whirlpool awz 7468 sm

SERVICE Whirlpool EMEACustomer Services AWZ 7468

Service InformationDryer CondensationAWZ 74688575 746 10081Last Modification: 08/18/08Creation Date: 08/16/08

Spare Part List 2

Exploded View 4

Technical Data 6

Wiring Diagram 8

Circuit Diagram 10

Testprogram 12

Error Codes 13

Service Bulletin 4812 713 40313 14



This document is only intended for qualified technicans who are aware of therespective safety regulations.Subject to modifications

Whirlpool EMEA www.scc-service.com

SERVICE Whirlpool EMEACustomer Services8575 746 10081, 08/18/08

page 2 of 18

Spare Part List

Pos 12NC Description

004 0 4812 440 11701 Bottom CD011 0 4812 500 18054 Foot adjustable012 0 4812 528 78033 Roll012 1 4812 528 98003 Shaft Front + Roll012 2 4812 520 28188 Shaft rear

021 0 4812 440 10819 Front VBL GW022 0 4812 440 10821 Panel side GW024 0 4812 440 11569 Panel rear030 0 4812 440 11504 Table top short BK EBL053 0 4812 440 11155 Flap EBL WH

053 2 4812 417 28103 Lock transmit. plinth EBL053 4 4812 440 89104 Plinth f. tank bottom EBL WH053 5 4812 417 28102 Axle f.flap EBL100 0 4812 440 11678 Door CD white131 1 4812 271 38354 Door lock system

133 2 4812 417 28056 Lock Bag filter191 0 4812 466 68607 Gasket door220 0 4812 418 18177 Drum cpl. SS223 0 4812 418 89017 Drum lifter GW271 0 4812 358 18164 BELT PV 1936 H6

273 0 4812 358 18055 Pulley jokey275 0 4812 492 68129 Spring291 0 4812 466 68561 Gasket front291 2 4812 466 68837 Gasket drum rear301 0 4801 121 00182 Control panel AWZ 7468

331 0 4812 414 58306 Knob timer331 3 4812 414 58307 Spring Knob timer332 0 4812 410 29401 Push button 2 options333 0 4812 513 18172 Push button401 0 4812 361 18532 Motor + fan wheel + clamp

401 1 4812 401 18421 Clamp Motor420 0 4812 121 18144 Capacitor 10 mF421 0 4812 121 18284 Interf.filter443 0 4812 361 18537 Blower wheel443 1 4812 361 18518 Fan wheel with Clamp

443 2 4812 290 88096 Clamp blower wheel, stainless456 0 4812 259 28926 Heat.elem. 2000W-230V 1HAV0A445002490 0 4812 321 18042 Connect.cable 3m490 0 4812 321 18044 CABLE,MAINS 5M 4X1490 1 4812 321 28433 Strain relief + protect.

492 2 4812 316 18014 Connector AC - Mot. earth521 0 4812 214 70748 Control unit TINY/DOMINO TB, Basic521 0 4812 214 70938 Control unit TINY B6 (M6) programmed620 1 4812 239 58063 Module humidity631 0 4812 271 38497 Microswitch f. pump/belt

631 3 4801 121 00278 Floater system cpl. 6kg633 0 4812 276 18523 Switch door633 1 4812 276 18422 Pin Start reset GW691 0 4812 259 28863 Sensor temper. NTC691 1 4812 282 98014 Gasket NTC



page 3 of 18

Pos 12NC Description

692 0 4812 210 58055 Bracket Sensor692 1 4812 278 58001 Sensor692 2 4812 210 58075 Cover Sensor, Kit740 0 4812 511 48417 Heat exchanger H2741 0 4812 440 08035 Blower cold air

741 1 4812 530 48244 Cover blower house743 0 4812 530 48912 Air guide without hole743 1 4812 530 49274 Heating chamber aluzinc743 3 4812 530 48239 Cover blow. house743 8 4812 466 88519 Gasket f. blow. house

750 0 4812 418 18521 Tank bottom white 6kg761 0 4812 480 58322 Filter; bag GW794 0 4812 466 88863 Gasket AC, Bottom794 1 4812 466 28108 Gasket heater channel794 4 4812 466 88521 Gasket filter

900 1 4812 290 88053 Clip900 2 4812 290 88099 Clip for Heater900 3 4812 404 18529 Crossbar Control panel903 0 4812 532 28028 Clip fix910 1 4812 502 48347 Screw,selftap 3,5x14

