sony cdx r3350

46
1 Ver. 1.0 2004.12 Model Name Using Similar Mechanism NEW CD Drive Mechanism Type MG-611TA-186//Q Optical Pick-up Name KSS1000E SERVICE MANUAL AEP Model UK Model CDX-R3350/R3350C CD player section Signal-to-noise ratio 120 dB Frequency response 10 – 20,000 Hz Wow and flutter Below measurable limit Tuner section FM Tuning range 87.5 – 108 MHz Antenna terminal External antenna connector Intermediate frequency 10.7 MHz/450 kHz Usable sensitivity 9 dBf Selectivity 75 dB at 400 kHz Signal-to-noise ratio 67 dB (stereo), 69 dB (mono) Harmonic distortion at 1 kHz 0.5% (stereo), 0.3% (mono) Separation 35 dB at 1 kHz Frequency response 30 – 15,000 Hz SPECIFICATIONS MW/LW Tuning range MW: 531 – 1,602 kHz LW: 153 – 279 kHz Antenna terminal External antenna connector Intermediate frequency 10.7 MHz/450 kHz Sensitivity MW: 30 μV LW: 40 μV Power amplifier section Outputs Speaker outputs (sure seal connectors) Speaker impedance 4 – 8 ohms Maximum power output 50 W 4 (at 4 ohms) General Outputs Audio outputs terminal (front (CDX-R3350C only), sub/rear switchable) Power antenna relay control terminal Power amplifier control terminal Inputs Telephone ATT control terminal BUS control input terminal (CDX-R3350C only) BUS audio input terminal (CDX-R3350C only) Remote controller input terminal Antenna input terminal • The tuner and CD sections have no adjustments. Sony Corporation e Vehicle Company Published by Sony Engineering Corporation 9-879-385-01 2004L04-1 © 2004. 12 – Continued on next page – FM/MW/LW COMPACT DISC PLAYER Photo: CDX-R3350C

Upload: engine24

Post on 06-Mar-2015

814 views

Category:

Documents


21 download

TRANSCRIPT

Page 1: Sony Cdx r3350

1

Ver. 1.0 2004.12

Model Name Using Similar Mechanism NEW

CD Drive Mechanism Type MG-611TA-186//Q

Optical Pick-up Name KSS1000E

SERVICE MANUAL AEP ModelUK Model

CDX-R3350/R3350C

CD player sectionSignal-to-noise ratio 120 dBFrequency response 10 – 20,000 HzWow and flutter Below measurable limit

Tuner sectionFMTuning range 87.5 – 108 MHzAntenna terminal External antenna connectorIntermediate frequency 10.7 MHz/450 kHzUsable sensitivity 9 dBfSelectivity 75 dB at 400 kHzSignal-to-noise ratio 67 dB (stereo),

69 dB (mono)Harmonic distortion at 1 kHz

0.5% (stereo),0.3% (mono)

Separation 35 dB at 1 kHzFrequency response 30 – 15,000 Hz

SPECIFICATIONS

MW/LWTuning range MW: 531 – 1,602 kHz

LW: 153 – 279 kHzAntenna terminal External antenna connectorIntermediate frequency 10.7 MHz/450 kHzSensitivity MW: 30 µV

LW: 40 µV

Power amplifier sectionOutputs Speaker outputs

(sure seal connectors)Speaker impedance 4 – 8 ohmsMaximum power output 50 W × 4 (at 4 ohms)

GeneralOutputs Audio outputs terminal

(front (CDX-R3350C only), sub/rear switchable)Power antenna relay control terminalPower amplifier control terminal

Inputs Telephone ATT control terminalBUS control input terminal (CDX-R3350C only)BUS audio input terminal (CDX-R3350C only)Remote controller input terminalAntenna input terminal

• The tuner and CD sections have no adjustments.

Sony Corporatione Vehicle Company

Published by Sony Engineering Corporation

9-879-385-012004L04-1

© 2004. 12

– Continued on next page –

FM/MW/LW COMPACT DISC PLAYER

Photo: CDX-R3350C

Page 2: Sony Cdx r3350

2

CDX-R3350/R3350C

If the optical pick-up block is defective, please replace the wholeoptical pick-up block.Never turn the semi-fixed resistor located at the side of opticalpick-up block.

CAUTIONUse of controls or adjustments or performance of proceduresother than those specified herein may result in hazardousradiation exposure.

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINEWITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND INTHE PARTS LIST ARE CRITICAL TO SAFE OPERATION.REPLACE THESE COMPONENTS WITH SONY PARTS WHOSEPART NUMBERS APPEAR AS SHOWN IN THIS MANUAL ORIN SUPPLEMENTS PUBLISHED BY SONY.

Tone controls Low: ±10 dB at 60 Hz (XPLOD)Mid: ±10 dB at 1 kHz (XPLOD)High: ±10 dB at 10 kHz (XPLOD)

Power requirements 12 V DC car battery(negative ground)

Dimensions Approx. 178 × 50 × 179 mm(w/h/d)

Mounting dimensions Approx. 182 × 53 × 161 mm(w/h/d)

Mass Approx. 1.2 kgSupplied accessories Parts for installation and connections (1 set)

Front panel case (1)Card remote commander RM-X151

US and foreign patents licensed from Dolby Laboratories.

NoteThis unit cannot be connected to a digital preamplifier or an equalizer which is SonyBUS system compatible.

Design and specifications are subject to change withoutnotice.

NOTES ON HANDLING THE OPTICAL PICK-UP BLOCKOR BASE UNITThe laser diode in the optical pick-up block may suffer electrostaticbreakdown because of the potential difference generated by thecharged electrostatic load, etc. on clothing and the human body.During repair, pay attention to electrostatic breakdown and also usethe procedure in the printed matter which is included in the repairparts.The flexible board is easily damaged and should be handled withcare.

NOTES ON LASER DIODE EMISSION CHECKThe laser beam on this model is concentrated so as to be focused onthe disc reflective surface by the objective lens in the optical pick-up block. Therefore, when checking the laser diode emission, ob-serve from more than 30 cm away from the objective lens.

Notes on Chip Component Replacement• Never reuse a disconnected chip component.• Notice that the minus side of a tantalum capacitor may be

damaged by heat.

TEST DISCSThis set can playback CD-R and CD-ROM discs. The followingtest discs should be used to check the capability:

CD-R test disc TCD-R082LMT (Part No. J-2502-063-1)CD-RW test disc TCD-W082L (Part No. J-2502-063-2)

SERVICE NOTES

optical pick-up

semi-fixed resistor

This label is located on the bottom of the chassis.

Page 3: Sony Cdx r3350

3

CDX-R3350/R3350C

• CD Playback:You can play CD-DA (also containing CD TEXT*1), CD-R/CD-RW (MP3 files also containing Multi Session and ATRAC CD(ATRAC3 and ATRAC3plus format).

Type of discs Label on the disc

CD-DA

MP3

ATRAC CD

*1 A CD TEXT disc is a CD-DA that includes information such asdisc, artist and track name.

EXTENSION CABLE AND SERVICE POSITIONWhen repairing or servicing this set, connect the jig (extension cable)as shown below.

• Connect the MAIN board (CNP301) and the SERVO board (CN2)with the extension cable (Part No. J-2502-076-1).

z UNLEADED SOLDERBoards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead.(Caution: Some printed circuit boards may not come printed withthe lead free mark due to their particular size)

: LEAD FREE MARK

Unleaded solder has the following characteristics.• Unleaded solder melts at a temperature about 40 °C higher

than ordinary solder.Ordinary soldering irons can be used but the iron tip has to beapplied to the solder joint for a slightly longer time.Soldering irons using a temperature regulator should be set toabout 350 °C.Caution: The printed pattern (copper foil) may peel away ifthe heated tip is applied for too long, so be careful!

• Strong viscosityUnleaded solder is more viscou-s (sticky, less prone to flow)than ordinary solder so use caution not to let solder bridgesoccur such as on IC pins, etc.

• Usable with ordinary solderIt is best to use only unleaded solder but unleaded solder mayalso be added to ordinary solder.

SERVO BOARDCN2

J-2502-076-1MAIN BOARDCNP301

Page 4: Sony Cdx r3350

4

CDX-R3350/R3350C

TABLE OF CONTENTS

1. GENERALLocation of Controls ................................................................ 5Connections ............................................................................. 5

2. DISASSEMBLY2-1. Sub Panel Assy (CD) ........................................................... 82-2. CD Mechanism Block ......................................................... 82-3. Main Board ......................................................................... 92-4. Chassis (T) Sub Assy .......................................................... 92-5. Roller Arm Assy ................................................................ 102-6. Chassis (OP) Assy ............................................................. 102-7. Optical Pick-up ................................................................. 112-8. SL Motor Assy (M902) ..................................................... 112-9. LE Motor Assy (M903) ..................................................... 122-10. Servo Board ....................................................................... 12

3. DIAGRAMS3-1. Block Diagram –CD Section– ........................................... 133-2. Block Diagram –Main Section– ........................................ 143-3. Block Diagram –Display Section– .................................... 153-4. Circuit Boards Location .................................................... 153-5. Printed Wiring Boards –CD Mechanism Section– ............ 173-6. Schematic Diagram –CD Mechanism Section (1/2)– ....... 183-7. Schematic Diagram –CD Mechanism Section (2/2)– ....... 193-8. Printed Wiring Board –Main Section– .............................. 203-9. Schematic Diagram –Main Section (1/3)– ........................ 213-10. Schematic Diagram –Main Section (2/3)– ........................ 223-11. Schematic Diagram –Main Section (3/3)– ........................ 233-12. Printed Wiring Board –Display Section– .......................... 243-13. Schematic Diagram –Display Section– ............................. 25

4. EXPLODED VIEWS4-1. Main Section ..................................................................... 334-2. Front Panel Section ........................................................... 344-3. CD Mechanism Section (1) ............................................... 354-4. CD Mechanism Section (2) ............................................... 364-5. CD Mechanism Section (3) ............................................... 374-6. CD Mechanism Section (4) ............................................... 38

5. ELECTRICAL PARTS LIST ........................................ 39

Page 5: Sony Cdx r3350

5

CDX-R3350/R3350CSECTION 1GENERAL This section is extracted

from instruction manual.

• LOCATION OF CONTROL

• CONNECTIONS

6

Location of controls and basic operations

Main unit

Card remote commander RM-X151

ATT OFF

SOURCE MODE SEL

SEEK

1 2 3 4 5 6 SENSREP BTM LIST– GP/DISC + SHUF

PTYAF/TA

DSPL

DIM

EQ3

OPEN

SEEK

1 2 3 4 5 6 7 8

CDX-R3350C

9 0qaqs qd qf qg qh qj qk

OFF

DSPL SCRL

SELSOURCE MODE

1 32

4 65

ATT

VOL+

+

2

3

7

0qaqs

ws

ql

w;

wd

wa

7

Refer to the pages listed for details. The corresponding buttons on the card remote commander control the same functions as those on the unit.

a Volume +/– buttonTo adjust volume.

b ATT (attenuate) buttonTo attenuate the sound. To cancel, press again.

c DSPL (display)/DIM (dimmer) button 4, 8, 12To change display items (press); change the display brightness (press and hold).

d OPEN shutter, disc slot (located behind the shutter) 5

e Display windowf EQ3 (equalizer) button 10

To select an equalizer type (XPLOD, VOCAL, CLUB, JAZZ, NEW AGE, ROCK, CUSTOM or OFF).

g OFF buttonTo power off/stop the source.

h SEEK +/– buttonRadio:To tune in stations automatically (press); find a station manually (press and hold).CD:To skip tracks (press); skip tracks continuously (press, then press again within about 1 second and hold); fast-forward/reverse a track (press and hold).

i (front panel release) button 4j SOURCE button

To power on/change the source (Radio/CD/MD*1).

k MODE button 8, 11To select the radio band (FM/MW/LW)/select the unit*2.

l SEL (select) button 4, 10, 11, 12To select items.

m RESET button (located behind the front panel) 4

n Number buttonsRadio:To receive stored stations (press); store stations (press and hold).CD/MD*1:(1)/(2): GP*3/DISC*2 –/+To skip groups (press); skip groups continuously (press and hold).(3): REP 8(4): SHUF 8

o SENS/BTM button 8To improve weak reception: LOCAL/MONO (press); start the BTM function (press and hold).

p AF (Alternative Frequencies)/TA (Traffic Announcement) button 9To set AF and TA/TP in RDS.

q PTY (Programme Type)/LIST button 10To select PTY in RDS; list up.

r Receptor for the card remote commander

The following buttons on the card remote commander have also different buttons/functions from the unit.

s < (.)/, (>) buttonsTo control radio/CD, the same as (SEEK) +/– on the unit. (For details of other operations, see “With the card remote commander” on each pages.)

t VOL (volume) +/– buttonTo adjust volume.

u M (+)/m (–) buttonsTo control CD, the same as (1)/(2) –/+ on the unit. (For details of other operations, see “With the card remote commander” on each pages.)

v SCRL button 8To scroll the display item.

w Number buttonsTo receive stored stations (press); store stations (press and hold).

*1 When an MD changer is connected. (CDX-R3350C only)

*2 When a CD/MD changer is connected. (CDX-R3350C only)

*3 When an MP3/ATRAC CD is played and a changer is not connected. If the changer is connected, the operation is different, see page 11.

NoteIf the unit is turned off and the display disappears, it cannot be operated with the card remote commander unless (SOURCE) on the unit is pressed, or a disc is inserted to activate the unit first.

TipFor details on how to replace the battery, see “Replacing the lithium battery of the card remote commander” on page 15.

AUDIO OUT FRONT*1

AUDIO OUT REAR*2

BUS AUDIO IN

BUS CONTROL IN

BUS AUDIO IN

BUS CONTROL IN

A

B

CDX-R3350C onlyNur CDX-R3350CCDX-R3350C uniquementSolo CDX-R3350CAlleen voor de CDX-R3350C

* not supplied nicht mitgeliefert

non fourni non in dotazione niet bijgeleverd

Source selector*Signalquellenwähler*Sélecteur de source*

Selettore di fonte*Geluidsbronkiezer*

XA-C30

CDX-R3350C only/Nur CDX-R3350C/CDX-R3350C uniquement/Solo CDX-R3350C/Alleen voor de CDX-R3350C

*1

*2AUDIO OUT SUB/REAR

Voorbeeldaansluitingen (2)Opmerkingen (2-A)• Sluit eerst de aarddraad aan voordat u de versterker aansluit.• U hoort de waarschuwingstoon alleen als de ingebouwde

versterker wordt gebruikt.

Tip (2-B- )Om twee of meer CD/MD-wisselaars aan te sluiten, hebt u de geluidsbronkiezer XA-C30 (optioneel) nodig.

Exemple de raccordement (2)Remarques (2-A) • Raccordez d’abord le câble de mise à la masse avant de

connecter l’amplifi cateur.• L’alarme est émise uniquement lorsque l’amplifi cateur intégré

est utilisé.

Conseil (2-B- )Dans le cas du raccordement de deux changeurs de CD/MD ou plus, le sélecteur de source XA-C30 (en option) est indispensable.

Anschlussbeispiel (2)Hinweise (2-A)• Schließen Sie unbedingt zuerst das Massekabel an, bevor Sie

den Verstärker anschließen.• Der Warnton wird nur ausgegeben, wenn der integrierte

Verstärker verwendet wird.

Tipp (2-B- )Zum Anschlieflen von zwei oder mehr CD/MD-Wechslern wird der gesondert erhältliche Signalquellenwähler XA-C30 benö tigt.

Esempio di collegamento (2)Note (2-A) • Assicurarsi di collegare il cavo di terra prima di collegare

l’apparecchio all’amplifi catore.• Tale segnale viene emesso solo se è in uso l’amplifi catore

incorporato.

Suggerimento (2-B- )Per collegare due o più cambia CD/MD, si deve utilizzare il selettore di fonte XA-C30 (opzionale).

