVER touch the hot exhaust manifold,muffler or cylinder. Allow these parts to coolbefore servicing engine or pump.
ALWAYS allow the engine to cool beforeadding fuel or performing service and maintenancefunctions. Contact with hot components can causeserious burns.
NEVER operate this equipment in any enclosed or narrowarea where free flow of the air is restricted. The engineof this equipment requires an adequate free flow ofcooling air. If the air flow isrestricted it will cause seriousdamage to the equipment orengine and may cause injuryto people and property.Remember the engine givesoff DEADLY gases.
ALWAYS refuel in a well-ventilated area, away from sparks and open flames.
ALWAYS use extreme caution when working withflammable liquids. When refueling, stop the engine andallow it to cool.
DO NOT smoke around or near theequipment. Fire or explosion could resultfrom fuel vapors, or if fuel is spilled on ahot engine.
NEVER operate the equipment in anexplosive atmosphere or near combustiblematerials. An explosion or fire could resultcausing severe bodily harm or evendeath.
DO NOT top-off fuel tank. Topping-off is dangerous as itcauses fuel to spill.
ALWAYS store the equipment in a clean, dry locationout of the reach of children.
NEVER run engine without air cleaner. Severe enginedamage may occur.
NEVER leave the equipment unattended with the enginerunning. Turn off engine when unattended.
CAUTION must always be observed while servicing thisequipment. Rotating parts can cause injury if contacted.
GENERAL SAFETY
DO NOT operate or service this equipmentbefore reading this entire manual.
This equipment should not be operated bypersons under 18 years of age.
NEVER operate this equipment without proper protectiveclothing, shatterproof glasses, steel-toed boots and otherprotective devices required by the job.
NEVER operate this equipment when notfeeling well due to fatigue, illness or whenunder medication.
NEVER operate this equipment under theinfluence of drugs or alcohol.
NEVER disconnect any "emergency or safetydevices". These devices are intended for operator safety.Disconnection of these devices can cause severe injury,bodily harm or even death! Disconnection of any of thesedevices will void all warranties.
NEVER use accessories or attachments that are notrecommended by Multiquip for this equipment. Damageto the equipment and/or injury to user may result.
Manufacturer does not assume responsibility for anyaccident due to equipment modifications. Unauthorizedequipment modification will void all warranties.
Whenever necessary, replace nameplate, operation andsafety decals when they become difficult read.
ALWAYS check the equipment for loosened threads orbolts before starting.
WARNING — Read This Manual
Failure to follow instructions in this manual may lead toserious injury or even DEATH! This equipment is to beoperated by trained and qualified personnel only! Thisequipment is for industrial use only.
MVC-82VH/VHW • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08) — PAGE 9
RULES AND REGULATIONS
LOADING AND UNLOADING
Before lifting, make sure that equipment parts (hook andvibration insulator) are not damaged and screws are notloosened or lost.
ALWAYS make sure crane or lifting device has beenproperly secured to the lifting bail (hook) of the equipment.
NEVER lift the equipment while the engine is running.
Use adequate lifting cable (wire or rope) of sufficientstrength.
Use one point suspension hook and lift straight upwards.
NEVER allow any person or animal to stand underneaththe equipment while lifting.
Do not to lift machine to unnecessary heights.
TRANSPORTING
ALWAYS shutdown engine before transporting.
Tighten fuel tank cap securely and close fuel cock toprevent fuel from spilling.
Drain fuel when transporting equipment over longdistances or bad roads.
ALWAYS tie down the equipment during transport bysecuring the equipment with rope.
REFUELING
MAINTENANCE SAFETY
NEVER lubricate components or attempt service on arunning machine.
ALWAYS allow the machine a proper amount of time tocool before servicing.
Keep the equipment in proper running condition.
Fix damage to the equipment immediately and alwaysreplace broken parts.
Dispose of hazardous waste properly. Examples ofpotentially hazardous waste are used motor oil, fuel andfuel filters.
DO NOT use food or plastic containers to dispose ofhazardous waste.
DO NOT pour waste, oil or fuel directly onto the ground,down a drain or into any water source.
