1. executive summary -...
TRANSCRIPT
Granite Building Stone Quarry of M/s. Krishnagiri Stone Crushers Pre-feasibility Report
..1
1. EXECUTIVE SUMMARY:
M/s. Krishnagiri Stone Crushers had made an application for Granite building stone quarrying
located in Sy. No. 308, Vengapally Village, Vythiri Taluk, Wayanad District, Kerala State. Over
an extent of 1.400 Ha.(3.459 Acres).
Letter of intent for said granite quarry (M/s. Krishnagiri Stone Crushers) is issued vide Letter No.
5863/M3/2017dated 12.07.2017 of Directorate of Mining & Geology, Thiruvananthapuram. A
copy of the Letter is enclosed as Annexure –1 (Mining Plan). The location of the quarry is shown
on the Key plan / Location plan enclosed vide Plate No – 1 & 1A (Mining Plan). The approved
lease sketch is enclosed vide Plate No –2B (Mining Plan).
Quarrying / Mining Plan is approved by The Geologist, Dept. of Mining & Geology, Wayanad.
vide Letter No . DOW/M-558/17 dated 02.08.2017.
DETAILS OF THE SITE
a) 1 Details of area (with location map) :
Cadastral plan, Area survey Plan & Survey
Map showing the lease area is enclosed vide
Plate No. 2-2B (Mining Plan).
2 District and State : Wayanad, Kerala
3 Taluk / Mandal : Vythiri
4 Village : Vengapally
5 Khasara No. / Plot No. / Block /
Licence No etc : Sy.No. 308
6 Mining Lease Area (Hectares) : 1.400 Ha
7 Whether the area is recorded to be in
forest (please specify whether
protected, reserved etc.,)
: No
8 Ownership / Occupancy : Private
9 Existence of public road/railway line,
if any, nearby and approximate
distance Nearest Port / Airport
:
The nearest railhead is at Calicut is at 100km
from the mine.
Nearest airport – Calicut (110km)
10
Topo sheet No. : NC 43-3
Between
Latitude
Longitude
N11037’09.25” to N11037’13.821”
E76002’15.09” to E76002’22.539”
Granite Building Stone Quarry of M/s. Krishnagiri Stone Crushers Pre-feasibility Report
..2
Accessibility: This granite building stone quarry is located at 1.50km from Vengappally
Village in Vythiri Taluk, which is located at about 7.50 km NE of Wayanad District. The
quarry can be reached via Pinangode -State High way road.
The location of this mining area is shown on the Administrative and key plan enclosed Vide Plate
No -1 and 1A (Mining Plan) and Infrastructure Plan vide Plate No. 11 (Mining Plan).
Topography: The lease is located on the slope of the hillock gently dipping towards SW. The
highest elevation in this area is 790mRL and the lowest elevation is 766mRL.
Brief Description of the Project:
Geology:
Regional Geology:
The district can be broadly divided into four geological domains viz., the Peninsula Gneissic
Complex in the north and central part, ii) the Migmatite Complex in the southcentral part,
(iii) the Charnockite Group in the south and (iv) the Wayanad Group in the north. Wayanad
Group of supracrustal rocks include garnet-sillimanite-biotite gneiss with or without
graphite, kyanite-fuchsite-muscovite-quarts schist, hornblende-biotite schist and
gneiss+garnet, amphibolite bands, quartz-sericite schist/quartz-mica schist and meta
ultramafites, representing upper amphibolite to lower granulite facies metamorphism. These
rocks are found as linear bands in the north. The main member of this group garnet
sillimanite-biotite gneiss+graphite occurs as large bodies north of Kabani river. Peninsular
Gneissic Complex represented by hornblende-biotite gneiss and pink granite gneiss occupies
a major part of the district. Charnockite Group comprises charnockite forming the hilly
terrain in the south and southeast. Pyroxene Granulite and banded Magnetite Quartzite occur
as narrow bands within charnockite. Migmatite Complex is represented by biotite-
hornblende gneiss, occurring over a large area in the south-central part. The other member
of this group, namely garnetiferous quarto-feldspathic gneiss+sillimanite occur are narrow
bands within the older charnockite. In the east, large bodies of intrusive pink granite occur
near Kalpetta and Sultan Battery. Pegmatite veins are also associated with the granites.