Connection example (2)Notes (2-A)• Be sure to connect the earth lead before connecting the

amplifi er.• The alarm will only sound if the built-in amplifi er is used.

Tip (2-B- )For connecting two or more CD/MD changers, the source selector XA-C30 (optional) is necessary.

Page 6: Sony Cdx r3350

6

CDX-R3350/R3350C

L

R

AUDIO OUT*3

FRONT

BUSCONTROL IN*3

REMOTEIN

BUS AUDIO IN*3

AUDIO OUT REAR*4

1 3 5 7

2 4 6 8

5 7

4 8

from car aerialvon Autoantennede l’antenne de la voituredall’antenna dell’autovan een auto-antenne

Fuse (10 A)Sicherung (10 A)Fusible (10 A)Fusibile (10 A)Zekering (10 A)

AMP REM

Light blueHellblauBleu cielAzzurroLichtblauw

Blue/white stripedBlauweiß gestreiftRayé bleu/blancRigato blu e biancoBlauw/wit gestreept

from the car’s power connectorvom Stromanschluss des Fahrzeugsdu connecteur d’alimentation de la voituredal connettore di alimentazione dell’autovan de autovoedingsstekker

ATT

See “Power connection diagram” on the reverse side for details.

Näheres dazu fi nden Sie im ,,Stromanschlussdiagramm“. Blättern Sie dazu bitte um.

Voir le « Schéma de raccordement d’alimentation » au verso pour plus de détails.

Per ulteriori informazioni, vedere “Diagramma dei collegamenti di alimentazione” che si trova sul retro.

Zie "Voedingsaansluitschema" op de achterkant voor meer details.

*1 Note for the aerial connectingIf your car aerial is an ISO (International Organisation for Standardisation) type, use the supplied adaptor 2 to connect it. First connect the car aerial to the supplied adaptor, then connect it to the aerial jack of the master unit.

*2 RCA pin cord (not supplied)*3 CDX-R3350C only*4 AUDIO OUT can be switched SUB or

REAR. For details, see the Operating Instructions manual.

*5 Insert with the cord upwards.

*1 Hinweis zum Anschließen der AntenneWenn Ihre Fahrzeugantenne der ISO-Norm (ISO = International Organization for Standardization - Internationale Normungsgemeinschaft) entspricht, schließen Sie sie mithilfe des mitgelieferten Adapters 2 an. Verbinden Sie zuerst die Fahrzeugantenne mit dem mitgelieferten Adapter und verbinden Sie diesen dann mit der Antennenbuchse des Hauptgeräts.

*2 Cinchkabel (nicht mitgeliefert)*3 Nur CDX-R3350C*4 AUDIO OUT kann zwischen SUB

und REAR umgeschaltet werden. Näheres hierzu fi nden Sie in der Bedienungsanleitung.

*5 Mit dem Kabel nach oben einsetzen.

*1 Remarque sur le raccordement de l’antenneSi votre antenne de voiture est de type ISO (Organisation internationale de normalisation), utilisez l’adaptateur fourni

pour la r2 accorder. Raccordez d’abord l’antenne de voiture à l’adaptateur fourni et, ensuite, à la prise d’antenne de l’appareil principal.

*2 Cordon à broche RCA (non fourni)*3 CDX-R3350C uniquement*4 AUDIO OUT peut être commuté sur SUB

ou REAR. Pour obtenir plus de détails, reportez-vous au mode d’emploi.

*5 Insérez avec le câble vers le haut.

*1 Nota per il collegamento dell’antennaSe l’antenna dell’auto è di tipo ISO (International Organization for Standardization), utilizzare l’adattatore

in dotazione per collegar2 la. Collegare prima l’antenna della macchina all’adattatore in dotazione, quindi collegarla alla presa dell’antenna dell’apparecchio principale.

*2 Cavo a piedini RCA (non in dotazione)*3 Solo CDX-R3350C*4 AUDIO OUT può essere impostato

su SUB o su REAR. Per ulteriori informazioni, consultare il manuale di istruzioni per l’uso.

*5 Inserire con il cavo rivolto verso l’alto.

*1 Opmerking bij de antenne-aansluitingIndien uw auto is uitgerust met een antenne van het type ISO (International Organisation for Standardization), moet u die aansluiten met behulp van de bijgeleverde adapter 2. Sluit eerst de auto-antenne aan op de bijgeleverde adapter en vervolgens de antennestekker op het hoofdtoestel.

*2 Tulpstekkersnoer (niet bijgeleverd)*3 Alleen voor de CDX-R3350C*4 AUDIO OUT kan worden ingesteld

op SUB of REAR. Raadpleeg de gebruiksaanwijzing voor meer informatie.

*5 Plaatsen met het snoer naar boven.

Max. supply current 0.3 Amax. Versorgungsstrom 0,3 ACourant d’alimentation maximum 0,3 AAlimentazione massima fornita 0,3 AMax. voedingsstroom 0,3 A

*2

*5

Positions 1, 2, 3 and 6 do not have pins.An Position 1, 2, 3 und 6 be nden sich keine Stifte.Les positions 1, 2, 3 et 6 ne comportent pas de broches.Le posizioni 1, 2, 3 e 6 non hanno piedini.De posities 1, 2, 3 en 6 hebben geen pins.

4

YellowGelb

JauneGialloGeel

continuous power supplypermanente Stromversorgung

alimentation continuealimentazione continua

continu voeding

7

RedRot

RougeRossoRood

switched power supplygeschaltete Stromversorgung

alimentation commutéealimentazione commutata

geschakelde voeding

5

BlueBlauBleuBlu

Blauw

power aerial controlMotorantennensteuerung

antenne électriquecomando dell’antenna elettrica

automatische antenne

8

BlackSchwarz

NoirNeroZwart

earthMassemasseterra

aarding

Negative polarity positions 2, 4, 6, and 8 have striped leads.An den negativ gepolten Positionen 2, 4, 6 und 8 be nden sich gestreifte Adern.Les positions de polarité négative 2, 4, 6 et 8 sont dotées de cordons rayés.Le posizioni a polarità negativa 2, 4, 6 e 8 hanno cavi rigati.De posities voor negatieve polariteit (2, 4, 6 en 8) hebben gestreepte kabels.

1PurpleViolettMauveViolaPaars

+

Speaker, Rear, RightLautsprecher hinten rechtsHaut-parleur, arrière, droit

Diffusore, posteriore, destroLuidspreker, achter, rechts

5WhiteWeiflBlanc

BiancoWit

+

Speaker, Front, LeftLautsprecher vorne links

Haut-parleur, avant, gaucheDiffusore, anteriore, sinistro

Luidspreker, voor, links

2 –

Speaker, Rear, RightLautsprecher hinten rechtsHaut-parleur, arrière, droit

Diffusore, posteriore, destroLuidspreker, achter, rechts

6 –

Speaker, Front, LeftLautsprecher vorne links

Haut-parleur, avant, gaucheDiffusore, anteriore, sinistro

Luidspreker, voor, links

3GreyGrauGris

GrigioGrijs

+

Speaker, Front, RightLautsprecher vorne rechtsHaut-parleur, avant, droit

Diffusore, anteriore, destroLuidspreker, voor, rechts

7GreenGrünVert

VerdeGroen

+

Speaker, Rear, LeftLautsprecher hinten links

Haut-parleur, arrière, gaucheDiffusore, posteriore, sinistro

Luidspreker, achter, links

4 –

Speaker, Front, RightLautsprecher vorne rechtsHaut-parleur, avant, droit

Diffusore, anteriore, destroLuidspreker, voor, rechts

8 –

Speaker, Rear, LeftLautsprecher hinten links

Haut-parleur, arrière, gaucheDiffusore, posteriore, sinistro

Luidspreker, achter, links

from the car’s speaker connectorvom Lautsprecheranschluss des Fahrzeugsdu connecteur de haut-parleur de la voituredal connettore del diffusore dell’autovan de autoluidsprekerstekker

*2

Supplied with XA-C30Mit dem XA-C30 geliefertFourni avec le XA-C30In dotazione con il modello XA-C30Geleverd met de XA-C30

Source selector(not supplied)

Signalquellenwähler(nicht mitgeliefert)

Sélecteur de source(non fourni)

Selettore di fonte(non in dotazione)Geluidsbronkiezer(niet bijgeleverd)

XA-C30

Supplied with the CD/MD changerMit dem CD/MD-Wechsler geliefertFourni avec le changeur de CD/MDIn dotazione con il cambia CD/MDGeleverd met de CD/MD-wisselaar

*1

CDX-R3350C

3

2

Aansluitschema (3)A Naar AMP REMOTE IN van een optionele

eindversterkerDeze aansluiting is alleen bedoeld voor versterkers. Door een ander systeem aan te sluiten kan het apparaat worden beschadigd.

B Naar het interface-snoer van een autotelefoon

WaarschuwingIndien u een elektrische antenne hebt zonder relaiskast, kan het aansluiten van deze eenheid met het bijgeleverde netsnoer 3 de antenne beschadigen.Opmerkingen over de bedienings- en voedingskabels• De antennevoedingskabel (blauw) levert +12 V gelijkstroom

wanneer u de tuner inschakelt of de AF (Alternative Frequency) of TA (Traf c Announcement) functie activeert.

• Wanneer uw auto is uitgerust met een FM/MW/LW-antenne in de achterruit/zijruit, moet u de antennevoedingskabel (blauw) of de hulpvoedingskabel (rood) aansluiten op de voedingsingang van de bestaande antenneversterker. Raadpleeg uw dealer voor meer details.

• Met dit apparaat is het niet mogelijk een automatische antenne zonder relaiskast te gebruiken.

Instandhouden van het geheugenZolang de gele stroomdraad is aangesloten, blijft de stroomvoorziening van het geheugen intact, ook wanneer het contact van de auto wordt uitgeschakeld.

Opmerkingen betreffende het aansluiten van de luidsprekers• Zorg dat het apparaat is uitgeschakeld, alvorens de

luidsprekers aan te sluiten.• Gebruik luidsprekers met een impedantie van 4 tot 8 Ohm

en let op dat die het vermogen van de versterker kunnen verwerken. Als dit wordt verzuimd, kunnen de luidsprekers ernstig beschadigd raken.

• Verbind in geen geval de aansluitingen van de luidsprekers met het chassis van de auto en sluit de aansluitingen van de rechter- en linkerluidspreker niet op elkaar aan.

• Verbind de aarddraad van dit apparaat niet met de negatieve (–) aansluiting van de luidspreker.

• Probeer nooit de luidsprekers parallel aan te sluiten.• Sluit geen actieve luidsprekers (met ingebouwde versterkers)

aan op de luidspreker-aansluiting van dit apparaat. Dit zal leiden tot beschadiging van de actieve luidsprekers. Sluit dus altijd uitsluitend luidsprekers zonder ingebouwde versterker aan.

• Om defecten te vermijden mag u de bestaande luidsprekerbedrading in uw auto niet gebruiken wanneer er een gemeenschappelijke negatieve (–) draad is voor de rechter- en linkerluidsprekers.

• Verbind de luidsprekerdraden niet met elkaar.

Opmerking over aansluitenAls de luidspreker en versterker niet correct zijn aangesloten, wordt "FAILURE" in het display weergegeven. In dit geval moet u zorgen dat de luidspreker en versterker correct zijn aangesloten.

Schémas de raccordement (3)A Au niveau du AMP REMOTE IN d’un

amplifi cateur de puissance facultatifCe raccordement existe seulement pour les amplifi cateurs. Le raccordement à tout autre système peut endommager l’appareil.

B Vers le cordon de liaison d’un téléphone de voiture

AvertissementSi vous disposez d’une antenne électrique sans boîtier de relais, le branchement de cet appareil au moyen du cordon d’alimentation fourni 3 risque d’endommager l’antenne.Remarques sur les câbles de commande et d’alimentation• Le câble de commande (bleu) fournit du courant continu de

+12 V lorsque vous mettez le tuner sous tension ou lorsque vous activez la fonction AF (fréquence alternative) ou TA (informations de circulation).

• Lorsque votre voiture est équipée d’une antenne FM/MW (GO)/LW (PO) intégrée dans la vitre arrière/latérale, raccordez le câble de commande d’antenne (bleu) ou l’entrée d’alimentation des accessoires (rouge) au bornier de l’amplifi cateur d’antenne existant. Pour plus de détails, consultez votre revendeur.

• Une antenne électrique sans boîtier de relais ne peut pas être utilisée avec cet appareil.

Raccordement pour la conservation de la mémoireLorsque le câble de commande d’antenne jaune est connecté, le circuit de la mémoire est alimenté en permanence même si la clé de contact est en position d’arrêt.

Remarques sur le raccordement des haut-parleurs• Avant de raccorder les haut-parleurs, mettre l’appareil hors

tension.• Utiliser des haut-parleurs ayant une impédance de 4 à 8 ohms

et une capacité adéquate sous peine de les endommager.• Ne pas raccorder les bornes du système de haut-parleurs au

châssis de la voiture et ne pas connecter les bornes du haut-parleur droit à celles du haut-parleur gauche.

• Ne pas raccorder le câble de mise à la masse de cet appareil à la borne négative (–) du haut-parleur.

• Ne pas tenter de raccorder les haut-parleurs en parallèle.• Connecter uniquement des haut-parleurs passifs. La

connexion de haut-parleurs actifs (avec des amplifi cateurs intégrés) aux bornes des haut-parleurs pourrait endommager l’appareil.

• Pour éviter tout dysfonctionnement, n’utilisez pas les câbles des haut-parleurs intégrés installés dans votre voiture si l’appareil dispose d’un câble négatif commun (–) pour les haut-parleurs droit et gauche.

• Ne raccordez pas entre eux les cordons des haut-parleurs de l’appareil.

Remarque sur le raccordementSi les enceintes et l’amplifi cateur ne sont pas raccordés correctement, le message « FAILURE » s’affi che. Dans ce cas, assurez-vous que les enceintes et l’amplifi cateur sont raccordés correctement.

Anschlussdiagramm (3)A An AMP REMOTE IN des gesondert

erhältlichen EndverstärkersDieser Anschluss ist ausschließlich für Verstärker gedacht. Schließen Sie nichts anderes daran an. Andernfalls kann das Gerät beschädigt werden.

B An Schnittstellenkabel eines Autotelefons

WarnungWenn Sie eine Motorantenne ohne Relaiskästchen verwenden, kann durch Anschließen dieses Geräts mit dem mitgelieferten Stromversorgungskabel 3 die Antenne beschädigt werden.Hinweise zu den Steuer- und Stromversorgungsleitungen• Die Motorantennen-Steuerleitung (blau) liefert +12 V

Gleichstrom, wenn Sie den Tuner einschalten oder die AF- (Alternativfrequenzsuche) oder die TA-Funktion (Verkehrsdurchsagen) aktivieren.

• Wenn das Fahrzeug mit einer in der Heck-/Seitenfensterscheibe integrierten UKW/MW/LW-Antenne ausgestattet ist, schließen Sie die Motorantennen-Steuerleitung (blau) oder die Zubehörstromversorgungsleitung (rot) an den Stromversorgungsanschluss des vorhandenen Antennenverstärkers an. Näheres dazu erfahren Sie bei Ihrem Händler.

• Es kann nur eine Motorantenne mit Relaiskästchen angeschlossen werden.

Stromversorgung des SpeichersWenn die gelbe Stromversorgungsleitung angeschlossen ist, wird der Speicher stets (auch bei ausgeschalteter Zündung) mit Strom versorgt.

Hinweise zum Lautsprecheranschluss• Schalten Sie das Gerät aus, bevor Sie die Lautsprecher

anschließen.• Verwenden Sie Lautsprecher mit einer Impedanz zwischen 4 und

8 Ohm und ausreichender Belastbarkeit. Ansonsten können die Lautsprecher beschädigt werden.

• Verbinden Sie die Lautsprecheranschlüsse nicht mit dem Wagenchassis und verbinden Sie auch nicht die Anschlüsse des rechten mit denen des linken Lautsprechers.