FUEL
FUEL
TYPICAL
PLATE COMPACTOR
PAGE 10 — MVC-82VH/VHW PLATE COMPACTOR • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08)
EMERGENCIES
ALWAYS know the location of the nearestfire extinguisher.
ALWAYS know the location of the nearestfirst aid kit.
In emergencies, always know the locationof the nearest phone or keep a phone on the job site.Also know the phone numbers of the nearestambulance, doctor and fire department. Thisinformation will be invaluable in case of emergency.
BATTERY SAFETY (FOR ELECTRIC START)
■ The battery contains acids that can causeinjury to the eyes and skin. ALWAYS wearsafety glasses to avoid eye irritation.
■ ALWAYS wear well-insulated gloves whenpicking up the battery.
■ ALWAYS keep the battery charged. If the battery is notcharged, a buildup of combustible gas will occur.
■ DO NOT charge battery if frozen. Battery can explode.When frozen, warm the battery to at least 61° F (16° C).
■ ALWAYS make sure battery terminals are properlyconnected. Inadequate battery connections may causepoor starting of the equipment and create othermalfunctions.
■ ALWAYS keep battery cables in good working condition.Repair or replace all worn cables.
■ ALWAYS recharge the battery in an vented airenvironment, to avoid risk of a dangerous concentrationof combustible gases.
■ ALWAYS disconnect the negative battery terminal beforeperforming service on the equipment.
■ If the battery liquid (dilute sulfuric acid) comes in contactwith clothing or skin, rinse skin or clothing immediatelywith plenty of water.
■ If the battery liquid (dilute sulfuric acid) comes in contactwith your EYES, rinse eyes immediately with plenty ofwater and contact the nearest doctor or hospital to seekmedical attention.
DANGER — Explosion Hazards
The risk of an explosion exists when performing serviceon the battery. To avoid severe injury or DEATH:
DO NOT drop the battery. There is thepossibility of risk that the battery mayexplode.
DO NOT expose the battery to openflames, sparks, cigarettes, etc. The battery
contains combustible gases and liquids. If these gasesand liquids come in contact with a flame or spark, anexplosion could occur.
RULES AND REGULATIONS
MVC-82VH/VHW • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08) — PAGE 11
SPECIFICATIONS
)rotcapmoC(snoitacificepS.1elbaT
sledoM WHV28-CVM/HV28-CVM
eldnaH )eldnaHretneC(VAH
ecroFlagufirtneC )Nk7.31(.fbl0803
snoitarbiVforebmuN )zH39(nim/snoitarbiv006,5
deepSgnilevarT )nim/sretem52(nim/.tf28
)WxL(eziSetalP )mm054x075(.ni7.71x4.22
)eldnaHgnidulcnI(htgneL )mm079(.ni2.83
)eldnaHgnidulcnI(thgieH )mm569(.ni0.83
)eldnaHtuohtiW(thgieH )mm075(.ni4.22
)HV(thgieWgnitarepO)WHV(thgieWgnitarepO
).gk28(.sbl181).gk09(.sbl891
)ylnOledoMWHV(yticapaCknaTretaW )sretil0.11(.tq6.11
noitcapmoCfOaerA.xaM )rh/m.qs576(.rh/.tf.qs262,7
yticapaCliOrotarbiV )sretil41.0(.tq51.0
)enignE(snoitacificepS.2elbaT
enignE
ledoM 21MS1U061XGADNOH
epyT,VHO,rednilyCelgniS,ekorts4delooc-riA
enignEenilosaGtfahSlatnoziroH
ekortSXeroB )mm54xmm86(.ni8.1x.ni7.2
tnemecalpsiD )ni.uc9.9(cc361
tuptuOxaM .M.P.R0063/.P.H5.5
yticapaCknaTleuF )sretil6.3(snollag.S.U59.0.xorppA
leuF enilosaGelibomotuAdedaelnU
yticapaCliOebuL )sretil06.0(stq36.0
dohteMlortnoCdeepS epyTthgiew-ylFlagufirtneC
dohteMgnitratS tratSlioceR
)HxWxL(noisnemiD )mm533x263x403(.ni2.31x2.41x021
thgieWteNyrD ).gK84.01(sbl1.32
PAGE 12 — MVC-82VH/VHW PLATE COMPACTOR • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08)
DIMENSIONS
C
B
E
A
D
snoisnemiD.3elbaT
retteLecnerefeR noitpircseD noisnemiD
A )eldnahgnidulcni(htgneL )mm079(sehcni2.83
B )eldnahtuohtiw(thgieH )mm075(sehcni4.22
C )eldnahgnidulcni(thgieH )mm569(sehcni83
D htgneLetalP )mm075(sehcni4.22
E htdiWetalP )mm054(sehcni7.71
MVC-82VH/VHW • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08) — PAGE 13
GENERAL INFORMATION
DEFINITION OF PLATE COMPACTOR
The Mikasa MVC-82VH/VHW is a walk-behind, one-wayplate compactor designed for the compaction of sand,mixed soils and asphalt. This plate compactor is a powerfulcompacting tool capable of applying a tremendous forcein consecutive high frequency vibrations to a soil surface.Its applications include compacting for road, embankmentsand reservoirs as well as backfilling for gas pipelines, waterpipelines and cable installation work.