Dolerite and gabbro are intrusive into the older rocks. Large lenticular bodies of
gabbro/anorthosites occur northeast of Manantody and a large body of diorite occurs near
the northern boundary of the district The geology of the district given above may be read
with the “Geology of Kerala”
Granite Building Stone Quarry of M/s. Krishnagiri Stone Crushers Pre-feasibility Report
..3
Local Geology:
The granite building stones are very well exposed as outcrop, whereas part of area with lower
elevation is covered by top soil of about 0 to 1.7m thickness,
A Geological Plan showing the granite and soil cover are shown in surface geological plan &
sections prepared on 1:1000 scale and enclosed vide Plate No 4 (Mining Plan).
Table 01: Local Geology
Soil Cover 0 to 1.7m
Granite 50m (min. estimate)
Table No: 1.1: The Geological Resources
Section
No
Area
(m2)
Influence
(m)
Volume
(m3)
Tonnage (T)
BD 2.5T/m3
UNFC
A-A' 1,803 38 68,528 1,71,321 332
B-B' 2,412 25 60,288 1,50,719 332
C-C' 4,084 38 1,55,186 3,87,964 332
Total 2,84,002 7,10,004 332
Table No 1.2: Granite Building Stone Mineable Reserves
Section
No
Section
Levels
Area
(m2)
Influence
(m)
Volume
(m3)
Tonnage (T)
BD 2.5T/m3 UNFC
A-A'
770 114 30.5 3,477 8,693 122
765 235 30.5 7,168 17,191 122
760 229 30.5 6,985 17,461 122
755 198 30.5 6,039 15,098 122
750 182 30.5 5,551 13,878 122
745 132 30.5 4,026 10,065 122
Total 33,245 83,113 122
B-B'
770 158 25 3,950 9,875 122
765 217 25 5,425 13,563 122
760 169 25 4,225 10,563 122
755 111 25 2,775 6,938 122
750 125 25 3,125 7,813 122
Total 19,500 48,750 122
C-C' 785 76 30.5 2,318 5,795 122
780 220 30.5 6,710 16,775 122
775 481 30.5 14,671 36,676 122
770 755 30.5 23,028 57,569 122
765 838 30.5 25,559 63,898 122
760 788 30.5 24,034 60,085 122
Total 96,319 2,40,798 122
Total Reserves 1,49,064 3,72,660 122
Granite Building Stone Quarry of M/s. Krishnagiri Stone Crushers Pre-feasibility Report
..4
Mining:
The Mining is proposed to be operated by developing benches of 5m height and 5m ultimate
width by Opencast Semi-Mechanized Mining Method. The mechanized operation of mining
includes excavators, tippers, rock breakers, Jack hammer drilling and blasting. The maximum
production proposed is 50,325 tonnes per annum of Granite Building Stone.
This Pre Feasibility Report is submitted for obtaining Environment Clearance as required under
EIA notification-2006/15th
January 2016 and for a max production capacity of 50,325 tonnes
per annum, over an extent of 1.400Ha.(3.459 Acres). located at Sy.No. 308 in Vengappally
Village, Vythiri Taluk, Wayanad District, , Kerala State in favor of M/s. Krishnagiri Stone
Crushers.