• Verbinden Sie die Masseleitung dieses Geräts nicht mit dem negativen (–) Lautsprecheranschluss.

• Versuchen Sie nicht, Lautsprecher parallel anzuschließen.• An die Lautsprecheranschlüsse dieses Geräts dürfen nur

Passivlautsprecher angeschlossen werden. Schließen Sie keine Aktivlautsprecher (Lautsprecher mit eingebauten Verstärkern) an, da das Gerät sonst beschädigt werden könnte.

• Um Fehlfunktionen zu vermeiden, verwenden Sie nicht die im Fahrzeug installierten, integrierten Lautsprecherleitungen, wenn am Ende eine gemeinsame negative (–) Leitung für den rechten und den linken Lautsprecher verwendet wird.

• Verbinden Sie nicht die Lautsprecherkabel des Geräts miteinander.

Hinweis zum AnschlieflenWenn Lautsprecher und Verstärker nicht richtig angeschlossen sind, erscheint ,,FAILURE“ im Display. Vergewissern Sie sichin diesem Fall, dass Lautsprecher und Verstärker richtig angeschlossen sind.

Schema di collegamento (3)A A AMP REMOTE IN di un ampli catore di

potenza opzionale Questo collegamento è riservato esclusivamente agli amplifi catori. Non collegare un tipo di sistema diverso onde evitare di causare danni all’apparecchio.

B Al cavo di interfaccia di un telefono per auto

AvvertenzaQuando si collega l’apparecchio con il cavo di alimentazione in dotazione 3, si potrebbe danneggiare l’antenna elettrica se questa non dispone di scatola a relè.Note sui cavi di controllo e di alimentazione• Il cavo (blu) di controllo dell’antenna elettrica fornisce

alimentazione pari a +12 V CC quando si attiva il sintonizzatore oppure la funzione TA (notiziario sul traffi co) o AF (frequenza alternativa).

• Se l’automobile è dotata di antenna FM/MW/LW incorporata nel vetro posteriore/laterale, collegare il cavo (blu) di controllo dell’antenna elettrica o il cavo (rosso) di ingresso dell’alimentazione accessoria al terminale di alimentazione del preamplifi catore dell’antenna esistente. Per ulteriori informazioni, consultare il proprio fornitore.

• Non è possibile usare un’antenna elettrica senza scatola a relè con questo apparecchio.

Collegamento per la conservazione della memoriaQuando il cavo di ingresso alimentazione giallo è collegato, viene sempre fornita alimentazione al circuito di memoria anche quando l’interruttore di accensione è spento.

Note sul collegamento dei diffusori• Prima di collegare i diffusori spegnere l’apparecchio.• Usare diffusori di impedenza compresa tra 4 e 8 ohm e con

capacità di potenza adeguata, altrimenti i diffusori potrebbero venire danneggiati.

• Non collegare i terminali del sistema diffusori al telaio dell’auto e non collegare i terminali del diffusore destro a quelli del diffusore sinistro.

• Non collegare il cavo di terra di questo apparecchio al terminale negativo (–) del diffusore.

• Non collegare i diffusori in parallelo.• Assicurarsi di collegare soltanto diffusori passivi, poiché

il collegamento di diffusori attivi, dotati di amplifi catori incorporati, ai terminali dei diffusori potrebbe danneggiare l’apparecchio.

• Per evitare problemi di funzionamento, non utilizzare i cavi dei diffusori incorporati installati nell’automobile se l’apparecchio condivide un cavo comune negativo (–) per i diffusori destro e sinistro.

• Non collegare fra loro i cavi dei diffusori dell’apparecchio.

Nota sui collegamentiSe l’amplifi catore e il diffusore non sono collegati correttamente, “FAILURE” viene visualizzato nel display. In tal caso, accertarsi che l’amplifi catore e il diffusore siano collegati correttamente.

Connection diagram (3)A To AMP REMOTE IN of an optional power

amplifi erThis connection is only for amplifi ers. Connecting any other system may damage the unit.

B To the interface cable of a car telephone

WarningIf you have a power aerial without a relay box, connecting this unit with the supplied power connecting lead 3 may damage the aerial.Notes on the control power and suppy leads• The power aerial control lead (blue) supplies +12 V DC when

you turn on the tuner, or when you activate the AF (Alternative Frequency) or TA (Traf c Announcement) function.

• When your car has built-in FM/MW/LW aerial in the rear/side glass, connect the power aerial control lead (blue) or the accessory power input lead (red) to the power terminal of the existing aerial booster. For details, consult your dealer.

• A power aerial without a relay box cannot be used with this unit.

Memory hold connectionWhen the yellow power input lead is connected, power will always be supplied to the memory circuit even when the ignition switch is turned off.

Notes on speaker connection• Before connecting the speakers, turn the unit off.• Use speakers with an impedance of 4 to 8 ohms, and with

adequate power handling capacities to avoid its damage.• Do not connect the speaker terminals to the car chassis, or

connect the terminals of the right speakers with those of the left speaker.

• Do not connect the earth lead of this unit to the negative (–) terminal of the speaker.

• Do not attempt to connect the speakers in parallel.• Connect only passive speakers. Connecting active speakers

(with built-in amplifi ers) to the speaker terminals may damage the unit.

• To avoid a malfunction, do not use the built-in speaker leads installed in your car if the unit shares a common negative (–) lead for the right and left speakers.

• Do not connect the unit’s speaker leads to each other.

Note on connectionIf speaker and amplifi er are not connected correctly, “FAILURE” appears in the display. In this case, make sure the speaker and amplifi er are connected correctly.

Page 7: Sony Cdx r3350

7

CDX-R3350/R3350CSECTION 2

DISASSEMBLY

Note : This set can be disassemble according to the following sequence.

2-1. SUB PANEL ASSY(Page 8)

2-2. CD MECHANISM BLOCK(Page 8)

SET

2-3. MAIN BOARD(Page 9)

2-4. CHASSIS (T) SUB ASSY(Page 9)

2-5. ROLLER ARM ASSY(Page 10)

2-6. CHASSIS (OP) ASSY(Page 10)

2-8. SL MOTOR ASSY (M902)(Page 11)

2-10. SERVO BOARD(Page 12)

2-7. OPTICAL PICK-UP(Page 11)

2-9. LE MOTOR ASSY (M903)(Page 12)

Page 8: Sony Cdx r3350

8

CDX-R3350/R3350C

2-2. CD MECHANISM BLOCK

2 two claws

3 two claws

4 sub panel assy

1 two screws (+PTT 2.6 x 6)

7 bracket (CD)

5 CD mechanism block

4 CNP301

3

1 screw (+PTT 2.6 x 6)

2 screw (+PTT 2.6 x 6)

6 two screws (+PTT 2.6 x 4)

Note : Follow the disassembly procedure in the numerical order given.

2-1. SUB PANEL ASSY (CD)

Page 9: Sony Cdx r3350

9

CDX-R3350/R3350C

2-4. CHASSIS (T) SUB ASSY

2-3. MAIN BOARD

1 three screws (+BTT 2.6 x 5)

3 MAIN board

4 insulating sheet

2 two screws (+PTT 2.6 x 8)

5 SENSOR board

6 chassis (T) sub assy

4 claw

3 claw

1 two screws (+P 1.7 x 2.2)

2 two screws (+P 1.7 x 2.2)

Page 10: Sony Cdx r3350

10

CDX-R3350/R3350C

2-5. ROLLER ARM ASSY

2-6. CHASSIS (OP) ASSY

3 washer

4 gear (RA1)

5 roller arm assy

1 spring (RAL)

2 spring (RAR)

4 washer

0 coil spring (damper)

9 two coil springs (damper)

qa chassis (OP) assy

5 gear (LE1)

1 CN1 (16P)

lever (D)

slider (R)

6

7

8

2 Remove the six solderings.

3 tension coil spring (KF60)

Page 11: Sony Cdx r3350

11

CDX-R3350/R3350C

2-7. OPTICAL PICK-UP

2-8. SL MOTOR ASSY (M902)

1 tension coil spring (CHKG)

2 chucking arm sub assy

3 screw (+B 1.4 x 5)

4 rack (SL)

5 claw

6 main shaft

7 optical pick-up

1 screw (+P 1.4 x 1.8)

2 SL motor assy (M902)

Page 12: Sony Cdx r3350

12

CDX-R3350/R3350C

2-9. LE MOTOR ASSY (M903)

2-10. SERVO BOARD

2 washer

4

qd

3 gear (LE1)

7 leaf spring (LE)

5

lever (D)

bracket (LEM-N)

slider (R)

6 screw (+P 1.7 x 2.2)

8 screw (+M 1.7 x 2.5)

qa screw (+M 1.7 x 2.5)qf two toothed lock screws

(+M 1.4 )

qs screw (+M 1.7 x 2.5)

9 bearing (LEB-N)

0 gear (LE) assy

qg LE motor assy (M903)

1 Remove the soldering.

3 CN1 (16P)

5 claw

6 SERVO board

4 toothed lock screw (M 1.7)

1 Remove the eight solderings.

2 Remove the three solderings.

Page 13: Sony Cdx r3350

13 13

CDX-R3350/R3350C

CDX-R3350/R3350C

3-1. BLOCK DIAGRAM — CD SECTION —

79RFO

RF AMP,DIGITAL SERVO,DIGITAL SIGNAL PROCESSOR

IC2

87 RFEQO

3RFRP

6TEI

85 RFI86 RFRPI

1 RFZI

7 TEZI

9 F0O

PD1

PD2

E

F

I-V A

MP

PD LD

DETECTOR

77AGCI78RFDCI

94

96

95

97

99

98

TNI

FPI1

FNI1

FPI2

FNI2

TPI

91 LDO 92MDI

(FOCUS)

(TRACKING)

2-AXIS DEVICE

OPTICALPICK-UP BLOCK

(KSS1000E)

• Signal Path: CD PLAY

LASER DIODE

M

M

M

18

17

VO3–

VO3+

14

13

VO1+

VO1–

12

11 VO2–

VO2+

10

9

VOL+

VOL–FWD

REV

1

28

OPIN4– 26

OPOUT4 25

10 TROOPIN3– 23

46 IO0(/HSO)OPOUT3 22

12 FMOOPOUT1 4

13 DMOOPIN2 7

47 IO1(/UHSO)MUTE 21

16

15

VO4–

VO4+

M903(LOADING)

M901(SPINDLE)

M902(SLED)

FOCUS/TRACKING COIL DRIVE,SLED/SPINDLE/LOADING

MOTOR DRIVEIC1

56MUTE53REQ43STBY18ZDET42/RST41/CCE40BUCK39BUS3

CD-L MAIN SECTIONA30LO

27RO R-CH

27 DEC SSTBY15 CD ZDET14 CD XRST13 CD XCCE

53 MEC_SELFSW

45 MEC_INSW

42 MEC_LIMIT

12 CD BUCK11 CD BUS3

38BUS2 10 CD BUS237BUS1 8 CD BUS136BUS0 7 CD BUS014SBSY 52 CD SBSY

81 X1

80 X0

MEC LOAD43

MEC EJECT44

CDSYSTEM CONTROL

IC3

+1.5V REGIC6

SYSTEM CONTROLIC501 (1/3)

37 DEC XMUTE30 DEC INT

SW2(SELF)

46 MEC_DSWSW1(DOWN)

SW3(DISC IN)

SW4(LIMIT)

56UNISI25RXD57UNISO

58UNICKI50BUS ON51BU IN75RSTX

67MECON CHK

11.5V ON

63MECON64CDON66ZMUTE

60A ATT

26TXD

PD1

E

F

LD

MON OUT

FCS+

FCS–

TRK+

TRK–

PD2

AUTOMATICPOWER

CONTROLQ1

+1.5V ON/OFFSWITCH

Q2,3

• R-ch is omitted due to same as L-ch.

24

23X2

16.934MHzX1

12MHz

XI

XO

MAIN SECTIONB

UNI SI

UNI SO

ATT59LINK OFF LINK ON/OFF

UNI CLKBUS ONB/U CHECKSYS RST

CD ON

VOUT

98CDM ON99

CD MUTE R

MECHA+6V

9361EJECT OK EJECT OK SW89

68CDON CHK

15 VDD3CE

SERVO+3.3V

+1.5V

+1.5V

U COM+3.3V

(Page 14)

SECTION 3DIAGRAMS

(Page 14)

Page 14: Sony Cdx r3350

1414

CDX-R3350/R3350C

CDX-R3350/R3350C

1 ANT

7 TUNER LCH

ELECTRONIC VOLUMEIC401

J1(ANTENNA)

TU1(TUNER UNIT)

I2C BUS CONTROLLED POWER AMP/MULTIPLE VOLTAGE REGULATOR

IC750

SYSTEM CONTROLIC501 (2/3)

CN6016 TUNER RCH

BATT

9 CD LCH8 CD RCH

R-CH

43

10VCC11TU VDD15E2P VDD

13TU-SCL14TU-SDA

6S-METER7TU MUTE

16E2P SCL17E2P SDA

39 VSM

8MUTE CONDITION

9RDS

5QUALITY

53 TU ATT IN

38 QUALITY

13 NS MASK

56 DAVN

AUDIO+8.3VTUNER+5VBACKUP+3.3V

12 TU ATT

25 EEP CKO24 EEP SIO

TUNER LCHTUNER RCH

CD-L

R-CH

25OUT FR

R-CH24OUT RR

R-CH18OUT SUB R

17OUT SUB L

23OUT FL

R-CH

L

R

53

OUT FL+OUT FL–

97

OUT RL+OUT RL–

2927

AMP REM

R-CH

ANT REM

BATT

3037

REG1

35VP20VP16VP2

REG23133

REG3REG4

34REG5

TUNER+5V

29MUTE

2 SDA

AUDIO+8.3VBACKUP+5VSERVO+3.3VMECHA+6VPANEL+10V

4 SCL

SDASCL

16 BEEP22 STB25 DIAG

AUDIO+8.3V

15

13

7

10

12

11

16

19

2

4

3

56

3031

SCLSDA

SCLSDA

SCLSDA

SCLSDA

33I2C CKO34I2C SIO

9VOL ATT86ATT

5BEEP26AMPSTB8DIAG

54BU IN

73TEST IN

12 INFL FL+FL–

RL+RL–

FR+FR–RR+RR–

AMP-REMANT-REM

ACC

TEST

11 INRL22OUT RL

MUTEQ481

REARAUDIO OUT

MUTE CONTROLQ478,479

58UNI SI59UNI SO60UNI SCK87BUS ON88SYS RST

10 B/U-C8 DATA OUT9 DATA IN11 CLK IN12 BUSON13 RST

RESET

3

5

4

7

6

2

1

3BATT

6DATA I/O

4CLK

1BUS ON

2RST

72ACC IN ACCESSORY CHECKQ631

TU+5V REGQ1

BATT

BACKUP+3.3V BACKUP+5V

BATT

BU+3.3V REGIC681

BATT DETQ580

BUS INTERFACEIC580

MUTEQ4

ATT74TEL ATT TEL ATTENATION CHECKQ651

D479

FU601

R-CH

L

R

FRONTAUDIO OUT

R-CH53

BUS LCHBUS RCH

R-CH

R3350C

R3350C

L

R

BUSAUDIO INAUX IN

PJ330

BUSCONTROL IN

D511

D510(2/2)

D510

(1/2

)

D512

(1/2

)

D512(2/2)

D580,581

CD SECTION A

DISPLAY SECTIONCSYS RST

LINK OFFBUS ONUNI SCK

UNI SOUNI SI

ATTBU CHK

CD SECTION B

TH580

CN5808

BATT

RDS B+SWITCH

Q51

BUS ON SWITCHQ586,587

MUTEQ441

16 MPX

RDS DEMODULATORIC51

30 RDS ON

10 XTO

9 XTI

BACKUP+3.3V

RDS+3.3V

11SCL12SDA

SCLSDA

15INTNX51

8.664MHz

Q22

BATT DETQ581,582

R3350

R3350C

R3350C

R3350

• Signal Path• R-CH is omitted due to same as L-CH.