VIBRATORY PLATES
The vibratory plates of the MVC-80VH/VHW produce lowamplitude high frequency vibrations, designed to compactgranular soils and asphalt.
The resulting vibrations cause forward motion. The engineand handle are vibration isolated from the vibrating plate.
FREQUENCY/SPEED
The compactor's vibrating plate has a frequency range of5600 vpm (vibrations per minute). The travel speed of thecompactor is approximately 82 ft./minute (25 meters/minute).
ENGINE
The Mikasa MVC-82VH/VHW Plate Compactor is equippedwith a Honda GX160U1SM12 gasoline engine.
CONTROLS
Before starting the MVC-82VH/VHW Plate Compactor,identify and understand the function of the controls andcomponents.
PAGE 14 — MVC-82VH/VHW PLATE COMPACTOR • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08)
COMPONENTS (COMPACTOR)
4
3
5
2
8
67
110
9
WATER TANK
(MVC-82VHW ONLY)
Figure 1. Plate Compactor Controls and Components
Figure 1 shows the location of the basic controls andcomponents of the MVC-80VH/VHW Plate Compactor. Thefunction of each control is described below:
1. Water Tank Cap (VHW Only) – Remove this cap toadd water to the water tank.
2. Fuel Tank Cap – Remove this cap to add fuel.
3. Lifting Bale – When lifting of the compactor is requiredeither by forklift, crane, etc., tie rope or chain aroundthis lifting point.
4. Handle Bar – When operating the compactor use thishandle bar to maneuver the compactor.
5. Gasoline Engine – This plate compactor uses aHONDA GX160U1SM12 engine. Refer to the HONDAowner's manual for engine information and relatedtopics.
6. Belt Cover – Remove this cover to gain access to theV-belts. NEVER run the compactor without the V-beltcover. If the V-belt cover is not installed, the possibilityexists that your hand may get caught between the V-belt and clutch, causing serious injury and bodily harm.
7. Vibrating Plate – A flat, open plate made of durablecast iron construction used in the compacting of soil.
8. Vibration Case – Encloses the eccentric, gears andcounter weights.
9. Water Shut-Off Valve (VHW only) – Turn this valvedownward to let water flow from the water tank to thewater tube.
10. Water Tank (VHW only) – Holds 13.8 quarts of water(removable, no tools required).
MVC-82VH/VHW • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08) — PAGE 15
COMPONENTS (ENGINE)
Figure 2. Engine Controls & Components
ENGINE COMPONENTS
The engine (Figure 2) must be checked for properlubrication and filled with fuel prior to operation. Refer tothe manufacturer's engine manual for instructions anddetails of operation and servicing.
1. Fuel Filler Cap – Remove this cap to add unleadedgasoline to the fuel tank. Make sure cap is tightenedsecurely. DO NOT over fill.
DANGER — Explosive Fuel Hazard
Adding fuel to the tank should be doneonly when the engine is stopped and hashad an opportunity to cool down. In theevent of a fuel spill, DO NOT attempt tostart the engine until the fuel residue has
been completely wiped up, and the area surroundingthe engine is dry.