Table No. 1.3 Year-wise calculations of granite building stone production
Year Section Level's Area
(m2)
Influence
(m)
Volume
(m3)
Tonnage (T)
(BD 2.5T/m3) UNFC
I-Year C-C'
785 76 30.5 2,318 5,795 122
780 220 30.5 6,710 16,775 122
774 360 30.5 10,980 27,450 122
Total 20,008 50,020 122
II-Year
A-A' 770 144 30.5 4,392 10,980 122
A-A' 765 235 30.5 7,168 17,919 122
B-B' 770 158 25 3,950 9,875 122
B-B' 765 217 25 5,425 13,563 122
Total 20,020 50,049 122
III-Year C-C' 775 114 30.5 3,477 8,692 122
769 546 30.5 16,653 41,633 122
Total 20130 50,325 122
IV-Year C-C'
770 209 30.5 6,375 15,936 122
763 450 30.5 13,725 34,313 122
Total 20,100 50,249 122
V-Year
A-A' 760 229 30.5 6,985 17,461 122
A-A' 755 198 30.5 6,039 15,098 122
B-B' 760 169 25 4,225 10,563 122
B-B' 755 111 25 2,775 6,938 122
Total 20,024 50,059 122
Total Reserves 1,00,281 2,50,701 122
Granite Building Stone Quarry of M/s. Krishnagiri Stone Crushers Pre-feasibility Report
..5
Table No. 1.4 Year-wise generation of top soil / waste
Year Section Area (m2) Influence
(m) Volume (m3)
Tonnage (T)
(BD 2.5T/m3)
I-Year C-C' 129 30.5 3,935 6,295
Total 3,935 6,295
II-Year A-A' 70 30.5 2,135 3,416
B-B' 69 25 1,725 2,760
Total 3,860 6176
Total Waste 7,795 12,471
The Production & Development Plan is enclosed vide Plate No. 5A to 5E (Mining Plan).
2. INTRODUCTION OF THE PROJECT/ BACKGROUND INFORMATION:
I. Identification of project and project proponent. In case of Mining project, a copy of
mining lease/ letter of intent should be given.
Building Stone Quarry is located at Sy.No. 308 in Vengappally Village, Vythiri Taluk,
Wayanad District, , Kerala State over an extent of 1.400Ha. Letter of Intent (LOI) for said
Granite Building Stone quarry of M/s. Krishnagiri Stone Crushers is issued vide Letter No.
5863/M3/2017dated 12.07.2017of Directorate of Mining & Geology, Thiruvananthapuram. A
copy of the Letter is enclosed as Annexure –1 (Mining Plan). The location of the quarry is
shown on the Key plan / Location plan enclosed vide Plate No – 1 & 1A (Mining Plan).
The approved lease sketch is enclosed vide Plate No. 2 –2B(Mining Plan).
Name & address of lessee
&
Registered Office
: Mr. T. V. Alias
Managing Partner
M/s. Krishnagiri Stone Crushers
Krishnagiri (P.O.), Meenangadi
Wayanad District, Kerala-673591
Ph No. : +91 944004466
II. Brief description of nature of the project
The ‘Granite Building Stone Quarry of M/s. Krishnagiri Stone Crushers', over an extent of
1.400Ha is a granite building stone mining project. The granite building stone is the basic rock in
this area to be excavated by quarrying.
This Granite Building Stone quarry is proposed to be operated by Opencast Semi-Mechanized
Quarrying Method. The mechanized operation of quarry shall use excavators, tippers, rock
breakers, Jack hammer drilling and blasting. The excavated material shall be crushed in the
crushers located outside the quarry lease area.
The maximum production capacity proposed in this area is 50,325 tonnes per annum building
stone of size -150mm.
Granite Building Stone Quarry of M/s. Krishnagiri Stone Crushers Pre-feasibility Report
..6
The quarrying operation shall provide 35 direct & equal number of indirect employment to local
people.
III. Need for the project and its importance to the country and or region.
The basic objective of the project is to have effective utilization of granite stone as a building
material in this region and state. The spur in infrastructure development and construction industry
has enhanced the demand of granite building stone in past few years.
Mainly infrastructure projects – like roads, highways, railways, bridges, buildings, township, Port
Development, etc., have raised the demand of building material. Building stone quarry not only
provides the building material but also employment and economic growth of the region that
ultimately enhance the socio-economic status of the people of the region and the state. The mining
activities shall provide socio-economic benefits to the local population with direct & indirect
employment opportunities. The project also contributes to the regional and financial benefits in the
form of Royalty, Cess, Taxes, DMF etc.
IV. Demand-Supply Gap.
Granite Building stone is an important component of the construction activities for infrastructure
development. The demand for granite building stone is increasing along with the increase in
infrastructure and construction activities in Kerala. This quarry can produce max 50,325 tonnes of
building stone annually and the demand of building stone by various industries can be partly
fulfilled by this project. During last four years there is a sudden increase in the Real estate & Port
development activities which has further enhanced the demand for building stone, hence, there is
heavy requirement of granite building stone to meet the demand supply chain.