: CD PLAY

: FM

: BUS AUDIO

: MW/LW

3-2. BLOCK DIAGRAM — MAIN SECTION —

(Page 13)

(Page 15)

(Page 13)

Page 15: Sony Cdx r3350

15 15

CDX-R3350/R3350C

CDX-R3350/R3350C

3-3. BLOCK DIAGRAM — DISPLAY SECTION —

(Page 14)

S900-908,910-922

KEY ACKSWITCH

Q664

X50232.768kHz

79

80

82

83

41 28292740

52

76

7143

642

1

SYSTEM CONTROLIC501 (3/3)

LCD DRIVERIC901

KEYIN0 DATACLKCE

LCDSOLCDCKO

LCDCEKEYIN1

KEYACK

XKEYON

RCIN1RCIN0

SIRCSVCC

7712 RESET

70 RETRA SW

PANEL+10V

REMOTE CONTROLSIGNAL RECEIVER

IC971

RESETIC602

XIN

XOUT

OSCOUT

OSCIN

X50118.432MHz

6364

62

1

COM4

COM1

LCDLCD901

LED902-908,910-922,961

LED932LCD

BACK LIGHT

D501

J561(REMOTE IN)

51I

54

4I

50•

55

I

SEG4

SEG51I

DICLCE

DIMMER

R3350CR3350

BACKUP +3.3V

RESET

LEDILLUMINATION

( )

( )

KEY MATRIX

LEDDRIVEQ901

2AMBERLED

DRIVEQ902

3GREENLED

DRIVEQ903

S702RESET

S961(DOOR)

VDD VOUT

OUT

MAIN SECTION C

3-4. CIRCUIT BOARDS LOCATION

MAIN boardKEY board

SENSOR board

SERVO board

tuner unit(TU1)

Page 16: Sony Cdx r3350

1616

CDX-R3350/R3350C

CDX-R3350/R3350C

• WAVEFORMS

— MAIN BOARD —

— SERVO BOARD —(CD PLAY)

1 IC2 4 (FEI)

Approx.1Vp-p0 V

0.6 Vp-p

16.9344 MHz

Approx. 100 mVp-p

50 mV/DIV, 5 msec/DIV

0.5 V/DIV, 0.5 µsec/DIV

2 IC2 6 (TEI)

200 mV/DIV, 5 msec/DIV

6 IC2 oh (FPI2),

0.5 V/DIV, 0.5 µsec/DIV

Approx. 400 mVp-p

3 IC2 wd (XI)

0.2 V/DIV, 0.2 µsec/DIV

7 IC3 ia (X1)

0.5 V/DIV, 0.2 µsec/DIV

1.1 Vp-p

12 MHz

4 IC2 uj (RFI)

0.5 V/DIV, 0.5 µsec/DIV

5 IC2 of (FNI2),og (FNI1)

1.5 Vp-p

oj (FPI1)

1.5 Vp-p

0 V

1.1 Vp-p

8.664 MHz

1 IC51 9 (XTI)

0.5 V/DIV, 0.2 µsec/DIV

0.7 Vp-p

32.768 kHz

2 IC501 ul (X1)

0.2 V/DIV, 20 µsec/DIV

2 Vp-p

18.432 MHz

3 IC501 id (OSC IN)

1 V/DIV, 0.1 µsec/DIV

• NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS

THIS NOTE IS COMMON FOR PRINTED WIRINGBOARDS AND SCHEMATIC DIAGRAMS.(In addition to this, the necessary note is printedin each block.)

For schematic diagrams.Note:• All capacitors are in µF unless otherwise noted. (p: pF)

50 WV or less are not indicated except for electrolyticsand tantalums.

• All resistors are in Ω and 1/4 W or less unless otherwise

specified.• f : internal component.• C : panel designation.

For printed wiring boards.Note:• X : parts extracted from the component side.• Y : parts extracted from the conductor side.• a : Through hole.• : Pattern from the side which enables seeing.(The other layers' patterns are not indicated.)

• A : B+ Line.• B : B– Line.• H : adjustment for repair.• Voltages and waveforms are dc with respect to ground

under no-signal (detuned) conditions.• CD mechanism section (1/2), (2/2) no mark : CD PLAY• Main (1/3), (2/3), (3/3) and Display sections no mark : FM

( ) : MW/LW< > : CD PLAY

∗ : Impossible to measure• Voltages are taken with a VOM (Input impedance 10 MΩ).

Voltage variations may be noted due to normal produc-tion tolerances.

• Waveforms are taken with a oscilloscope.Voltage variations may be noted due to normal produc-tion tolerances.

• Circled numbers refer to waveforms.• Signal path.

J : CD PLAYF : FMf : MW/LWL : BUS AUDIO

Caution:Pattern face side: Parts on the pattern face side seen from the(Side B) pattern face are indicated.Parts face side: Parts on the parts face side seen from the(Side A) parts face are indicated.

Q

C

These are omitted

EB

EThese are omitted

CB

CThese are omitted

BE

Note: The components identified by mark 0 or dotted linewith mark 0 are critical for safety.Replace only with part number specified.

Page 17: Sony Cdx r3350

17 17

CDX-R3350/R3350C

CDX-R3350/R3350C

1

A

B

C

D

E

F

G

H

2 3 4 5 6 7 8 9 10 11 12 13 14

SW3

SW2

MAIN BOARD CNP301

TP24

TP40

TP17

TP14

TP18

TP37

TP38

TP39

TP30

FMA4

FMA6

FMA3

TP48

TP49TP51TP53

FMA5C37

C9

C38

C39C40C4

1

C43

C48

C67

C72

FB3

R132

R6

R7

R48

R50

R16

R17

R40

R41

R8

R25 R26

R84

R86R

131

R122Q

1

IC6

SW1(DOWN)

C106

R12

0

C65

C64

C19R

123

C20

C61

Q3

FB4

C29

C22

R65

C32

C51

C35

C45

C62

R11

R9

C57

R10

IC3

R12

FB2

C6

R11

2

R58

R42

R113

R43

R47

R54R

56R

57R

66

R68

R69

R70

R73 R100

R10

1

R13

R21

R71

Q2

C7

C101

C102

C80

C103

IC1

TP4

TP3

TP5

TP33

TP34

TP35TP

36

TP41

TP42

TP47

TP46

TP25

TP26TP27

TP21

TP22

TP68

TP93

TP15

TP64

FMB3

FMB4

TP11

TP86

TP87

TP10

TP1

TP6

TP7

TP8

TP9

TP12

TP13

TP16

TP20

TP32TP

31

TP66

TP67

TP74

TP75TP76

TP77

TP78

TP79TP80TP81

TP82

TP83

TP84

TP85

TP90

TP89

TP88

TP91

TP92

TP95

TP97TP98

TP99

TP2

TP63

TP44

TP43

TP65

TP62

FMB5

TP101

TP23

TP29

CN1

R4

R24

R5

CN2

R61

C5

R49

R51

R45

R46

R2

R3

X1

X1

IC2

R121

C10

C4

R11

9

C18

C47

C34

R11

8

C17

C23

C42

C16

C60

R125

C36

R62

R117

C21

R116

X2

C24

C31

C28

R12

6

C52

R12

7

C49

R128

C53

R63

R64

C13

R28

R1

C27

R53R55

R67

R60

R74

R77

R78

R80

R81

R82

R83

R90

R91

C33

R19

R22R23

R44

R52

R72R

59

C59

C105

C58

1-864-901-

11

11 1-864-901-

11

11

A

1-689-230-

3-5. PRINTED WIRING BOARDS — CD MECHANISM SECTION — • Refer to page 15 for Circuit Boards Location. : Uses unleaded solder.

(Page 20)

Ref. No. LocationIC1 G-2IC2 B-11IC3 D-2IC6 D-1

Q1 B-4Q2 C-1Q3 C-1

• SemiconductorLocation

Page 18: Sony Cdx r3350

1818

CDX-R3350/R3350C

CDX-R3350/R3350C

• Refer to page 16 for Waveforms.3-6. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (1/2) — • Refer to page 26 for IC Block Diagrams.

(Page 19)

IC B/D

IC B/D

CN1

R6 R7

TP34

Q2 R86

R84

TP41

TP36

TP27

TP26

TP46

TP30

TP47

R22

R71

R72

R64

R62

R63

R61

R60

R59

R26

R40

R44

C61

R25

R41

TP42

TP12

TP13

TP20

TP21 TP22

TP25

TP18

TP17

TP16

TP15

TP14

R125

R126

R127

R128

TP29

R23

R21

R24

TP93

TP101

R49

C58

C59R131

R113

C4

C5

C7

C27

C23

C20

C19

C17

C18

C21

C24

C28

C29

C35C32

C34

C33

C72C80

Q3

C102

C53

C51

C62

C49 C57

C48

C45

C42

FB2

FB3

C67

C60

R52

C52C47

C41

C40

C39

C38

C16

C13

C31

R19

R46R45

FB4

C101 R123TP

35

TP33

C36

R132

R5

R4

R51

R112

Q1

C9

TP37

TP38

TP39

TP40

IC6

C22

R13

IC2

R1

C10

X2

Page 19: Sony Cdx r3350

19 19

CDX-R3350/R3350C

CDX-R3350/R3350C

• Refer to page 16 for Waveform.• Refer to page 26 for IC Block Diagram.

3-7. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (2/2) — • Refer to page 29 for IC Pin Description.

(Page 23)

(Page 18)

IC B/D

R81R82

R83

R55 TP

62TP53

TP51

TP49

TP48

TP44

TP65TP64

TP63

R47

R73

R58

R48

R50

R54

R56

R66

R68

R69

R67

R65

R57

R53

R11

R10

R8

R9

R70

TP32TP31

TP1

TP2

TP3

TP4

TP5

TP10

TP11

TP43

TP67

TP66

TP23TP24

R11

6

R11

8R

119

R121

TP74

TP75TP76

TP77TP78

TP79TP80TP81

TP82TP83

TP84TP85

TP86TP87

TP88

TP89TP90

TP91TP92

TP97

TP98TP99

C43

C64

C65

C106

C37

R78

R77

R91

R90

R80

R117R122

R42 R43

R74

R17

R16

C6

R100

R101

IC1

CN2

R12

TP7

TP6

TP9

TP8

SW4

SW1

SW3

SW2

M903

M901

M902

R2

R3

R120 C103

IC3

C105

R28

X1

Page 20: Sony Cdx r3350

2020

CDX-R3350/R3350C

CDX-R3350/R3350C

3-8. PRINTED WIRING BOARD — MAIN SECTION — • Refer to page 15 for Circuit Boards Location. : Uses unleaded solder.

1

A

B

C

D

E

F

G

H

I

J

2 3 4 5 6 7 8 9 10 11 12 13 14

BUSAUDIO

IN

-1

L R

REAR

AUDIO OUT

L R

FRONT

L R

-2 -3 -4 -5 -6

J1(ANTENNA) J561

(REMOTE IN)CNP580

(BUS CONTROL IN)

KEY BOARD CN901B

S702RESET

1-865-675-

11

11

SERVOBOARD

CN2A

J330

11918

9 16

1 8

1723

4568 7

Q478

Q479

Q651

Q582

C502

R508

R509

R513

R514

C504

C508

C507

R510

R511

R512

Q664

R517

R528

C413

R405

R406

R407R409

R408

D1

C6

R2

R3

C2

C1Q22R29

R501

C501

R503

R58

2

D580

Q581

D583

R651

R653

R654

D651

R609

D609

R632R634

R633

Q631

R636

D582

Q58

0

R521

R522

C580

D584

R581

R580

R585

R584

D581

R58

3

R532

R531

R333

R33

1

R33

2R

330

JC75

3

C343

R674

R3350

R3350C

R3350C

R3350C

R3350C

R3350C

R3350C

R3350C

R3350C

R3350

R3350

R3350

R3350

R671

R672

R534

R756

C755

R752

C7

R479D479

C770

C769

R1

R536

R535

C404

C405

C756

Q1

R537

R453

R463

FMB3

FMB4

C11

C509R504

R505

R673

L1

R540

R541

IC40

1

C510

C512

C513

C514

C516

R544

C681

C682

JC502

C53

C54

C55 C56

C57

C58

C59

C60

C62

R51

R52

R53

R54

R55

R56

R57

R58

JC681

IC51

R548

R550

R471

R472

Q47

1

R481

R482

Q48

1

R461

R451

R552

C763

D719

R587

R588

R704

R553

R4

R5

R6

R7

R8

R9

R554

R555

R518

R557

R563

R564

R551R3350C

R3350C

R3350

C617

C618

C764C765

C751

C750

C331C330

C602

C12

C13

R59

JC401

Q51

R60

R61

R410

R411

R301

R302

C306

C308

C309

C310

C582

FB603

FB605

FB604

R652

C771

R573

FB1 FB309

FB305

FB30

3

FB307

FB308

JC527

Q586

Q5874

6

321

C484 C474

JC754

JC75

5

JC446

R533D512

IC602

D510

D511

R431 R433

Q43

1

R432

C434

R441

R443

Q44

1

R442

C444

FB56

1FB

562

FB563

FB302FB304

C312

D501

L51

R561

R565

R567

R529

R570

R59

0

JC501

JC503R569

R12

R13

C550

R591

D702D701

IC681

C519

R335

R502

JC445

Q46

1Q

451

R462

R452

IC58

0

JC1

FB310

R40

1

JC533

R601

D502R519

R506

R520

JC504

L301

C442

C432

C452

C462

C774C775C776

JC511

R574

R576

JC505

JC50

6

R566L501

R542

R543

R547

R578

JC75

6

D763

D764

R539

FB501

FB606

R675R676

R677

R678

R679

R681

D617

R705

IC501

C531

FMB6

JC5

JC12

JW10

JW11

JW12

JW13

JW29

JW31

JW32

JW33

JW36

JW37

JW64

JW90JW101

R63

1

JW10

4

JW10

5

C431

R3350C

R3350C

R3350C

R3350C

C461

C451

JW10

2C3

C401

CN701S702

C301

C302

TH580

C601

TU1

X51

C761

X502

C758

C752

C441

C581

D75

7

D75

9

D76

0

D60

1YE

L

C631

JW9

D75

8

C759

C754

D75

4

C407

C406

JW1

JW2

JW95

JW96

JW97

JW63

JW51

JW52

JW49 JW

47

C683

C305

JW91

JW115

JW129

JW130

JW43

JW72

JW94

JW57

C471

C481

JW13

1

JW13

2

JW110

D75

5

D75

6

JW27

C760

C753

C479

C412

C4C5

C51

C511

C503

JW59

D761

D762

JW61

JW77

JW78

C402

C403

JW3

JW25

JW109

JW144

YEL

JW14

5

JW14

6

L601

JW39

CNP301

JW14

2

JW14

3

CN580

R3350C

JW93

JW89

JW81

JW16

JW15

JW14

JW17

JW56

JW50

JW116

JW41

CN601

FU601

JW12

0

JW22

JW11

8

JW24

C622

R3350

R3350C

C623

JW18

JW128

JW65

JW82

JW75

JW119JW14

9

JW45

JW12

7

JW12

5

JW67

JW58

JW83

X501

JW6

JW8

JW13

7

JW7

JW79

JW30

JW99

JW28

JW117

JW62

JW100

JW92

JW14

1

JW66

JW111

JW106

JW113

JW134

JW20

JW14

0

JW73

JW74

JW13

3

JW121

JW80

JW122

JW60

JW15

0

JW44

JW48

JW88

JW12

6JW70

JW53

JW68

JW86

JW40

JW69

JW10

3

JW10

8

JW42 JW

23

JW5

D75

3

D75

2

D75

1

IC750

JW123

JW54

JW112

JW139

JW71

JW76

JW84

JW85

JW13

8

JW26

JW98

JW15

3

JW154

C562

(Page 24)

(Page 17)

Ref. No. LocationD1 F-3D479 E-6D501 I-5D502 I-7D510 H-8D511 F-6D512 I-8D580 F-11D581 F-11D582 F-11D583 E-11D584 F-11D601 C-10D609 D-9D617 C-9D651 C-9D701 I-3D702 I-3D719 J-4D751 D-7D752 D-7D753 D-7D754 D-7D755 C-6D756 C-6D757 C-6D758 C-6D759 D-8D760 D-8D761 D-9D762 D-9

• Semiconductor Location

D763 D-8D764 D-8

IC51 H-2IC401 E-4IC501 H-6IC580 H-10IC602 I-9IC681 E-7IC750 B-6

Q1 F-3Q22 E-3Q51 H-3Q431 C-4Q441 C-4Q451 C-4Q461 D-4Q471 C-3Q478 E-6Q479 E-5Q481 C-3Q580 F-11Q581 I-10Q582 I-10Q586 G-11Q587 G-11Q631 H-10Q651 D-9Q664 I-7

Ref. No. Location

Page 21: Sony Cdx r3350

21 21

CDX-R3350/R3350C

CDX-R3350/R3350C

• Refer to page 16 for Waveform.3-9. SCHEMATIC DIAGRAM — MAIN SECTION (1/3) — • Refer to page 26 for IC Block Diagrams.