2. Throttle Lever – Used to adjust engine RPM speed(lever advanced forward - SLOW, lever back towardoperator - FAST).
3. Engine ON/OFF Switch – ON position permits enginestarting, OFF position stops engine operations.
4. Recoil Starter (pull rope) – Manual-starting method.Pull the starter grip until resistance is felt, then pullbriskly and smoothly.
5. Fuel Valve Lever – OPEN to let fuel flow, CLOSE tostop the flow of fuel.
6. Choke Lever – Used in the starting of a cold engine,or in cold weather conditions. The choke enriches thefuel mixture.
7. Air Cleaner – Prevents dirt and other debris fromentering the fuel system. Remove wing-nut on top ofair filter cannister to gain access to filter element.
8. Spark Plug – Provides spark to the ignition system.Set spark plug gap to 0.6 - 0.7 mm (0.028 - 0.031inch). Clean spark plug once a week.
WARNING — Burn Hazard
Engine components can generateextreme heat. To prevent burns, DONOT touch these areas while theengine is running or immediately afteroperating. NEVER operate the enginewith the muffler removed.
Operating the engine without an air filter,with a damaged air filter, or a filter in needof replacement will allow dirt to enter theengine, causing rapid engine wear.
9. Muffler – Used to reduce noise and emissions.
10. Fuel Tank – Holds unleaded gasoline. For additionalinformation refer to engine owner's manual.
PAGE 16 — MVC-82VH/VHW PLATE COMPACTOR • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08)
INSPECTION
Figure 3. Engine Oil Dipstick (Removal)
Figure 4. Engine Oil Dipstick (Oil Level)
BEFORE STARTING
1. Read safety instructions at thebeginning of manual.
2. Clean the compactor, removingdirt and dust, particularly theengine cooling air inlet,carburetor and air cleaner.
3. Check the air filter for dirt and dust. If air filter is dirty,replace air filter with a new one as required.
4. Check carburetor for external dirt and dust. Clean withdry compressed air.
5. Check fastening nuts and bolts for tightness. Loosenedscrews or bolts due to vibration, could lead tounexpected accident.
ENGINE OIL CHECK
1. To check the engine oil level, place the pump on securelevel ground with the engine stopped.
2. Remove the filler dipstick from the engine oil filler hole(Figure 3) and wipe clean.
3. Insert and remove the dipstick without screwing it intothe filler neck. Check the oil level shown on the dipstick.
4. If the oil level is low (Figure 4), fill to the edge of the oilfiller hole with the recommended oil type (Table 4).Maximum oil capacity is 0.63 quarts (0.60 liters).
FUEL CHECK
1. Remove the gasoline cap located on top of fuel tank.
2. Visually inspect to see if the fuel level is low. If fuel islow, replenish with unleaded fuel.
3. When refueling, be sure to use a strainer for filtration.DO NOT top-off fuel. Wipe up any spilled fuelimmediately!
epyTliO.4elbaT
nosaeS erutarepmeT epyTliO
remmuS rehgiHroC°52 03-W01EAS
llaF/gnirpS C°01~C°52 02/03-W01EAS
retniW rewoLroC°0 01-W01EAS
The Oil Alert System will automaticallystop the engine before the engine fallsbelow safe limits. Always be sure to checkthe engine oil level prior to starting theengine.
DANGER — Explosive Fuel Hazard
Adding fuel to the tank should be doneonly when the engine is stopped and hashad an opportunity to cool down. In theevent of a fuel spill, DO NOT attempt tostart the engine until the fuel residue has
been completely wiped up, and the area surroundingthe engine is dry.
MVC-82VH/VHW • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08) — PAGE 17
INSPECTION
CLUTCH
PULLEY
VIBRATOR
PULLEY
V-BELT CHECK
Figure 5. V-Belt Hazard
1. To check the V-belt tension, remove the three boltsthat secure the belt cover to the frame as shown inFigure 6.
Figure 6. V-Belt Cover Removal
CAUTION — V-Belt Check
NEVER attempt to check the V-belt with the enginerunning. Severe injury can occur if your hand (Figure 5)gets caught between the V-belt and the clutch. Alwaysuse safety gloves.
2. The V-belt tension is proper if the V-belt bends 10 to15 mm (Figure 7) when depressed with finger midwaybetween the clutch and vibration pulley shafts.