V. Imports Vs Indigenous production
The requirements of granite building stone in infrastructure industry is huge where as the prices of
granite are relatively low. The import or export of the same is not feasible due to heavy
transportation cost. The granite building stone of size -150mm shall be transported / sold to the
crusher outside the quarry lease, where it shall be sized and sold to the local market for
infrastructure development.
VI. Export possibility.
The price of the granite is very low and the transportation cost is very high. Hence there are no
export possibilities of the same.
Granite Building Stone Quarry of M/s. Krishnagiri Stone Crushers Pre-feasibility Report
..7
VII. Domestic/Export markets.
The granite building stone of size -150mm shall be transported / sold to the crusher outside the
quarry lease, where it shall be sized and sold to the local market for infrastructure development,
real estate builders, contractors, etc. and to the nearby vendors for government infrastructure
projects. It is not viable to export this material. However, there is huge demand for the granite
building stone in the domestic market.
VIII. Employment Generation (Direct and Indirect) due to the project.
As per the requirement of Mines Act, Mines manager, Mines Foreman, Mine mates, Blaster, shall
be appointed to supervise the quarrying operations. The list of the staff and workmen those shall
be employed in the quarry is given below.
Sl. No Particulars No’s
1 Highly Skilled 1
2 Skilled 12
3 Semi-skilled 12
4 Un-skilled 10
Total 35
3. PROJECT DESCRIPTION
(i) Type of project including interlinked and interdependent projects, if any.
The building stone shall be produced by drilling and blasting, the blasted material shall be
loaded using excavators and transported to the crushing and screen plant located outside the
lease area for reducing it to the sizes acceptable to the market .
(ii) Location (map showing general location, specific location, and project boundary
& project site layout) with Co-ordinates.
The ‘Granite building Stone Quarry of M/s. Krishnagiri Stone Crushers ' over an area of 1.400
Ha. is located in Survey No 308 in Vengappally Village, Vythiri Taluk, Wayanad District,
Kerala State.
The latitude & longitude of the area is given below.
B. P. No. Latitude Longitude
1 11°37'11.67'' N 76°02'15.08'' E
2 11°37'11.77'' N 76°02'15.77'' E
3 11°37'12.39'' N 76°02'17.03'' E
4 11°37'13.05'' N 76°02'20.47'' E
5 11°37'13.58'' N 76°02'20.83'' E
6 11°37'13.82'' N 76°02'21.64'' E
7 11°37'10.08'' N 76°02'22.53'' E
8 11°37'10.13'' N 76°02'21.77'' E
9 11°37'10.32'' N 76°02'21.50'' E
10 11°37'09.59'' N 76°02'21.23'' E
11 11°37'09.27'' N 76°02'20.72'' E
Granite Building Stone Quarry of M/s. Krishnagiri Stone Crushers Pre-feasibility Report
..8
12 11°37'09.25'' N 76°02'20.25'' E
13 11°37'10.07'' N 76°02'19.77'' E
14 11°37'11.42'' N 76°02'19.28'' E
15 11°37'11.14'' N 76°02'17.87'' E
16 11°37'10.94'' N 76°02'17.58'' E
17 11°37'10.75'' N 76°02'15.14'' E
Key Plan showing the general location is Enclosed as Plate No.1A (Mining Plan), Cadastral
Plan & Infrastructure Plan showing Specific location enclosed as Plate No. 2-2B (Mining
Plan) & Surface Plan Showing the project boundary & project site layout with Co-ordinates is
enclosed as Plate No-3 (Mining Plan) .
(iii) Details of alternate sites considered and the basis of selecting the proposed site,
particularly the environmental considerations gone into should be highlighted.
This is site specific project. Quarrying activities are carried out based on local geology and
availability of the granite building stone at the specific site.
(iv) Size or magnitude of operation.
Small scale operation within an area of 1.400Ha, Maximum Production planned 50,325
Tonnes per Annum (TPA) of granite building stone with maximum output size of
minus150mm.
(v) Project description with process details (a schematic diagram/ flow chart showing the
project layout, components of the project etc. should be given).
The quarrying of granite building stone is proposed by opencast semi-mechanized quarrying
method and the sequence of quarrying shall be as given under,
• The top soil shall be removed and used in afforestation / Green belt / Safety barrier all along
the periphery of the quarry lease area.