(Page 23)

(Page 22)

IC B/DIC B/D

X51

C479

C3

L1C406

JC445

JC401

FB1

JC446

JC12

JC1

R55

R52

R51

R405

R406

R407R408

R409

C431

C451

C441

C461

R431

R451

R441

R461

R432

R452

R442

R462

R433

R453

R443

R463

D1

C5

R1

R410

R411

R54

C471

C481

R471

R481

R472

R482

R4

R7

R8 R9

R59

R60

R61

R12

R13

R335

R401

C11

C13

C12

C6

C58C57

L51

C53

C54

C55

C56

C60 C59

C62

C404

C405

Q481

Q471

Q461

Q441

Q451

C413

Q431

C484 C474

C432

C452

C442

C462

C7

R29C2C1

R6

C4 R5

C407

C401

C412

Q479

Q478

IC51

C51

TU1

Q1

J1

Q22

Q51

J330

JW102

JW77JW72JW126

JW79

JW85

JW84

IC401

R332

R333

R330

R331

C330 C331 C444 C434

C403

C402

R3

R2

R58

R56R57

R53

Page 22: Sony Cdx r3350

2222

CDX-R3350/R3350C

CDX-R3350/R3350C

3-10. SCHEMATIC DIAGRAM — MAIN SECTION (2/3) — • Refer to page 28 for IC Block Diagram.

(Page 21)

(Page 23)

IC B/D

L601

R633

R632R634

R654

R653 R652

R651

R609

JC756

D764

R479

C631

D751

D752

D753

D754

D755

D756

D757

D758

C753

D75

9

D76

0

R752C758

C759

C760

C761

C752

C754

JC754

C750

R631

JW52

C755

JC753

C763

C769

C770

C776

C751

C775 C765 C764 C774

C617

C618

C601C602 D601

C771

CN601

FU601

JC755

D763

D61

7

D65

1

D76

2

D76

1

D609

D479

Q651

Q631

IC750

JW53 JW98

C609

Page 23: Sony Cdx r3350

23 23

CDX-R3350/R3350C

CDX-R3350/R3350C

• Refer to page 16 for Waveforms.• Refer to page 27 for IC Block Diagram.

3-11. SCHEMATIC DIAGRAM — MAIN SECTION (3/3) — • Refer to page 31 for IC Pin Description.

(Page 25)

(Page 21) (Page 22)

(Page 19)

IC B/D

R636

R671

R67

2

R673

R512R

511

C302

R583

D719

R674

C623

R535R536

JC681

D510

D512

R53

4R

557

R55

1R

537

R57

3

R528

D511

R505

R504

R563

R54

4

R522R521

R565

JC527

C550

JC533

FB563FB562

R57

6

R57

4

R54

2

R54

7

R578

R705

C622

R585

R584

TH580

R301

R302

FB605

R508

R503R502

R552 R533

C503

C511

R531

R517

R501

R518

R54

1

R54

0

D70

2

R590

R519

R566

R539

R543

R675R676

R677R681

R601

D70

1

FB308

FB303

FB305

C306

FB310

C531

C510

C508 C507

C504

FB501

C513C516C501

JC501C509

C519

FB606

FB604

Q581

Q580D581

Q582

CN701

JC5

FB307

FB302

FB304

L301

CNP301

FB603

R564

R567

C512C502

C514

JC504

R561

R53

2

R510

R506

R756 R570

R51

3

R51

4

R679

R569

R529

R509JC505

C308

C310

C309

C305

FB309

C312

C301

C343

IC602

CN580

J561

Q664

JC506

IC501

X501

L501

R555R554

R553

D50

2

JC503

JW125

JW86

D501

R548R520

R550

C756

FB305

JC511

S702C681

IC681

C682C683

JW64

JW61 JW112 R704

FB561

JW58

IC580JW116

R678

JW41

JW134

R588

R587

R580 C582

JW36

JW37

JW43

C581

R591

D580 R582

Q587

Q586

D582

D584

JW47

JC502

C580

R581

X502

D583

C562

Page 24: Sony Cdx r3350

2424

CDX-R3350/R3350C

CDX-R3350/R3350C

3-12. PRINTED WIRING BOARD — DISPLAY SECTION — • Refer to page 15 for Circuit Boards Location. : Uses unleaded solder.

(Page 20)

1

A

B

C

D

E

F

G

H

2 3 4 5 6 7 8 9 10 11 12 13 14

LED922,S922 LED932(LCD BACK LIGHT)

LCD901LIQUID CRYSTAL DISPLAY PANEL

DSPLLED961

(DISC IN)LED910,S910

EQ3ATT

S901

S961(DOOR)

OPEN/EJECT 3 4 5 6LED916,S916 LED914,S914

MODELED907,S907

SELS920

1/GROUP–R3350:

1/GP/DISC–R3350C:

2/GROUP–R3350:

2/GP/DISC–R3350C:

PTYR3350:

PTY/LISTR3350C:

S921 LED9191

52 1

LED921 LED9182

LED920 LED917,S9173/REP 4/SHUF

S918SENS/BTM AF/TA

LED913

PTV

S913S915SENS

LED915OPEN/EJECT

S900

OFF

SEEK

LED902,S902

LED912,S912

LED911,S911

LED908,S908SOURCE

LED903,S903 S9191-865-677-

11

11

MAIN BOARD CN701

B1-865-677-

11

11

R913

S961

LED903 LED907 LED908 LED921 LED920 LED919 LED918 LED917 LED916 LED915 LED914 LED913

LED904

LED922 LED910

LED

912

LED906 LED

911

LED905 LED902

R912

LED961R928

R3350C

LED

932

LED

931

S902

R3350C

S911

S912

S900S913S914S915S916S917S918S919S920S921S908S907S903

S901

S904

S905

LED905,S905

LED906,S906

LED904,S904

S906

S922 S910

IC971IC971

C903

C904C905

(VOLUME)

C906

R3350C

FMB3

C991

CN901

IC901

D902

D901

C971

R906

R996R995R994

R98

9

C992

C993C995

R901

R903

R902

R907

R91

1

R915R916R917R918

R919

R920

R921

R905R904

R991

R97

1

R972

R98

2

R98

1

R983

R984

R993

R98

7

R98

8

D99

1

R922

D992

R978

R931

R932R93

3

R93

4

Q90

1

R914

R937

R938

R3350

R3350C

R936R935

R3350C

R3350C

R3350CR3350C

R3350C

Q90

2Q

903

R925R924

R941

R942

R943

R926

R953

R961

R962

R92

7

R97

6 R92

9

R930

1

4

2

3

Ref. No. LocationD901 G-11D902 F-11D991 G-6D992 G-9

IC901 G-8IC971 D-14

LED902 A-14

• Semiconductor Location

LED903 D-3LED904 D-2LED905 A-1LED906 B-2LED907 D-4LED908 D-5LED910 C-12LED911 B-14LED912 C-13

LED913 D-12LED914 D-11LED915 D-10LED916 D-10LED917 D-9LED918 D-8LED919 D-7LED920 D-6LED921 D-6

LED922 C-3LED932 C-4LED961 B-7

Q901 G-4Q902 F-3Q903 F-3

Ref. No. Location Ref. No. Location Ref. No. Location

Page 25: Sony Cdx r3350

25 25

CDX-R3350/R3350C

CDX-R3350/R3350C

3-13. SCHEMATIC DIAGRAM — DISPLAY SECTION —

(Page 23)

CN901

S961

R976

D902

D901

R943

R924

R961

R901

R902

R903

R994

R995

R996R993

R989

R988

R987

R972

R978

R971

R981

R982

R983

R904

R905

R906

R907

R911

R912

R925

R926

R927

R984

R913

R914

R915

R916

R917

R918

R919

R920

R921

R922

C903

C905

C991

C995

C992

C993

IC971

C971

IC901

S900

S901

S902

S903

S904

S905

S906

S907

S908

S922

S921

S920

S919

S918

S917

S916

S915

S914

S913

S912

S911

S910

R929R931 R933 R935

R937

LED961

D991

D992

R991

R962

LED910

LED912

LED911

LED902 LED916

LED915

LED914

LED913

LED920

LED919

LED903

LED907

LED905

LED906

LED918 LED908 LED904

LED922LED921LED917

Q901

LCD901

R930

C904R932 R934

R936 R938

C906

R928

R941

R942

LED931

R953

Q902Q903

LED932

Page 26: Sony Cdx r3350

2626

CDX-R3350/R3350C

CDX-R3350/R3350C

IC2 TC94A60MFG-301 (SERVO Board (1/2))

• IC BLOCK DIAGRAMS

IC6 R1114N151D-TR-FA (SERVO Board (1/2))

76

77 EFM SLICE

79

78

82

83

84

88

RFRP

VCOSLCO

RFI

RFRPI

REFQO

RESIN

VRO

VMDIR

TESTR

INVSEL

AGCI

RFDCI

RFO

PNSEL

EQSET

RVDD3

LDO

MDI

RVSS3

FNI2FNI1FPI2FPI1

TPI

TNI

FTE

RFZI

AVSS

3

RFRP FE

ISB

AD/R

FDC

TEI

TEZI

AVDD

3

FOO

TRO

VREF

FMO

DMO

SBSY

SBOK IP

F

SFSY

GPIN

VDD1

5

ZDET

VSS1

5XV

SS3 XI XO

XVDD

3

PVSS

3

VCOR

EF

VCOF

PVRE

FLP

FO

LPFN

TMAX

PDO

PVDD

3

AWRC

VSS1

5VD

D15

LRCK

IBC

KIAI

N

LRCK

OBC

KO

DOUT

PIO3

AOUT

PIO2

PIO1

PIO0

TEST

C

VDDP

VCOIVSSPTESTD

IO1IO0

FGIN

VDDT

STBY

/RST

/CCEBUCKBUS3BUS2BUS1BUS0VSS15

VDDMVDD3VSS3DVSS3

LO

DVR

DVDD3

RO

DVSS3

AUDIOOUT

DIGITALOUT

PLLTMAX

RFEQ

85 AGC

86 RFDC

87 RF

RAMDIGITAL EQAUTO ADJ. ROM

91APC

92

94

FE95

98TE

99

100

21 3 54 6 7 8 9 10 11 12 13 20 21 2214 15 16 17 1918

9697

80VRO

81

89

90

93

23

ANA.LPF

24 25

SYNC SIGNAL PROTECTIONEFM DEMODULATION

69 68 63 62 61 56 55 54 53

50

45

44

43

41403938373635

34333231

30

29

28

27

26

42

4948

4647

60 59 58 57 52 5166 65 6467707475 73

1-BITDAC

CLOCKGEN.PWM

SUBCODEDEMODULATION

CIRCUIT

16KRAM

ADDRESS CIRCUITCPUI/F

CORR

RECT

ION

CIR

CUIT

5-BITR-2R DAC

SERVOCONTROL

10-BITSAR ADC

72 71

CLV SERVO CAV SERVO

AWRC

1

VREF

VDD

GND

CE

CURRENTLIMIT

2

3

5 VOUT

NC4

IC1 BA5968FP-E2 (SERVO Board (2/2))

1

2

11

13

14

12

LEVELSHIFT

LEVELSHIFT

LEVELSHIFT

LEVELSHIFT

MUTE

FWD

FWD

LDCTL

NC

OPOUT1

NC

NC

OPOUT2

POWVCC VCCVOL–

VOL+

VOL2–

VOL2+

VO1–

VO1+

REV

OPIN4+

OPIN4–

OPOUT4

OPIN3+

OPIN3–

OPOUT3

MUTEVOL+GND

VOL3–

VOL3+

VOL4–

VOL4+

REV

OUTR OUTF

10

98

7

6

5

28

27

26

25

24

23

22

212019

18

17

16

15

4

3

IC51 TDA7333013TR (MAIN Board (1/3))

VDDA

INTERPOLATOR

RAMBUFFER

&CONTROL

LOGIC

TEST LOGIC&

PIN MUX'S

I2C/SPI

INTERFACE

BAND PASSFILTER

SIGMA DELTACONVERTER

SINC4FILTER

REF3

REF2

REF1

VSS

VDDD

RESETN

TM

1

MPX16

CSNSDAOUT

RDSREG

3

INTN

MPX

SINC

4REG

SDAINSCKSPITESTREG

14

2

3

4

5

6

7

8

INTN15

SA_DATAOUT13SDA_DATAIN12SCL_CLK11

OSCILLATOR

XTO10

XTI9

RDSDEMODULATOR &

SYNCHRONIZATION

2

Page 27: Sony Cdx r3350

27

CDX-R3350/R3350C

IC580 BA8271F-E2 (MAIN Board (3/3))

1

2

3

456

7 8

9

10

14

131211

BUS ONSWITCH

RESETSWITCH

BATTERYSWITCH

BUS ON

RST

BATT

CLKVREF

GND

VCC

RESETBUS ONCLK INBU IN

DATA IN

DATA OUT

DATA

IC401 BD3806FS-FE2 (MAIN Board (1/3))

32 31 30 29 28 27 26 25 24 23 22

I2C BUSLOGIC

VCO

MIX

FADER(0~-58,-∞dB)

FADER(0~-58,-∞dB)

FADER(0~-58,-∞dB)

FADER(0~-58,-∞dB)

VOLUME(+23~-79dB,-∞dB

1dB STEP)

VOLUME(+23~-79dB,-∞dB

1dB STEP)

INPUT GAIN(0~15dB,1dB STEP)

INPUT SELECTOR(4 STEREO INCLUDE 1 ISOLATION INPUT)

INPUT GAIN(0~15dB,1dB STEP)

ANTI-ALIASINGFILTER

ANTI-ALIASINGFILTER

MUTE

fc:40kHz fc:40kHz

MUTE

6 7 8 9 10 113 4 521

DGND

AGND FI

L

AN AP2

AP1 B1 B2 C1 C2 D1 D2

DS11

DS21

DS31 NC NC

12 14 1613 15

SDA

SCL

MUT

E

SEL

ADJ

VCC

OUTF

1

OUTR

1

OUTF

2

OUTR

2

DS12

DS22

DS32

OUTS

1

OUTS

2

21 20 19 18 17

VCC

VCC/2

TONEPASS

BASSfo:60,70,80,100,120,140,160,200HzQ:0.5,0.75,1,1.25

MIDDLEfo:500Hz,1kHzQ:1

TABLEfo:5,7.5,10,12.5kHz

TONEPASS

EFFECT (0dB~+20dB,2dB STEP)