Figure 7. V-Belt Tension
OIL PLUG
VIBRATOR
Figure 8. Vibrator Oil Plug
3. A loose V-belt will decrease the power transmissionoutput causing reduced compaction and prematurewear of the belt.
4. If the V-belt becomes worn or loose, replace it.
VIBRATOR OIL CHECK
1. Place the plate compactor horizontally on a flat surface.Make sure the compactor is level when checking theoil in the vibrator assembly.
2. Check vibrator oil level by removing the oil plug(vibrator oil gauge) as shown in Figure 8. The oillevel should be up to the oil plug. The vibrator holds140 cc (approximately 0.3 pint). IMPORTANT, if oil isrequired, replace using only SAE10W-30 motor oil.
PAGE 18 — MVC-82VH/VHW PLATE COMPACTOR • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08)
OPERATION
INITIAL START-UP
1. Place the fuel valve lever (Figure 9) in the "ON"position.
Figure 9. Fuel Valve Lever
Figure 10. Engine ON/Off Switch
Nnnn
Figure 11. Choke Lever
CAUTION — Read Manual
DO NOT attempt to run the compactoruntil the Safety and Initial Start-up sectionshave been read and understood.
2. Place the Engine ON/OFF switch (Figure 10) in the"ON" position.
3. Place the Choke Lever (Figure 11) in the "OPEN"position.
The CLOSED position of the choke leverenriches the fuel mixture for starting aCOLD engine. The OPEN positionprovides the correct fuel mixture fornormal operation after starting, and forrestarting a warm engine.
Figure 12. Throttle Lever
Figure 13. Starter Grip
4. Place the throttle lever (Figure 12) halfway betweenfast and slow.
5. Grasp the starter grip (Figure 13) and slowly pull it out.The resistance becomes the hardest at a certainposition, corresponding the compression point. Rewindthe rope a little from that point and pull out sharply.
CAUTION — Starter Rope
DO NOT pull the starter rope all the way to the end
DO NOT release the starter rope after pulling. Allow itto rewind as soon as possible.
MVC-82VH/VHW • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08) — PAGE 19
OPERATION
OPERATION
1. Once the engine has started, move the engine throttlelever quickly to the fast position.
2. With the throttle lever in the fast position, the enginespeed should be around 2,300 RPM, thereforeengaging the centrifugal clutch.
ALWAYS move the throttle lever quicklywithout hesitation, because increasingthe engine speed slowly causes theclutch to slip.
6. If the engine has started, slowly return the choke lever(Figure 11) to the CLOSED position. If the engine hasnot started, repeat steps 1 through 5.
7. Before the compactor is put into operation, run theengine for 3-5 minutes.
8. Check for abnormal engine noises or fuel leaks.
CAUTION — Follow Safety Rules
Make sure to follow all safety rules referenced in thesafety section of this manual before operatingcompactor. Keep work area clear of debris and otherobjects that could cause damage to the compactor orbodily injury.
3. Firmly grasp the compactor's handle bar with bothhands, the compactor will begin moving forward.
4. Slowly walk behind the compactor and be on thelookout for any large objects or foreign matter thatmight cause damage to the compactor or bodily injury.
5. Compactor traveling speed may drop on soils whichcontain clay, however there may be cases wheretraveling speed drops because the compaction platedoes not leave the ground surface easily due to thecomposition of the soil. To rectify this problem do thefollowing:
Check the bottom plate to see if clay or equivalentmaterial has been lodged in the plate mechanism. If so,wash with water and remove.
Remember the compactor does not work as efficientlyon clay or soils that have a high moisture content level.
If the soil has a high moisture level, dry soil to appropriatemoisture content level or carry out compaction twice.
STOPPING THE ENGINE
CAUTION — Stopping the Engine
NEVER stop the engine suddenly while working at highspeeds.
Normal Shutdown
1. Place the throttle lever (Figure 12) in slow position,and listen for the engine speed to decrease.
2. Place the Engine ON/OFF switch (Figure 10) in the"OFF" position.
3. Place the fuel valve lever (Figure 9) in the "OFF"position.
Emergency Shutdown
1. Move the throttle lever quickly to the slow position,and place the Engine ON/OFF switch in the "OFF "position.
PAGE 20 — MVC-82VH/VHW PLATE COMPACTOR • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08)
MAINTENANCE
INSPECTION AND MAINTENANCE
To make sure your plate compactor is always in goodworking condition before using, carry out the maintenanceinspection in accordance with Tables 5 through 7.