• After exposing the granites, drilling of small diameter holes of 33/48mm, shall be done by jack
hammer.
• The blasting shall be carried out by conventional blasting material with proper burden &
spacing.
• The Rock breakers shall be used to break the oversize boulders left after blasting.
• No secondary blasting like plaster shooting, pop blasting shall be undertaken at any time in the
quarry.
• The blasted material and the broken material by rock breakers shall be loaded to the tippers by
excavator and transported to the crushing and screening plant located outside the quarry lease
area.
Granite Building Stone Quarry of M/s. Krishnagiri Stone Crushers Pre-feasibility Report
..9
Summary of the production and development is given in the table below
Year Production
(T)
Top Soil
(T)
Total Handling
(T) Ratio
I-Year 50,020 6,295 56,315 1:0.13
II-Year 50,049 6,176 56,225 1:0.12
III-Year 50,325 - 50,325 1:0.00
IV-Year 50,249 - 50,249 1:0.00
V-Year 50,059 - 50,059 1:0.00
Total 2,50,701 12,471 2,63,173 1:0.05
At conceptual stage there shall be single pit in this area with10 benches of 5m height and 5m
width. The pit at conceptual stage shall have 83m length and 198m width and it shall be
developed upto 745mRL level. The overall pit slope shall be maintained at less than 450.
The entire pit at the conceptual stage shall be converted into rain water pond. The pit shall be
properly fenced with single opening for drawing the water. The pit shall also be developed for
pisciculture with simple vegetation. Conceptual Plan & Sections are enclosed as Plate No.7 &
Environment Plan is enclosed as Plate No.8 (Mining Plan).
Totally 12,471 Tonnes top soil shall be recovered and 2,50,701 Tonnes granite building stone
shall be Mined in the first Five years of the plan period. The top soil shall be stacked at the
safety barrier area and shall be used for Afforestation/Green belt development.
The Geological resources of granite building stone in this area are 7,10,004 Tonnes and
mineral reserves are 3,72,660 Tonnes. In the first five years of plan period totally 2,50,701
Tonnes granite building stone / aggregate shall be quarried. The balance mineral reserves of
1,21,959Tonnes granite building stone / aggregate shall be quarried in the subsequent mining plan
period.
Removal of Top Soil / Overburden
Drilling and Blasting
Excavation, loading and Transportation of -
150mm size boulders
Haulage/ Dispatch to Crusher outside
the lease
Granite Building Stone Quarry of M/s. Krishnagiri Stone Crushers Pre-feasibility Report
..10
Considering the above the anticipated life of the mine is about 10 years.
(vi) Raw material required along with estimated quantity, likely source, marketing area of final
products, mode of transports of raw Material and finished product.
No raw materials are required for producing granite building stone, the final products shall be
transported by 10 tonnes tippers to the crushing & screening plant located outside the lease area.
(vii) Resource optimization/ recycling and reuse envisaged in the project, if any, should be briefly
outlined.
There shall not be any waste production in the quarry process as all the by-products can be utilized
in the infrastructure market.
(viii) Availability of water its source, Energy/ power requirement and source should be given.
Around 34 KLD of water is required for dust suppression, afforestation and domestic use, which
shall be drawn from nearby old quarries and bore wells.
Requirement of water
Purpose Qty Required
m3/day
Drinking water & Domestic 4
Afforestation 10
Dust suppression 20
Total 34*
* The water for Plantation and dust suppression will not be required for 4-5 months in a year during
monsoon and wet/ rainy days.
* All Excavators, Tippers, Compressors and all other equipments are self primed by diesel engines. No
external power is require for the project.
(ix) Quantity of wastes to be generated (liquid and solid) and scheme for their Management/
disposal.
There shall not be any waste generation (liquid & Solid) during the course of production of the
Granite building stones. Only the top soil shall be utilized for the development of the green belt in
the 7.5 meters safety zone.
Granite Building Stone Quarry of M/s. Krishnagiri Stone Crushers Pre-feasibility Report
..11
(x) Schematic representations of the feasibility drawing which give information of the project
Quarrying Operations
• The Crushing & Screening Plant is proposed to be located Outside the Lease Area.