EFFECT (0dB~+20dB,2dB STEP) 2ND ORDER

LPF

2ND ORDER LPFfc:OFF,80,120,160HzQ: 0.707

BASS,TREBLE, MIDDLE(-15dB~+15dB,1dB STEP)

BASS,TREBLE, MIDDLE(-15dB~+15dB,1dB STEP)

GAIN+ATT(+10~-29,

-∞dB)

Page 28: Sony Cdx r3350

28

CDX-R3350/R3350C

IC750 TDA8588AJ/N2/R1 (MAIN Board (2/3)) (R3350C)IC750 TDA8588BJ/N2/R1 (MAIN Board (2/3)) (R3350)

MUT

EM

UTE

ENABLELOGIC

STANDBYMUTE

CHIP DETECTDIAGNOSTIC

PROTECTIONDIAGNOSTIC

SWITCH

REGU

LATO

R

SWITCH

REFERENCEVOLTAGE

LOADDUMPPROTECTION

TEMPERATUREPROTECTION

BACK-UPSWITCHREGULATOR

1

3

5

7

9

11

13

15

17

19

21

23

25

27

29

31

33

35

37

2

4

6

8

10

12

14

16

18

20

22

24

26

28

30

32

34

36

TAB

OUT FL-

OUT FL+

OUT RL-

OUT RL+

INRL

SGND

INRR

OUT RR+

OUT RR-

OUT FR+

OUT FR-

DIAG

SW2(ANT REM)

SW1(ANT REM)

REG3(SERVO)

REG4(DR+B)

VP(REG)

REG2(BU 5V)

SDA

SCL

VP2

PGND3

SVR

INFL

INFR

AC GND

PGND2

VP1

STB

PGND1

RST

CRES

REG1(AUDIO +B)

GND(REG)

REG5(ILL)

CBU

FL

RL

RR

VP

FR

I2C BUS

Page 29: Sony Cdx r3350

29

CDX-R3350/R3350C

• IC PIN DESCRIPTIONS• IC3 MB90487APFV-G-142-BNDE1 (CD SYSTEM CONTROL) (SERVO BOARD (2/2))

Pin No. Pin Name I/O Pin Description

1 NC O Servo 1.5 V power supply control signal output

2 to 6 NC — Not used. (Open)

7 CD BUS0 I/O Bus data signal input/output 0

8 CD BUS1 I/O Bus data signal input/output 1

9 VSS — Ground pin

10 CD BUS2 I/O Bus data signal input/output 2

11 CD BUS3 I/O Bus data signal input/output 3

12 CD BUCK O Bus clock signal output

13 CD XCCE O Chip enable signal output

14 CD XRST O Reset signal output

15 CD ZDET I Zero detection signal input

16 to 20 NC — Not used. (Open)

21 VCC — Power supply pin (+3.3 V)

22 DAC ZDETL I Zero data detection signal input (L-ch)

23 DAC ZDETR I Zero data detection signal input (R-ch)

24 NC — Not used. (Open)

25 RXD I UART RXD data signal input (MCBUS/Flash data input)

26 TXD O UART TXD data signal output (MCBUS/Flash data output)

27 DEC SSTBY O SRAM STANDBY mode control signal output

28, 29 NC — Not used. (Open)

30 DEC INT I Request signal input

31, 32 NC — Not used. (Open)

33 AVCC — Power supply pin (+3.3 V) for A/D converter

34 AVRH — External reference voltage for A/D converter

35 AVSS — Ground pin

36 NC — Not used. (Open)

37 DEC XMUTE O Mute signal output L: mute

38, 39 NC — Not used. (Open)

40 VSS — Ground pin

41 NC — Not used. (Open)

42 MEC LIMIT I Sled limit in detection switch signal input

43 MEC LOAD O Loading motor signal output (Load direction)

44 MEC EJECT O Loading motor signal output (Eject direction)

45 MEC INSW I Pack-in detection signal input

46 MEC DSW I Chucking end detection switch signal input

47, 48 MD0, MD1 I CPU operation mode designation signal input (Connect to Vcc.)

49 MD2 I CPU operation mode designation signal input (Connect to Vss.)

50 BUS ON I Bus on signal input L: bus on

51 BU IN I Backup on/off signal input H: backup on, L: backup off

52 CD SBSY I SUBQ sync signal input L: interruption

53 MEC SELFSW I Disc insert detection switch signal input L: disc in interruption

54, 55 NC — Not used. (Open)

56 UNISI I Serial data signal input

57 UNISO O Serial data signal output

58 UNICKI I Serial clock signal input

59 LINEOFF O Line off signal output

60 A ATT O Audio attenuation signal output H: ATT on

61 EJECT OK I Front panel open signal input H: eject

62 OPEN REQ O Front panel open/close request signal output H: open request

63 MECON O Mechanism deck power supply control signal output

64 CDON O Servo power supply control signal output

Page 30: Sony Cdx r3350

30

CDX-R3350/R3350C

Pin No. Pin Name I/O Pin Description

65 XUART I Sony-Bus/MC-Bus change signal input H: Sony-Bus, L: MC-Bus

66 ZMUTE O Zero detection mute signal output

67 MECON CHK I MECON rising detection signal input

68 CDON CHK I CDON rising detection signal input

69 to 74 NC — Not used. (Open)

75 RSTX I System reset signal input

76 NC — Not used. (Open)

77 X1A — Sub-clock connect pin Not used in this set. (Open)

78 X0A — Sub-clock connect pin Not used in this set. (Connect to Vss.)

79 VSS — Ground pin

80 X0 I Main-clock connect pin (12 MHz)

81 X1 O Main-clock connect pin (12 MHz)

82 VCC — Power supply pin (+3.3 V)

83 XTS I Not used in this set. (Open)

84 XINIT3 I Not used in this set. (Open)

85 NC — Not used. (Open)

86 XSJIG I Not used in this set. (Open)

87 to 89 XINIT0 to 2 I Not used in this set. (Open)

90 to 97 NC — Not used. (Open)

98 XLINE I Not used in this set. (Open)

99, 100 NC — Not used. (Open)

Page 31: Sony Cdx r3350

31

CDX-R3350/R3350C

• IC501 MB90488BPF-G-122-BNDE1 (SYSTEM CONTROL) (MAIN BOARD (3/3))Pin No. Pin Name I/O Pin Description

1 AREASEL2 I Destination function setting signal input 2

2 AREASEL1 I Destination function setting signal input 1

3 AREASEL0 I Destination function setting signal input 0

4 COL SW I LED color switch signal input

5 BEEP O Beep signal output

6 LIST SEL I List select signal input

7 NOSE SW I Front panel attachment detection signal input “L”: with panel

8 DIAG I Condition signal input from power amplifier

9 VOLATT O Electronic volume attenation control signal output

10 NCO O Not used. (Open)

11 VSS — Ground pin

12 TUATT O Tuner mute control signal output

13 NSMASK O Noise mask signal output

14 ILLUMI SEL1 I Illumination voltage setting signal input 1

15 ILLUMI SEL2 I Illumination voltage setting signal input 2

16 NCO O Not used. (Open)

17 AUXIN O AUX light change signal output “L”: AUX, “H”: BUS IN

18 CD SI O Not used in this set. (Open)

19 CD SO O Not used in this set. (Open)

20 CD SCK O Not used in this set. (Open)

21, 22 NCO O Not used. (Open)

23 VCC5 — Power supply pin

24 EEP SIO I/O Serial data input/output for EEPROM communication

25 EEP CKO O Serial clock output for EEPROM communication

26 AMPSTB O Standby signal output to power amplifier

27 LCD CE O Chip enable signal output to LCD driver

28 LCD SO O Serial data signal output to LCD driver

29 LCD CKO O Serial clock signal output to LCD driver

30 RDS ON O RDS on signal output Tuner on: “L”

31, 32 NCO O Not used. (Open)

33 I2C CKO O I2C BUS serial clock signal output

34 I2C SIO I/O I2C BUS serial data signal input/output

35 DAVDD — A/D converter power supply pin

36 AVRH — A/D converter reference power supply pin

37 DAVSS — A/D converter ground pin

38 QUALITY I Noise detection signal input

39 VSM I S-meter voltage detection signal input

40 KEYIN1 I Key signal input 1

41 KEYIN0 I Key signal input 0

42 VSS — Ground pin

43 RC IN0 I Rotary commander key signal input 0

44 to 48 NCO O Not used. (Open)

49, 50 MD0, MD1 I Operation mode designation signal input Fixed at “H” in this set.

51 MD2 I Operation mode designation signal input Fixed at “L” in this set.

52 KEYACK I Key acknowledge detection signal input

53 TU ATTIN I Tuner mute zero cross detection signal input

54 BUIN I Backup power supply detection signal input

55 CD INTQ O Not used in this set. (Open)

56 DAVN I RDS data block synchronization detection signal input

57 NCO O Not used. (Open)

58 UNISI I SONY BUS data signal input

59 UNISO O SONY BUS data signal output

Page 32: Sony Cdx r3350

32

CDX-R3350/R3350C

Pin No. Pin Name I/O Pin Description

60 UNISCK O SONY BUS clock signal output

61 to 63 NCO O Not used. (Open)

64 SIRCS I Remote control signal (infrared rays) input

65 to 67 NCO O Not used. (Open)

68 FLASH W IMemory mode change signal input

Normally “H” input: Single chip mode, “L” after reset: Flash white mode

69 NCO O Not used. (Open)

70 RETRA SW IRETRA CD door open/close detection switch signal input

“H”: CD door close, “L”: CD door open

71 RC IN1 I Rotary commander shift key signal input

72 ACC IN I Acssesory power supply detection signal input

73 TESTIN I Test mode detection signal input

74 TELATT I Telephone attenate detection signal input

75 NCO O Not used. (Open)

76 XKEYON O A/D converter power supply control signal output

77 RESET I Reset signal input

78 NCO O Not used. (Open)

79 XIN I Low speed operation clock signal input (32.768 kHz)

80 XOUT O Low speed operation clock signal output (32.768 kHz)

81 VSS1 — Ground pin

82 OSCOUT O High speed operation clock signal output (18.432 MHz)

83 OSCIN I High speed operation clock signal input (18.432 MHz)

84 VCC3 — Power supply pin

85 DEMOSEL I DEMO select signal input “H”: DEMO on, “L”: DEMO off

86 ATT O Audio mute control signal output

87 BUSON O Bus on signal output

88 SYSRST O System reset signal output

89 EJEECT OK SW O Eject OK signal output

90 CD RST O Not used in this set. (Open)

91 CD A0 O Not used in this set. (Open)

92 CD STB O Not used in this set. (Open)

93 CD MUTE R I Z-mute signal input

94 CD MUTE L O Not used in this set. (Open)

95 CD INSW O Not used in this set. (Open)

96 CD SELFSW O Not used in this set. (Open)

97 CD LM LO O Not used in this set. (Open)

98 CD ON I CD mechanism servo power supply control request signal input

99 CDM ON I CD mechanism deck power supply control request signal input

100 CD LIMIT O Not used in this set. (Open)

Page 33: Sony Cdx r3350

33

CDX-R3350/R3350CSECTION 4

EXPLODED VIEWS

Ref. No. Part No. Description Remark

4-1. MAIN SECTION

Ref. No. Part No. Description Remark

The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.

NOTE:• The mechanical parts with no reference

number in the exploded views are not supplied.• Items marked “*” are not stocked since

they are seldom required for routine service.Some delay should be anticipatedwhen ordering these items.

• -XX and -X mean standardized parts, sothey may have some difference from theoriginal one.

• Color Indication of Appearance PartsExample :

KNOB, BALANCE (WHITE) ... (RED)

Parts Color Cabinet’s Color• Accessories are given in the last of this

parts list.

R R

1 X-2024-491-1 PANEL ASSY, SUB2 3-042-244-11 SCREW (T)3 X-3383-739-1 LOCK ASSY (S)4 2-050-124-01 SCREW +BTT 2.6X5 (R3350C)4 3-376-464-11 SCREW (+PTT 2.6X6), GROUND POINT (R3350)

5 A-1086-104-A MAIN BOARD, COMPLETE (R3350)5 A-1086-106-A MAIN BOARD, COMPLETE (R3350C)

6 2-021-848-01 SHEET (TU), GROUND7 1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER)FU601 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10ATU1 A-3220-961-A TUNER UNIT (TUX-032)#1 7-685-792-09 SCREW +PTT 2.6X6 (S)

#2 7-685-790-01 SCREW +PTT 2.6X4 (S)#3 7-685-793-09 SCREW +PTT 2.6X8 (S)

FU601

not supplied

not supplied

not supplied

TU1

not supplied

#1

#1

#1

#2

#3

#1

MG-611TA-186//Q

A

A

B

B

1

2

3

4

7

5

6

Page 34: Sony Cdx r3350

34

CDX-R3350/R3350C

4-2. FRONT PANEL SECTION

Ref. No. Part No. Description RemarkRef. No. Part No. Description Remark

51 X-2050-730-1 PANEL ASSY, FRONT (SV) (R3350)51 X-2050-755-1 PANEL ASSY, FRONT (SV) (R3350C)52 3-258-947-02 FILTER (IR)53 1-780-096-11 CONDUCTIVE BOARD, CONNECTION54 X-2024-966-1 SHUTTER (SV) ASSY (R3350C)

54 X-2024-968-1 SHUTTER (SV) ASSY (R3350)55 X-2050-729-1 BUTTON ASSY (SV) (R3350)55 X-2050-754-1 BUTTON ASSY (SV) (R3350C)56 3-246-479-01 SPRING (RELEASE)57 2-515-402-11 SHEET (ILLUMINATOR)

58 2-188-139-01 PLATE (CD), LIGHT GUIDE59 2-179-623-01 PANEL, FRONT BACK60 X-3385-071-1 CASE ASSY (for FRONT PANEL)

61 A-1085-114-A PANEL OVERALL ASSY, FRONT (R3350)61 A-1086-186-A PANEL OVERALL ASSY, FRONT (R3350C)62 3-250-543-21 SCREW (+B P-TITE M2)63 3-258-960-01 SPRING (R), TORSION64 3-258-956-01 GEAR (SYNCHRONIZE)

65 3-258-958-01 SPRING (R), LEAF66 3-258-961-01 SPRING (L), TORSION67 3-258-959-01 SPRING (L), LEAF68 3-258-957-01 SHAFT (DRIVE)69 2-318-504-01 PANEL (SLOT), FRONT

LCD901 1-805-733-11 DISPLAY PANEL, LIQUID CRYSTAL#6 7-685-104-19 SCREW +P 2X6 TYPE2 NON-SLIT#7 7-624-104-04 STOP RING 2.0, TYPE -E

LCD901

not supplied

not supplied

not supplied

not supplied

#6

#6

#7

not supplied

not supplied

not supplied

not supplied(KEY board)

not supplied

51

52

54

5655

53

57

58 59

6061

69

6364

64

65

68

66 67

62

62

Page 35: Sony Cdx r3350

35

CDX-R3350/R3350C

4-3. CD MECHANISM SECTION (1)(MG-611TA-186//Q)

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

101 A-3372-444-A CHASSIS (T) SUB ASSY102 3-253-729-11 SPRING (LTR), TENSION COIL103 3-257-892-12 SPRING (DAMPER), COIL104 3-257-892-01 SPRING (DAMPER), COIL105 2-345-767-11 SPRING (KF60), TENSION

106 3-259-033-01 DAMPER (S)

107 3-352-758-31 SCREW (M1.7), TOOTHED LOCK108 A-1082-772-A SERVO BOARD, COMPLETE109 X-3384-088-2 LEVER (L) ASSY110 X-3384-089-2 LEVER (R) ASSY#4 7-627-552-87 SCREW, PRECISION +P 1.7X2.2

not supplied(SENSOR board)

not supplied

not supplied

#4

101102

109

110

103

104

105

106

107

108

Page 36: Sony Cdx r3350

36

CDX-R3350/R3350C

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

4-4. CD MECHANISM SECTION (2)(MG-611TA-186//Q)

151 A-1075-644-A CHASSIS (OP) COMPLETE ASSY152 3-316-938-91 SCREW (B1.4X5), TAPPING

0153 8-820-207-12 OPTICAL PICK-UP (KSS1000E/K1RP)154 A-1075-645-A CHASSIS (OP) SUB ASSY (including M901)155 A-3372-449-A ARM SUB ASSY, CHUCKING

156 A-3372-446-A LEVER (SL) SUB ASSY157 X-3384-090-2 LEVER (SL) ASSYM902 A-3372-447-A MOTOR ASSY, SL (SLED)SW4 1-571-099-11 SWITCH (1 KEY) (LIMIT)#5 7-627-850-77 SCREW, PRECISION +P 1.4X1.8

not supplied

SW4

not supplied

not suppliednot supplied

not supplied

#5

M902

151152

153

154(including M901)

155

156

157

The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.