InspectionCAUTION — Inspection and Service
Inspection and other services should always be carriedout on hard and level ground with the engine shutdown.
eludehcSecnanetniaMenignE.5elbaT
)3(noitpircseD noitarepO erofeBtsriF
rohtnoM.srh01
yrevEshtnom3
ro.srh52
yrevEshtnom6
ro.srh05
yrevEraey
ro.srh001
yrevEsraey2
ro.srh002
liOenignEkcehC X
egnahC X
renaelCriAkcehC X
egnahC )1(X
stloB&stuNllAfInethgit-eR
yrasseceNX
gulPkrapSnaelC-kcehC X
ecalpeR X
sniFgnilooC kcehC X
retserrAkrapS naelC X
knaTleuF naelC X
retliFleuF kcehC X
deepSeldI tsujdA-kcehC )2(X
evlaVecnaraelC
tsujdA-kcehC )2(X
senilleuF kcehC )2()yrassecenfiecalper(sraey2yrevE
nidesunehwyltneuqerferomecivreS)1( YTSUD .saera
.tneiciforpyllacinahcemeradnaslootreporpehtevahuoysselnu,relaedecivresruoyybdecivresebdluohssmetiesehT)2(.serudecorpecivresroflaunaMpohSADNOHehtotrefeR
.slavretniecnanetniamreporpenimretedotnoitarepofosruohgol,esulaicremmocroF)3(
CAUTION — Inspection Intervals
These inspection intervals are for operation undernormal conditions. Adjust your inspection intervalsbased on the number hours plate compactor is in use,and particular working conditions.
CAUTION — Fuel Piping
Fuel piping and connections should be replaced every2 years.
MVC-82VH/VHW • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08) — PAGE 21
MAINTENANCE
DAILY SERVICE
Check for leakage of fuel or oil.
Check engine oil.
Check for loose screws including tightness. See Table 7below (tightening torque ) for retightening.
ENGINE OIL
1. Replace the engine oil in first 20 hours of operationand every 100 hours afterwards.
2. Drain the engine oil when the oil is warm afteroperation. Remove the oil filler cap then unscrew theengine oil drain plug located at the base of the engine.Drain the old oil into a pan (Figure 14).
noitcepsnIenihcaM.6elbaT
metI noitarepOfosruoH
)kcehcgnitratS( )yadyreve(sruoh8yrevE
swercstsolroesooL )yadyreve(sruoh8yrevE
trapynafoegamaD )yadyreve(sruoh8yrevE
gnillortnocfonoitcnuFtrapmetsys
)yadyreve(sruoh8yrevE
kcehcliorotarbiV sruoh001yrevE
liorotarbiVtnemecalper
sruoh003yrevE
kcehc)hctulc(tleb-V ruoh002yrevE
retemaiD)mc/gk.ni(euqroTgninethgiT.7elbaT
lairetaM mm6 mm8 mm01 mm21 mm41 mm61 mm81 mm02
T4 07 051 003 005 057 001,1 004,1 000,2
T8-6 001 052 005 008 003,1 000,2 007,2 008,3
T11 051 004 008 002,1 000,2 009,2 002,4 006,5
* )mm01(007~056)mm8(053~003)mm6(001
)munimulafositrap-retnuocesacnI(*
).dednahthgirllaeraenihcamsihthtiwesunisdaerhT(
.)wercsdna,tlobhcaenodekramsilairetamfoytilauqdnalairetaM(
3. Replace engine oil with recommended type oil as listedin Table 4. For engine oil capacity, see Table 2 (enginespecifications). DO NOT overfill.
4. Reinstall drain bolt with sealing washer and tightensecurely.
Figure 14. Engine Oil (Draining)
Figure 15. Air Cleaner
AIR FILTER
1. The air filter element should be cleaned because aclogged air cleaner can cause poor engine starting,lack of power and shorten engine life substantially.