4. SITE ANALYSIS:
(i) Connectivity.
This granite building stone quarry is located at 1.50km from Vengappally Village in
Vythiri Taluk, which is located at about 7.50 km NE of Wayanad District. The quarry can
be reached via Pinangode -State High way road. The Infrastructure Plan is enclose vide
Plate No.11.
(ii) Land Form, Land use and Land ownership.
The Land Details & Possession certificate of M/s. Krishnagiri Stone Crushers is enclosed as
Annexure- 5 (Mining plan).
Present land use, land use at the end of progressive stage and the ultimate land use pattern.
Particulars
Land use
pattern at
present stage
(Ha)
Land use pattern
(end of progressive
stage) (Ha)
Land use
pattern at
Conceptual
stage (Ha)
Area for mining / mining activities 0.311 0.937 0.937
Area for Roads - - -
Area for Safety Barrier / Green
belt - 0.463 0.463
Total 0.311 1.400 1.400
Unused area 1.089 - -
Total Mining Lease Area 1.400 1.400 1.400
Drilling & Blasting
Granite Quarry
Excavation Granite Transportation to Crusher
Crushing & Screening Plant is
located outside the mining lease area
Top soil utilized for the development of
the Green belt
Granite Building Stone Quarry of M/s. Krishnagiri Stone Crushers Pre-feasibility Report
..12
(iii) Topography (along with map).
The lease area is located on the slope of the hillock gently dipping towards SW. The highest
elevation in this area is 790mRL and the lowest elevation is 766mRL. Topo sheet no. NC
43-3 showing the topographical details in the radius of 5 Kms of the lease area is enclosed as
Plate No-1A (Mining Plan) & Surface Plan of the Quarry lease enclosed vide Plate
No.3(Mining Plan).
(iv) Existing land use pattern (agriculture, non-agriculture, forest, water bodies (including
area under CRZ)), shortest distances from the periphery of the project to periphery of
the forests, national park, wild life sanctuary, eco sensitive area, water bodies (distance
from the HFL of the river). CRZ. In case of notified industrial area, a copy the Gazette
notification should be given.
M/s. Krishnagiri Stone Crushers area is located on the slope of the hillock gently dipping
towards SW. The core zone area is privately owned land. It is not a forest land and there is no
human habitation. Most of the area covered with rock formations over which thin vegetation
exists. The core zone is partly disturbed due to quarrying.
There is no forest land, no area under CRZ, No water bodies, and no Sanctuary in the core zone.
(v) Existing Infrastructure.
Hospital : Government Hospital Kalpetta-6Kms
School : Government HSS Kalpetta-6Kms
Church : DE Paul Church Kalpetta-6Kms
National Highway : Calicut-Bangalore NH-212 (E) 6 Kms from the Lease Area
State Highway : Kalpetta - Padinjarathara SH-54 (W) 1 Km from the Lease Area
Major District Road : Kalpetta - Padinjarathara SH-54 (W) 1 Km from the Lease Area
(vi) Soil Classification:
There is a soil cover of 0 to 1.7m thickness on the granite in the quarry lease area. The soil is
Lateritic soil, reddish in color and clay with loamy nature.
Granite Building Stone Quarry of M/s. Krishnagiri Stone Crushers Pre-feasibility Report
..13
(vii) Climatic data from Secondary Sources:
Maximum & Minimum Temperature
36.20C - Maximum temperature (April to May
during summer) 17.00C – Minimum temperature
during March & April
Relative Humidity 95 % per cent during the south west monsoon
period.
Rainfall Annual Average 2786mm, South West monsoon
during June to Sept. contributes 70%.
(viii) Social Infrastructure available:
Hospital : Government Hospital Kalpetta-6Kms
School : Government HSS Kalpetta-6Kms
Church : DE Paul Church Kalpetta-6Kms
National Highway : Calicut-Bangalore NH-212 (E) 6 Kms from the Lease Area
State Highway : Kalpetta - Padinjarathara SH-54 (W) 1 Km from the Lease Area
Major District Road : Kalpetta - Padinjarathara SH-54 (W) 1 Km from the Lease Area
5. PLANNING BRIEF:
i. Planning concept (type of industries, facilities, transportation etc) Town and Country
planning/ Development authority Classification:
This is a granite Building stone mining project.