Page 37: Sony Cdx r3350

37

CDX-R3350/R3350C

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

4-5. CD MECHANISM SECTION (3)(MG-611TA-186//Q)

201 3-348-993-01 WASHER202 2-186-699-01 GEAR (RA1)203 A-1075-641-A ARM ASSY, ROLLER204 3-259-455-12 SPRING (RAL)205 3-253-713-11 SPRING (RAR)

206 3-259-469-12 SPRING (LE), LEAF207 2-134-636-21 SCREW (M1.7X2.5)

208 2-186-696-01 BRACKET (LEM-N)209 3-345-648-91 SCREW (M1.4), TOOTHED LOCK210 A-1083-636-A GEAR (LE) ASSY211 2-186-697-01 BEARING (LEB-N)M903 A-1075-643-A MOTOR ASSY, LE (LOADING)

#4 7-627-552-87 SCREW, PRECISION +P 1.7X2.2

#4

M903

208 210

211

209

207

207

207

201202

203

204

205

206

Page 38: Sony Cdx r3350

38

CDX-R3350/R3350C

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

4-6. CD MECHANISM SECTION (4)(MG-611TA-186//Q)

251 2-186-700-01 GEAR (CHK1)252 3-344-223-01 WASHER253 3-259-470-11 GEAR (LE1)254 3-253-755-12 LEVER (D)

255 3-899-829-01 WASHER (SLIT)256 3-259-032-01 GEAR (LE2)257 A-1075-640-A CHASSIS (M) BLOCK ASSY

251

252

252254

255

256

257

253

Page 39: Sony Cdx r3350

39

CDX-R3350/R3350CSECTION 5

ELECTRICAL PARTS LIST

NOTE:• Due to standardization, replacements in

the parts list may be different from theparts specified in the diagrams or thecomponents used on the set.

• -XX and -X mean standardized parts, sothey may have some difference from theoriginal one.

• RESISTORSAll resistors are in ohms.METAL:Metal-film resistor.METAL OXIDE: Metal oxide-film resistor.F:nonflammable

• Items marked “*” are not stocked sincethey are seldom required for routine service.Some delay should be anticipatedwhen ordering these items.

• SEMICONDUCTORSIn each case, u : µ, for example:uA.. : µA.. uPA.. : µPA..uPB.. : µPB.. uPC..: µPC.. uPD.. : µPD..

• CAPACITORSuF : µF

• COILSuH : µH

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.

When indicating parts by referencenumber, please include the board.

KEY BOARD**********

1-780-096-11 CONDUCTIVE BOARD, CONNECTION2-515-402-11 SHEET (ILLUMINATOR)

< CAPACITOR >

C903 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC904 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

(R3350C)C905 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC906 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

(R3350C)C971 1-135-834-11 CERAMIC CHIP 2.2uF 6.3V

C991 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC992 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC993 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC995 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3V

< CONNECTOR >

CN901 1-794-312-11 PIN, CONNECTOR 12P

< DIODE >

D901 6-500-886-01 DIODE RSA6.1ENTRD902 8-719-056-93 DIODE UDZ-TE-17-18BD991 8-719-976-99 DIODE DTZ5.1BD992 8-719-081-97 DIODE MMDL914T1

< IC >

IC901 6-707-063-01 IC LC75826WH-US-EIC971 6-600-163-01 IC RS-770 (IR)

< LIQUID CRYSTAL DISPLAY >

LCD901 1-805-733-11 DISPLAY PANEL, LIQUID CRYSTAL

< DIODE >

LED902 6-500-450-01 LED CL-195SR-CD-T (OFF) (R3350)LED902 6-500-509-01 LED CL-165D/PG-D-T (OFF) (R3350C)LED903 6-500-450-01 LED CL-195SR-CD-T (SOURCE) (R3350)LED903 6-500-509-01 LED CL-165D/PG-D-T (SOURCE) (R3350C)LED904 6-500-450-01 LED CL-195SR-CD-T (VOLUME –) (R3350)

LED904 6-500-509-01 LED CL-165D/PG-D-T (VOLUME –) (R3350C)LED905 6-500-450-01 LED CL-195SR-CD-T (ATT) (R3350)LED905 6-500-509-01 LED CL-165D/PG-D-T (ATT) (R3350C)LED906 6-500-450-01 LED CL-195SR-CD-T (VOLUME +) (R3350)

LED906 6-500-509-01 LED CL-165D/PG-D-T (VOLUME +) (R3350C)LED907 6-500-450-01 LED CL-195SR-CD-T (MODE) (R3350)LED907 6-500-509-01 LED CL-165D/PG-D-T (MODE) (R3350C)LED908 6-500-450-01 LED CL-195SR-CD-T (SEL) (R3350)LED908 6-500-509-01 LED CL-165D/PG-D-T (SEL) (R3350C)

LED910 6-500-450-01 LED CL-195SR-CD-T (EQ3) (R3350)LED910 6-500-509-01 LED CL-165D/PG-D-T (EQ3) (R3350C)LED911 6-500-450-01 LED CL-195SR-CD-T (SEEK > M +)

(R3350)LED911 6-500-509-01 LED CL-165D/PG-D-T (SEEK > M +)

(R3350C)LED912 6-500-450-01 LED CL-195SR-CD-T (SEEK – m .)

(R3350)

LED912 6-500-509-01 LED CL-165D/PG-D-T (SEEK – m .)(R3350C)

LED913 6-500-450-01 LED CL-195SR-CD-T (PTY) (R3350)LED913 6-500-509-01 LED CL-165D/PG-D-T (PTY/LIST) (R3350C)LED914 6-500-450-01 LED CL-195SR-CD-T (AF/TA) (R3350)LED914 6-500-509-01 LED CL-165D/PG-D-T (AF/TA) (R3350C)

LED915 6-500-450-01 LED CL-195SR-CD-T (SENS) (R3350)LED915 6-500-509-01 LED CL-165D/PG-D-T (SENS) (R3350C)LED916 6-500-450-01 LED CL-195SR-CD-T (6) (R3350)LED916 6-500-509-01 LED CL-165D/PG-D-T (6) (R3350C)LED917 6-500-450-01 LED CL-195SR-CD-T (5) (R3350)

LED917 6-500-509-01 LED CL-165D/PG-D-T (5) (R3350C)LED918 6-500-450-01 LED CL-195SR-CD-T (4) (R3350)LED918 6-500-509-01 LED CL-165D/PG-D-T (4) (R3350C)LED919 6-500-450-01 LED CL-195SR-CD-T (3) (R3350)LED919 6-500-509-01 LED CL-165D/PG-D-T (3) (R3350C)

LED920 6-500-450-01 LED CL-195SR-CD-T (2) (R3350)LED920 6-500-509-01 LED CL-165D/PG-D-T (2) (R3350C)LED921 6-500-450-01 LED CL-195SR-CD-T (1) (R3350)LED921 6-500-509-01 LED CL-165D/PG-D-T (1) (R3350C)LED922 6-500-450-01 LED CL-195SR-CD-T (DSPL) (R3350)

LED922 6-500-509-01 LED CL-165D/PG-D-T (DSPL) (R3350C)LED932 6-501-062-01 LED NSCW505CT-AST (LCD BACK LIGHT)LED961 6-500-450-01 LED CL-195SR-CD-T (DISC IN) (R3350)LED961 6-500-509-01 LED CL-165D/PG-D-T (DISC IN) (R3350C)

< RESISTOR >

LED931 1-216-174-00 RES-CHIP 100 5% 1/8W

< TRANSISTOR >

Q901 6-551-244-01 TRANSISTOR MUN2233T1GQ902 6-551-244-01 TRANSISTOR MUN2233T1G (R3350C)

KEY

Page 40: Sony Cdx r3350

40

CDX-R3350/R3350C

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

Q903 6-551-244-01 TRANSISTOR MUN2233T1G (R3350C)

< RESISTOR >

R901 1-216-819-11 METAL CHIP 680 5% 1/10WR902 1-216-819-11 METAL CHIP 680 5% 1/10WR903 1-216-819-11 METAL CHIP 680 5% 1/10WR904 1-216-821-11 METAL CHIP 1K 5% 1/10WR905 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

R906 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR907 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR911 1-216-819-11 METAL CHIP 680 5% 1/10WR912 1-216-819-11 METAL CHIP 680 5% 1/10WR913 1-216-819-11 METAL CHIP 680 5% 1/10W

R914 1-216-821-11 METAL CHIP 1K 5% 1/10WR915 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR916 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR917 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR918 1-216-827-11 METAL CHIP 3.3K 5% 1/10W

R919 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR920 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR921 1-216-833-11 METAL CHIP 10K 5% 1/10WR922 1-216-835-11 METAL CHIP 15K 5% 1/10WR924 1-216-864-11 SHORT CHIP 0

R925 1-216-815-11 METAL CHIP 330 5% 1/10WR926 1-216-809-11 METAL CHIP 100 5% 1/10WR927 1-216-809-11 METAL CHIP 100 5% 1/10WR928 1-216-864-11 SHORT CHIP 0 (R3350C)R929 1-216-033-00 RES-CHIP 220 5% 1/10W

(R3350C)

R929 1-216-037-00 RES-CHIP 330 5% 1/10W(R3350)

R930 1-216-033-00 RES-CHIP 220 5% 1/10W(R3350C)

R931 1-216-023-00 RES-CHIP 82 5% 1/10W(R3350C)

R931 1-216-031-00 RES-CHIP 180 5% 1/10W(R3350)

R932 1-216-029-00 RES-CHIP 150 5% 1/10W(R3350C)

R933 1-216-023-00 RES-CHIP 82 5% 1/10W(R3350C)

R933 1-216-031-00 RES-CHIP 180 5% 1/10W(R3350)

R934 1-216-029-00 RES-CHIP 150 5% 1/10W(R3350C)

R935 1-216-023-00 RES-CHIP 82 5% 1/10W(R3350C)

R935 1-216-031-00 RES-CHIP 180 5% 1/10W(R3350)

R936 1-216-029-00 RES-CHIP 150 5% 1/10W(R3350C)

R937 1-216-033-00 RES-CHIP 220 5% 1/10W(R3350C)

R937 1-216-037-00 RES-CHIP 330 5% 1/10W(R3350)

R938 1-216-033-00 RES-CHIP 220 5% 1/10W(R3350C)

R941 1-216-808-11 METAL CHIP 82 5% 1/10W

R942 1-216-808-11 METAL CHIP 82 5% 1/10WR943 1-216-808-11 METAL CHIP 82 5% 1/10W

R953 1-216-864-11 SHORT CHIP 0 (R3350)R961 1-216-817-11 METAL CHIP 470 5% 1/10WR962 1-216-864-11 SHORT CHIP 0R971 1-216-817-11 METAL CHIP 470 5% 1/10WR972 1-216-817-11 METAL CHIP 470 5% 1/10W

R976 1-216-864-11 SHORT CHIP 0R978 1-216-817-11 METAL CHIP 470 5% 1/10WR981 1-216-817-11 METAL CHIP 470 5% 1/10WR982 1-216-817-11 METAL CHIP 470 5% 1/10WR983 1-216-817-11 METAL CHIP 470 5% 1/10W

R984 1-216-864-11 SHORT CHIP 0R987 1-216-811-11 METAL CHIP 150 5% 1/10WR988 1-216-811-11 METAL CHIP 150 5% 1/10WR989 1-216-811-11 METAL CHIP 150 5% 1/10WR991 1-216-864-11 SHORT CHIP 0

R993 1-216-857-11 METAL CHIP 1M 5% 1/10WR994 1-216-821-11 METAL CHIP 1K 5% 1/10WR995 1-216-821-11 METAL CHIP 1K 5% 1/10WR996 1-216-821-11 METAL CHIP 1K 5% 1/10W

< SWITCH >

S900 1-786-653-11 SWITCH, TACTILE (OPEN/EJECT)S901 1-786-653-11 SWITCH, TACTILE (OPEN/EJECT)S902 1-786-653-11 SWITCH, TACTILE (OFF)S903 1-786-653-11 SWITCH, TACTILE (SOURCE)S904 1-786-653-11 SWITCH, TACTILE (VOLUME –)

S905 1-786-653-11 SWITCH, TACTILE (ATT)S906 1-786-653-11 SWITCH, TACTILE (VOLUME +)S907 1-786-653-11 SWITCH, TACTILE (MODE)S908 1-786-653-11 SWITCH, TACTILE (SEL)S910 1-786-653-11 SWITCH, TACTILE (EQ3)

S911 1-786-653-11 SWITCH, TACTILE (SEEK > M +)S912 1-786-653-11 SWITCH, TACTILE (SEEK – m .)S913 1-786-653-11 SWITCH, TACTILE (PTY) (R3350)S913 1-786-653-11 SWITCH, TACTILE (PTY/LIST) (R3350C)S914 1-786-653-11 SWITCH, TACTILE (AF/TA)

S915 1-786-653-11 SWITCH, TACTILE (SENS/BTM)S916 1-786-653-11 SWITCH, TACTILE (6)S917 1-786-653-11 SWITCH, TACTILE (5)S918 1-786-653-11 SWITCH, TACTILE (4/SHUF)S919 1-786-653-11 SWITCH, TACTILE (3/REP)

S920 1-786-653-11 SWITCH, TACTILE (2/GROUP +) (R3350)S920 1-786-653-11 SWITCH, TACTILE (2,GP/DISC +) (R3350C)S921 1-786-653-11 SWITCH, TACTILE (1/GROUP –) (R3350)S921 1-786-653-11 SWITCH, TACTILE (1,GP/DISC –) (R3350C)S922 1-786-653-11 SWITCH, TACTILE (DSPL)

S961 1-529-566-61 SWITCH, PUSH (1 KEY) (DOOR)*************************************************************

A-1086-104-A MAIN BOARD, COMPLETE (R3350)A-1086-106-A MAIN BOARD, COMPLETE (R3350C)

*********************

7-685-134-19 SCREW +P 2.6X8 TYPE2 NON-SLIT7-685-794-09 SCREW +PTT 2.6X10 (S)

< CAPACITOR >

C1 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC2 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

MAINKEY

Page 41: Sony Cdx r3350

41

CDX-R3350/R3350C

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

C3 1-126-963-11 ELECT 4.7uF 20% 50VC4 1-126-947-11 ELECT 47uF 20% 35VC5 1-126-947-11 ELECT 47uF 20% 35VC6 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC7 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C11 1-164-816-11 CERAMIC CHIP 220PF 2% 50VC12 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC13 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC51 1-126-947-11 ELECT 47uF 20% 35VC53 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C54 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC55 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC56 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC57 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC58 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C59 1-162-916-11 CERAMIC CHIP 12PF 5% 50VC60 1-162-916-11 CERAMIC CHIP 12PF 5% 50VC62 1-162-959-11 CERAMIC CHIP 330PF 5% 50VC301 1-128-551-11 ELECT 22uF 20% 63VC302 1-126-934-11 ELECT 220uF 20% 16V