2. To clean or replace air filter loosen the wing nut on theair filter housing (Figure 15), remove the cover andtake out air filter cartridge. If only cleaning of the airfilter is desired blow through the air filter cartridge fromthe inside, moving a jet of dry compressed air up anddown until all dust is removed.
PAGE 22 — MVC-82VH/VHW PLATE COMPACTOR • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08)
MAINTENANCE
SPARK PLUG
1. Remove and clean the spark plug (Figure 16).
2. Adjust the spark gap to 0.028 ~0.031 inch (0.6~0.7 mm).This unit has electronic ignition, which requires noadjustments.
Figure 16. Spark Plug Gap
CHANGING VIBRATOR OIL
1. When changing the vibrator oil, remove the drain plug(Figure 8).
2. Tip the compactor to drain the oil. Note that the oil willdrain more easily while it is hot.
3. Remember to use only 10W-30 motor oil whenreplacing vibrator oil.
CHECKING/REPLACING THE V-BELT AND CLUTCH
After 200 hours of operation, remove the upper belt coverto check the V-belt tension. Tension is proper if the beltbends about 10 mm when depressed strongly with fingerbetween shafts. Loose or worn V-belts reduces powertransmission efficiency, causing weak compaction andreduces the life of the belt itself.
Replacing the V-belt
Remove the upper and lower belt covers. Engage an offsetwrench (13 mm) or the like to vibrator pulley (lower)fastening bolt. Engage waste cloth or the like at midway ofV-belt on the left side and while pulling it back strongly,rotate the offset wrench clockwise so that the V-belt willcome off.
Reinstalling the V-belt
Engage V-belt to lower vibrator pulley and push the V-beltto left side of upper clutch and, in the same manner as inremoval, rotate offset wrench clockwise so that the V-beltgoes back on.
CAUTION — Vibration Check
Whenever the compactor's vibration becomes weak orlost during normal operation regardless of operationhours, check the V-belt and clutch immediately.
WARNING — V-Belt Hazard
NEVER attempt to check the V-belt with the enginerunning. Severe injury can occur if your hand (Figure5) gets caught between the V-belt and the clutch. Alwaysuse safety gloves.
Checking Clutch
Check the clutch simultaneously with V-belt checking. Withbelt removed, check outer drum of the clutch for seizureand "V" groove for wear or damage with your eyes. Cleanthe "V" groove as necessary. Wear of lining or shoe shouldbe checked with running check. If the shoe is worn, powertransmission becomes deficient and slipping will result.
PLATE COMPACTOR STORAGE
For storage of the plate compactor for over 30 days, thefollowing is required:
Drain the fuel tank completely or add STA-BIL to thefuel.
Run the engine until the fuel is completely consumed.
Completely drain the oil from the engine crankcase andfollow procedures described in the HONDA engineOwner's Manual for engine storage.
Completely drain the compactor's hydraulic oil from thevibrating case.
Clean entire plate compactor, especially the bottom plateremoving all dirt and foreign matter.
Cover plate compactor and engine with plastic coveringor equivalent and store in a clean, dry place.
MVC-82VH/VHW • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08) — PAGE 23
TROUBLESHOOTING
Practically all breakdowns can be prevented by properhandling and maintenance inspections, but in the event ofa breakdown, please take remedial action following thediagnosis based on the following troubleshooting tables.
If the problem cannot be remedied, please leave the unitas is and consult Multiquip's service department.