910 8 4812 502 48348 Screw ST 4,2x11912 4 4812 502 48015 Screw 4,0x16-TORX922 0 4812 532 58005 Ring circlip Triring922 1 4812 532 58007 Ring circlip930 0 4812 492 98039 Spring f.flap

950 0 4812 466 48101 Felt,strip bottom group950 1 4812 466 88517 Gasket inlet bottom952 3 4812 466 88522 Gasket sensor wiring962 0 4812 466 38012 Protector Motor962 2 4812 466 38056 Foil Aluminium Display board



page 4 of 18

Exploded View



page 5 of 18

Exploded View



page 6 of 18

Technical Data

Dimensions + Weight

Product dimensionsHeight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85 cmWidth . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59.5 cmDepth . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .60 cm

Weightnet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40 kg

Electrical base data

Voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 230 V 10%Frequency . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50 HzFuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 ATotal connected load . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2.19 kW

Surroundings temperature

Room temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .max. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35 CRoom temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .min. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5 C

Capacity of laundry

Cotton . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 kgEasy care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2.5 kg

Heating element

Nominal voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .230 V + 10 % / - 15 %Total power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 x 1000 W 5 %Resistor NTC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1000 W . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46.86 Resistor NTC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2000 W . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23.43

Thermostats condenser

Caracteristics of the NTC

0 C 34.6 k

25 C 11.5 k

60 C 3.3 k

70 C 2.4 k

95 C 1.2 k

100 C 1.0 k

110 C 0.8 k

130 C 0.5 k

180 C 0.2 kSafety thermostat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TL

Switch off temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 260 C 10 K



page 7 of 18

Main- and blower motor

Type . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-phase asynchronousNominal voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .230 V + 10 % / - 15 %Frequency . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50 3 HzPower Consumption . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 285 WResistor (coil)

Main coil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . (2 - 3) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 Auxiliary coil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . (3 - 4) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

Micro switch

Nominal voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .230 V + 10 % / - 15 %Frequency . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50/60 HzCurrent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 A

Door switch

Nominal voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 VMax. current . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .50 mA

Control module

Type . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . TINY/DOMINONominal voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .230 V + 10 % / - 15 %Frequency . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50/60 Hz

Humidity module

Nominal voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 V



page 8 of 18

Wiring Diagram



page 9 of 18

Legend



page 10 of 18

Circuit Diagram



page 11 of 18

Legend



page 12 of 18

Testprogram



page 13 of 18

Error Codes



page 14 of 18

Service Bulletin 4812 713 40313

AUTHOR: Juergen ReinhardtLast Update: 07/01/09VERSION: 1.0TITLE: Randomly does not start or does stop in programs "SYNTHETIC"or "TIMESTEERED 30min".SUBJECT: Loose contact in program selector.Condenser driers and air vented driers produced in week 43, 44, 45, 46 and 48 could be affected by this issue.

REMEDIAL ACTION

In case of an issue check the production date of the timer according to the pictures below. Only the supplier INVENSIS isinvolved in this. The supplier AKO do not have an issue.



page 15 of 18



page 16 of 18


AUTHOR: Juergen ReinhardtLast Update: 05/11/10VERSION: 1.0TITLE: Reset Procedure for F14 / FE failure

REMEDIAL ACTION

In case of shortage of the heating element or a disturbance due to welding of the heating relay the following RESET proce-dure must be always carried out:

Please follow the sequence below which must be performed within 10 seconds:

1) Turn the program selector in 6 oclock position

2) Push "START"button three times

3) Turn program selector one position in clockwise direction (airing program)

4) Push "START"button three times



page 17 of 18


AUTHOR: Kay AugustinLast Update: 02/08/11VERSION: 1.0TITLE: Fluff accumulation at heat exchanger or heating elementSUBJECT: Additional fluff filter available as service kit

REMEDIAL ACTION

An additional filter kit, placed at the heat exchanger, is now available.Delivered with the filter kit will be a detailed Instruction For Use (IFU), see below.The service code for the filter kit is: 4801 121 01629



page 18 of 18


Spare Part ListExploded ViewTechnical DataWiring DiagramCircuit DiagramTestprogramError CodesService Bulletin 4812 713 40313Service Bulletin 4812 713 40317Service Bulletin 4812 713 40324

whirlpool awz 7468 sm

Documents

gasket ac

service bulletin

gasket door220

gasket front291

gasket ntc whirlpool

gasket drum rear301

clamp blower wheel

gasket heater channel794