It is proposed to produce maximum 50,325 tonnes building stones per annum. The mined material
will be transported by trucks to the crushing & screening plant located outside the quarry lease
area by tippers of 10tonnes capacity. Effective Environment Management will be carried out to
control the pollution of Air, Water, Noise and Ground vibration.
The Mining Plan for the operations in the quarry lease area is approved by the District Geologist,
Department of Mining and Geology Government of Kerala, Wayanad District, Kerala, vide Letter
No . DOW/M-558/17 dated 02.08.2017.
ii. Population Projection:
There will not be any increase in population due to the project. The man power required shall be
employed from the local areas. The drivers / truck operators also shall be engaged from local areas.
Hence not much influx of population from outside is anticipated.
Granite Building Stone Quarry of M/s. Krishnagiri Stone Crushers Pre-feasibility Report
..14
iii. Land use planning (breakup along with green belt etc):
Particulars
Land use
pattern at
present stage
(Ha)
Land use pattern
(end of progressive
stage) (Ha)
Land use
pattern at
Conceptual
stage (Ha)
Area for mining / mining activities 0.311 0.937 0.937
Area for Roads - - -
Area for Safety Barrier / Green
belt - 0.463 0.463
Total 0.311 1.400 1.400
Unused area 1.089 - -
Total Mining Lease Area 1.400 1.400 1.400
iv. Assessment of Infrastructure demand (physical & social):
All the manpower for the project shall be employed from the local area. Thus, there shall not be
influx of people into the region; therefore, no increase in the population is envisaged during the
period of the operations.
The operations are also small scale. Hence, infrastructure demand both in the form of physical and
social infrastructure, in terms of physical infrastructure will not be very demanding.
However, the project would raise the economic status of the people in the region thus the social
infrastructure like education, health and hygiene, sports, etc. would be quite demanding. The
company thus commits to support the local community in the field of Health & Hygiene, Basic
education, Education of girl child, Sports, renewable energy etc. thereby strengthening the social
infrastructure of the region.
6. PROPOSED INFRASTRUCTURE
(i) Industrial Area (Processing Area):
No Crushing or screening or processing is planned within the quarry lease area. The entire product
from the mine will be transported to the Crushing & Screening plant located outside the lease area.
Existing road shall be strengthened & made use for the transportation. As the mining equipment
are all diesel powered there is no need for external power. The infrastructure facilities like Quarry
office, site services, First Aid room, Rest shelter, and other statutory facilities, etc., shall be located
in the close proximity of the quarry lease area.
The man power requirement shall be employed from local area, no additional infrastructure is
required.
Granite Building Stone Quarry of M/s. Krishnagiri Stone Crushers Pre-feasibility Report
..15
(ii) Residential Area (Non Processing Area):
No additional residential area is required as the manpower for this project shall be employed from
the nearby villages.
(iii)Green Belt:
About 800 plants shall be planted in green belt area (0.463Ha) and another 200 sapling shall be
planted all along the haulage road.
(iv) Social Infrastructure:
The project shall generate 35 direct and Equal indirect employment to the local people. Hence, the
activity will contribute to the improvement of income status of the local people. The quarry project
will also improve infrastructure facilities, eventually leading to the overall development of the area,
resulting in the improvement of standard of life of local population.
The Project proponent undertakes to spend Rs 3.00 Lakhs per Annum, to take up CSR works in the
surrounding villages in the sector of Healthcare, Sanitation, Education of Girl child, Sports,
Environment, renewable energy, etc.
CSR - Annual Commitment
Sl No Activity Period Amount
(Lakhs)
1 Scholarship for the Girls passing out of 7
th & 10
th Standard
from Govt. Higher Secondary School. Yearly 0.50
2 Teaching Aids for Kuppakolly Tribal school
(Ambalavayal). Yearly 0.50
3 Annual Health camps. Yearly 0.50
4 Rain Water Harvesting in Domestic Wells of water scarce
areas in the local place. Yearly 0.50
5 Projects related to Endemic species conversation, Wild life
conservation etc. Yearly 0.50
6 Any other CSR project work in consultation with local self
Government (LSG's). Yearly 0.50
Total 3.00
(v) Connectivity (Traffic and Transportation Road/ Rail/ Metro/ Water ways etc)
granite building stone quarry is located at 1.50km from Vengappally Village in Vythiri
Taluk, which is located at about 7.50 km NE of Wayanad District. The quarry can be
reached via Pinangode -State High way road. The Infrastructure Plan is enclose vide Plate
No.11.