gnitoohselbuorTenignE.8elbaT
motpmyS esuaCelbissoP noituloS
sileuf",tratsottluciffiDtaKRAPSontubelbaliava
."gulpkraps
?gnigdirbgulpkrapS .gulpkrapsecalperronoitalusni,pagkcehC
?gulpkrapsnotisopednobraC .gulpkrapsecalperronaelC
krapstneicifedoteudtiucrictrohS?noitalusnigulp
.nrowfiecalper,noitalusnigulpkrapskcehC
?paggulpkrapsreporpmI .pagreporpotteS
sileuf",tratsottluciffiDsiKRAPSdna,elbaliava."gulpkrapsehttatneserp
?detrohssihctiwsFFO/NO .hctiwsecalper,gniriwhctiwskcehC
?evitcefedliocnoitingI .liocnoitingiecalpeR
?yrtridstniop,pagkrapsreporpmI .stniopnaelcdnapagkrapstcerrocteS
trohsronrownoitalusniresnednoC?gnitiucric
.resnednocecalpeR
trohsronekorberiwgulpkrapS?gnitiucric
.gniriwgulpkrapsevitcefedecalpeR
sileuf",tratsottluciffiDtneserpsikraps,elbaliava
sinoisserpmocdna"lamron
?epytleufgnorWtcerrochtiwecalperdna,metsysleufhsulF
.leuffoepyt
?metsysleufnitsudroretaW .metsysleufhsulF
?ytridrenaelcriA .renaelcriaecalperronaelC
sileuf",tratsottluciffiDtneserpsikraps,elbaliava
"wolsinoisserpmocdna
rokcutsevlavtsuahxe/noitcuS?dedurtorp
.sevlavtaes-eR
?nrowrednilycro/dnagnirnotsiP .notsiprodnasgnirnotsipecalpeR
tongulpkrapsro/dnadaehrednilyC?ylreporpdenethgit
.gulpkrapsdnastlobdaehrednilyceuqroT
teksaggulpkrapsro/dnateksagdaeH?degamad
.steksaggulpkrapsdnadaehecalpeR
tatneserpleufoN.roterubrac
?knatleufnielbaliavatonleuF .leuffoepyttcerrochtiwlliF
?ylreporpnepotonseodkcocleuF,revelkcocleufnesoolottnacirbulylppA
.yrassecenfiecalper
?deggolcretlifleuF .retlifleufecalpeR
?deggolcelohrehtaerbpacknatleuF .packnatleufecalperronaelC
?enilleufniriA .enilleufdeelB
PAGE 24 — MVC-82VH/VHW PLATE COMPACTOR • OPERATION AND PARTS MANUAL — REV. #1 (04/25/08)
TROUBLESHOOTING
)deunitnoc(gnitoohselbuorTenignE.8elbaT
motpmyS esuaCelbissoP noituloS
"rewopnikaeW"dnareporpsinoisserpmoc
.erifsimtonseod
?naelctonrenaelcriA renaelcriaecalperronaelC
?roterubracnilevelreporpmI .rotaerubracdliub-er,tnemtsujdataolfkcehC
?gulpkrapSevitcefeD .gulpkrapsecalperronaelC
?gulpkrapSevitcefeD
"rewopnikaeW"tubreporpsinoisserpmoc
.serifsim
?metsysleufniretaWepyttcerrochtiwecalperdna,metsysleufhsulF
.leuffo
?gulpkrapsytriD .gulpkrapsecalperronaelC
?evitcefedliocnoitingI .liocnoitingiecalpeR
.staehrevoenignE
eulavtaehgulpkrapS?reporpmi
.gulpkrapsfoepyttcerrochtiwecalpeR
?leuffoepyttcerroC leuffoepyttcerrochtiwecalpeR
?ytridsnifgnilooC .snifgniloocnaelC
.setautculfdeepslanoitatoR
?yltcerrocdetsujdaronrevoG .ronrevogtsujdA
?evitcefedgnirpsronrevoG .gnirpsronrevogecalpeR
?detcirtserwolfleuF .sgolcroskaelrofmetsysleuferitnekcehC
.noitcnuflamretratslioceR
htiwdeggolcmsinahcemlioceR?triddnatsud
.retawdnapaoshtiwylbmessaliocernaelC
?esoolgnirpslaripS .gnirpslaripsecalpeR
gnitoohselbuorTrotcapmoCetalP.9elbaT
motpmyS esuaCelbissoP noituloS
dna,wolootdeepslevarT.kaewsinoitarbiv
?wolootdeepsenignE .MPRtcerrocotdeepsenigneteS
?spilshctulC .hctulcecalperrokcehC
?spilstleb-V .tleb-VecalperrotsujdA
?rotarbivnilioevissecxE .levelreporpotllifdnaliossecxeniarD
?gnisuohrotarbivninoitcnuflaM .sthgiewretnuocdnasraeg,cirtneccekcehC
?eruliaFgniraeB .gniraebecalpeR
?tuptuoenignetneiciffusnI .ctenoisserpmoc,enignekcehC