Granite Building Stone Quarry of M/s. Krishnagiri Stone Crushers Pre-feasibility Report
..16
(vi) Drinking water Management (Source & Supply of Water):
Drinking water shall be made available at all the times to the mine workers. This will be
sourced by water tankers from the bore well outside the quarry lease area, A water purifier
shall be installed to provide safe drinking water.
(vii) Sewerage system:
Not applicable, as no human settlement is proposed in the lease area.
(viii) Industrial Waste Management:
No industrial waste is going to generate at this quarry
(ix) Solid waste Management:
It is expected to recover 12,471 tonnes top soil during quarrying this area. This top soil shall
be used in afforestation / Green belt / Safety barrier all along the periphery of the quarry
lease area.
No other waste is envisaged from the operations.
Power Requirement & Supply / Source:
As all the machinery are self primed by diesel engines, no external power is required.
REHABILITATION AND RESETTLEMENT (R*R) PLAN
(i) Policy to be adopted (Central/ State) in respect of the project affected persons including
home ousters, land ousters and land less laborers (a brief outline to be given):
Not applicable since there is no rehabilitation and resettlement involved in this project.
7. PROJECT SCHEDULE & COST ESTIMATES
i. Likely date of start of construction and likely date of completion (Time schedule for the
project to be given):
The Quarry will be commenced immediately after getting the statutory approvals from
Government authorities. Total cost of the project is about Rs 140.00 lakhs.
ii. Estimated project cost along with analysis in terms of Economic viability of the project.
Considering the present domestic market conditions of the products, the appx. Cost of the project
estimated is around Rs. 140 lakhs. The summary of the assets are given below. Mining machinery
will be hired through contractors.
Table No.F8.1: Capital Cost of the Project
Sl No. DESCRIPTION Capital investment
Cost in lakh Rs.
Granite Building Stone Quarry of M/s. Krishnagiri Stone Crushers Pre-feasibility Report
..17
Table No.F8.2: Operating Cost of the Project
Sl.No. Details Cost
1 The estimated capital cost of the project Rs.140.0 Lakhs
2 Total pit head cost/Tonne of stone Rs.125.00
3 Royalty & Others related Cost per Tonne Rs.50.00
4 Net production cost per Tonne (Pit Head) Rs.175.00
5 Selling price per Tonne (Pit Head) Rs.250.00
6 Gross Profit/tonne Rs.75.0
7 Gross Profit/annum for 50,140 tonnes Rs. 37.60Lakhs
Therefore the proposed project is financially viable. However, increase in prices of building stone
in domestic market is further expected.
8. ANALYSIS OF PROPOSAL (FINAL RECOMMENDATIONS)
This project will be one of the major economic activities resulting in provide livelihood and have
positive impact on socio-economic life of people living in nearby villages thereby contributing to
the overall up gradation of living standards. The project also generates revenues to the state and
central governments, by way of royalties, taxes, Cess, DMF, etc,
The mining operations shall be providing employment to approximately 35 persons directly and
equal persons indirectly.
• The company plans to provide good support to the local schools and provide scholarships for the
High school Girl students.
• Health care, sanitation, sport facilities, etc shall be improved on account of the facilities being
planned as part of the CSR works by the company.
• The mined out pit at the end of the mining operations will be developed into a pond for
Pisciculture that could provide livelihood for a few villages. The water could be used for
agriculture & various other purposes.
1 Water Tanker (1 No.) 10.0
2 Jeep (1 No.) 8.0
3 Excavator, Rock breaker, Tipper
etc., (Mobilization Charges) 50.0
4 Strengthening of Roads 10.0
5 Temporary sheds, Rest shelters etc., 10.0
6 Environmental Control Measures 14.0
7 D.G. Set 2.00
8 Mine Development 10.0
9 Land Expenses 20.0
10 Miscellaneous 06.0
Total 140.0