C305 1-104-665-11 ELECT 100uF 20% 25VC306 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC308 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC309 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC310 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V

C312 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC330 1-163-251-11 CERAMIC CHIP 100PF 5% 50V

(R3350C)C331 1-163-251-11 CERAMIC CHIP 100PF 5% 50V

(R3350C)C343 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC401 1-126-964-11 ELECT 10uF 20% 50V

C402 1-126-960-11 ELECT 1uF 20% 50V(R3350C)

C403 1-126-960-11 ELECT 1uF 20% 50V(R3350C)

C404 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16VC405 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16VC406 1-126-960-11 ELECT 1uF 20% 50V

C407 1-126-960-11 ELECT 1uF 20% 50VC412 1-126-947-11 ELECT 47uF 20% 35VC413 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC431 1-126-791-11 ELECT 10uF 20% 35VC432 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16V

C434 1-163-251-11 CERAMIC CHIP 100PF 5% 50V(R3350C)

C441 1-126-791-11 ELECT 10uF 20% 35VC442 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16VC444 1-163-251-11 CERAMIC CHIP 100PF 5% 50V

(R3350C)C451 1-126-791-11 ELECT 10uF 20% 35V

C452 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16VC461 1-126-791-11 ELECT 10uF 20% 35VC462 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16VC471 1-126-791-11 ELECT 10uF 20% 35VC474 1-163-251-11 CERAMIC CHIP 100PF 5% 50V

C479 1-126-947-11 ELECT 47uF 20% 35VC481 1-126-791-11 ELECT 10uF 20% 35VC484 1-163-251-11 CERAMIC CHIP 100PF 5% 50V

C501 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC502 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC503 1-104-665-11 ELECT 100uF 20% 25VC504 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC507 1-162-917-11 CERAMIC CHIP 15PF 5% 50V

C508 1-162-917-11 CERAMIC CHIP 15PF 5% 50VC509 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC510 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC511 1-104-665-11 ELECT 100uF 20% 25VC512 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C513 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC514 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC516 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC519 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC531 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C550 1-216-864-11 SHORT CHIP 0 (R3350)C562 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC580 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

(R3350C)C581 1-126-935-11 ELECT 470uF 20% 16V

(R3350C)C582 1-165-319-11 CERAMIC CHIP 0.1uF 50V

(R3350C)

C601 1-131-868-81 ELECT 3300uF 20% 16VC602 1-165-319-11 CERAMIC CHIP 0.1uF 50VC609 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC617 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC618 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50V

C622 1-126-916-11 ELECT 1000uF 20% 6.3V(R3350)

C623 1-126-916-11 ELECT 1000uF 20% 6.3VC631 1-126-960-11 ELECT 1uF 20% 50VC681 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

(R3350C)C682 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

(R3350C)

C683 1-126-964-11 ELECT 10uF 20% 50V(R3350C)

C750 1-115-340-11 CERAMIC CHIP 0.22uF 10% 25VC751 1-115-340-11 CERAMIC CHIP 0.22uF 10% 25VC752 1-126-947-11 ELECT 47uF 20% 35VC753 1-128-551-11 ELECT 22uF 20% 63V

C754 1-126-961-11 ELECT 2.2uF 20% 50VC755 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC756 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16VC758 1-126-964-11 ELECT 10uF 20% 50VC759 1-126-964-11 ELECT 10uF 20% 50V

C760 1-104-665-11 ELECT 100uF 20% 25VC761 1-126-964-11 ELECT 10uF 20% 50VC763 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10VC764 1-115-340-11 CERAMIC CHIP 0.22uF 10% 25VC765 1-115-340-11 CERAMIC CHIP 0.22uF 10% 25V

C769 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10VC770 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10VC771 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10VC774 1-115-340-11 CERAMIC CHIP 0.22uF 10% 25VC775 1-115-340-11 CERAMIC CHIP 0.22uF 10% 25V

C776 1-115-340-11 CERAMIC CHIP 0.22uF 10% 25V

MAIN

Page 42: Sony Cdx r3350

42

CDX-R3350/R3350C

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

< CONNECTOR >

CN580 1-580-907-41 PLUG, CONNECTOR (BUS CONTROL IN)(R3350C)

CN601 1-774-701-21 PIN, CONNECTOR 16PCN701 1-794-311-21 PLUG, CONNECTOR 12PCNP301 1-817-536-11 CONNECTOR, BOARD TO BOARD 28P

< DIODE >

D1 8-719-036-94 DIODE RD5.6SB-T1D479 8-719-081-97 DIODE MMDL914T1D501 8-719-050-37 DIODE M1MA152WA-T1D502 6-500-137-01 DIODE BAT54HT1D510 6-501-013-01 DIODE BAT54ALT1G

D511 6-501-051-01 DIODE BAT54CLT1GD512 6-501-051-01 DIODE BAT54CLT1GD580 8-719-056-82 DIODE UDZ-TE-17-6.2B (R3350C)D580 8-719-056-83 DIODE UDZ-TE-17-6.8B (R3350)D581 8-719-056-93 DIODE UDZ-TE-17-18B

D582 8-719-056-93 DIODE UDZ-TE-17-18B (R3350C)D583 8-719-072-70 DIODE MA2ZD14001S0 (R3350C)D584 8-719-056-93 DIODE UDZ-TE-17-18B (R3350C)D601 8-719-049-38 DIODE 1N5404TUD609 8-719-056-83 DIODE UDZ-TE-17-6.8B

D617 8-719-056-93 DIODE UDZ-TE-17-18BD651 8-719-056-93 DIODE UDZ-TE-17-18BD701 6-500-886-01 DIODE RSA6.1ENTRD702 6-500-886-01 DIODE RSA6.1ENTRD719 8-719-056-93 DIODE UDZ-TE-17-18B

D751 6-500-522-01 DIODE 10EDB40-TA1B2D752 6-500-522-01 DIODE 10EDB40-TA1B2D753 6-500-522-01 DIODE 10EDB40-TA1B2D754 6-500-522-01 DIODE 10EDB40-TA1B2D755 6-500-522-01 DIODE 10EDB40-TA1B2

D756 6-500-522-01 DIODE 10EDB40-TA1B2D757 6-500-522-01 DIODE 10EDB40-TA1B2D758 6-500-522-01 DIODE 10EDB40-TA1B2D759 6-500-522-01 DIODE 10EDB40-TA1B2D760 6-500-522-01 DIODE 10EDB40-TA1B2

D761 6-500-522-01 DIODE 10EDB40-TA1B2D762 6-500-522-01 DIODE 10EDB40-TA1B2D763 8-719-081-97 DIODE MMDL914T1D764 8-719-081-97 DIODE MMDL914T1

< FERRITE BEAD >

FB1 1-469-844-11 INDUCTOR 2.2uHFB302 1-469-876-11 INDUCTOR, FERRITE BEADFB303 1-469-876-11 INDUCTOR, FERRITE BEADFB304 1-500-245-11 INDUCTOR, FERRITE BEADFB305 1-216-295-11 SHORT CHIP 0 (R3350C)

FB305 1-500-245-11 INDUCTOR, FERRITE BEAD (R3350)FB307 1-469-876-11 INDUCTOR, FERRITE BEADFB308 1-500-245-11 INDUCTOR, FERRITE BEADFB309 1-216-864-11 SHORT CHIP 0FB310 1-216-864-11 SHORT CHIP 0

FB501 1-500-245-11 INDUCTOR, FERRITE BEADFB561 1-216-864-11 SHORT CHIP 0 (R3350C)FB562 1-216-864-11 SHORT CHIP 0FB563 1-216-864-11 SHORT CHIP 0

FB603 1-216-295-11 SHORT CHIP 0FB604 1-216-295-11 SHORT CHIP 0FB605 1-216-864-11 SHORT CHIP 0FB606 1-414-595-11 INDUCTOR, FERRITE BEAD

< IC >

IC51 6-803-747-01 IC TDA7333013TRIC401 6-705-372-01 IC BD3808FS-FE2IC501 6-805-066-01 IC MB90488BPF-G-122-BNDE1IC580 6-703-884-01 IC BA8271F-E2 (R3350C)IC602 8-759-659-13 IC PST3428UL

IC681 6-705-373-01 IC MM3123DPLE (R3350C)IC750 6-705-359-02 IC TDA8588AJ/N2/R1 (R3350C)IC750 6-705-360-02 IC TDA8588BJ/N2/R1 (R3350)

< JACK >

J1 1-815-185-13 JACK (ANTENNA)J330 1-774-698-11 JACK, PIN 2P (AUDIO OUT REAR) (R3350)J330 1-774-700-11 JACK, PIN 6P (BUS AUDIO IN,

AUDIO OUT REAR/FRONT) (R3350C)J561 1-566-822-41 JACK (REMOTE IN)

< JUMPER RESISTOR >

JC1 1-216-864-11 SHORT CHIP 0JC5 1-216-864-11 SHORT CHIP 0JC12 1-216-864-11 SHORT CHIP 0JC401 1-216-864-11 SHORT CHIP 0JC445 1-216-296-11 SHORT CHIP 0

JC446 1-216-864-11 SHORT CHIP 0JC501 1-216-296-11 SHORT CHIP 0JC502 1-216-864-11 SHORT CHIP 0 (R3350C)JC503 1-216-296-11 SHORT CHIP 0JC504 1-216-864-11 SHORT CHIP 0

JC505 1-216-296-11 SHORT CHIP 0JC506 1-216-864-11 SHORT CHIP 0JC511 1-216-296-11 SHORT CHIP 0JC527 1-216-821-11 METAL CHIP 1K 5% 1/10WJC533 1-216-864-11 SHORT CHIP 0 (R3350)

JC681 1-216-864-11 SHORT CHIP 0 (R3350)JC753 1-216-296-11 SHORT CHIP 0JC754 1-216-296-11 SHORT CHIP 0JC755 1-216-296-11 SHORT CHIP 0JC756 1-216-864-11 SHORT CHIP 0

< RESISTOR >

JW52 1-249-425-11 CARBON 4.7K 5% 1/4W

< COIL >

L1 1-469-844-11 INDUCTOR 2.2uHL51 1-216-295-11 SHORT CHIP 0L301 1-216-295-11 SHORT CHIP 0L501 1-500-245-11 INDUCTOR, FERRITE BEADL601 1-456-617-11 COIL, CHOKE

< TRANSISTOR >

Q1 8-729-920-85 TRANSISTOR 2SD1664-QRQ22 8-729-421-19 TRANSISTOR UN2213Q51 8-729-026-49 TRANSISTOR 2SA1037AK-T146-RQ431 6-551-070-01 TRANSISTOR KRC283S-B-RPK/P

MAIN

Page 43: Sony Cdx r3350

43

CDX-R3350/R3350C

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

Q441 6-551-070-01 TRANSISTOR KRC283S-B-RPK/PQ451 6-551-070-01 TRANSISTOR KRC283S-B-RPK/PQ461 6-551-070-01 TRANSISTOR KRC283S-B-RPK/PQ471 6-551-070-01 TRANSISTOR KRC283S-B-RPK/PQ478 8-729-421-19 TRANSISTOR UN2213

Q479 8-729-424-08 TRANSISTOR UN2111Q481 6-551-070-01 TRANSISTOR KRC283S-B-RPK/PQ580 8-729-421-22 TRANSISTOR UN2211Q581 8-729-421-19 TRANSISTOR UN2213 (R3350)Q582 8-729-010-25 TRANSISTOR MSD601-RT1 (R3350)

Q586 8-729-424-08 TRANSISTOR UN2111 (R3350C)Q587 8-729-047-76 TRANSISTOR FMC2A-T148 (R3350C)Q631 8-729-010-25 TRANSISTOR MSD601-RT1Q651 8-729-010-25 TRANSISTOR MSD601-RT1Q664 8-729-424-08 TRANSISTOR UN2111

< RESISTOR >

R1 1-216-821-11 METAL CHIP 1K 5% 1/10WR2 1-414-595-11 INDUCTOR, FERRITE BEADR3 1-414-595-11 INDUCTOR, FERRITE BEADR4 1-216-839-11 METAL CHIP 33K 5% 1/10WR5 1-216-843-11 METAL CHIP 68K 5% 1/10W

R6 1-216-839-11 METAL CHIP 33K 5% 1/10WR7 1-216-843-11 METAL CHIP 68K 5% 1/10WR8 1-216-839-11 METAL CHIP 33K 5% 1/10WR9 1-216-843-11 METAL CHIP 68K 5% 1/10WR12 1-216-864-11 SHORT CHIP 0

R13 1-216-864-11 SHORT CHIP 0R29 1-216-809-11 METAL CHIP 100 5% 1/10WR51 1-216-797-11 METAL CHIP 10 5% 1/10WR52 1-216-797-11 METAL CHIP 10 5% 1/10WR53 1-414-595-11 INDUCTOR, FERRITE BEAD

R54 1-216-833-11 METAL CHIP 10K 5% 1/10WR55 1-216-864-11 SHORT CHIP 0R56 1-414-595-11 INDUCTOR, FERRITE BEADR57 1-414-595-11 INDUCTOR, FERRITE BEADR58 1-414-595-11 INDUCTOR, FERRITE BEAD

R59 1-216-833-11 METAL CHIP 10K 5% 1/10WR60 1-216-833-11 METAL CHIP 10K 5% 1/10WR61 1-216-821-11 METAL CHIP 1K 5% 1/10WR301 1-216-821-11 METAL CHIP 1K 5% 1/10WR302 1-216-821-11 METAL CHIP 1K 5% 1/10W

R330 1-216-821-11 METAL CHIP 1K 5% 1/10W(R3350C)

R331 1-216-821-11 METAL CHIP 1K 5% 1/10W(R3350C)

R332 1-216-833-11 METAL CHIP 10K 5% 1/10W(R3350C)

R333 1-216-833-11 METAL CHIP 10K 5% 1/10W(R3350C)

R335 1-216-864-11 SHORT CHIP 0

R401 1-216-789-11 METAL CHIP 2.2 5% 1/10WR405 1-218-881-11 METAL CHIP 27K 0.5% 1/10WR406 1-216-809-11 METAL CHIP 100 5% 1/10WR407 1-216-809-11 METAL CHIP 100 5% 1/10WR408 1-216-809-11 METAL CHIP 100 5% 1/10W

R409 1-216-809-11 METAL CHIP 100 5% 1/10WR410 1-216-809-11 METAL CHIP 100 5% 1/10WR411 1-216-809-11 METAL CHIP 100 5% 1/10W

R431 1-216-809-11 METAL CHIP 100 5% 1/10WR432 1-216-841-11 METAL CHIP 47K 5% 1/10WR433 1-216-864-11 SHORT CHIP 0R441 1-216-809-11 METAL CHIP 100 5% 1/10WR442 1-216-841-11 METAL CHIP 47K 5% 1/10W

R443 1-216-864-11 SHORT CHIP 0R451 1-216-809-11 METAL CHIP 100 5% 1/10WR452 1-216-841-11 METAL CHIP 47K 5% 1/10WR453 1-216-864-11 SHORT CHIP 0R461 1-216-809-11 METAL CHIP 100 5% 1/10W

R462 1-216-841-11 METAL CHIP 47K 5% 1/10WR463 1-216-864-11 SHORT CHIP 0R471 1-216-809-11 METAL CHIP 100 5% 1/10WR472 1-216-841-11 METAL CHIP 47K 5% 1/10WR479 1-216-805-11 METAL CHIP 47 5% 1/10W

R481 1-216-809-11 METAL CHIP 100 5% 1/10WR482 1-216-841-11 METAL CHIP 47K 5% 1/10WR501 1-216-864-11 SHORT CHIP 0R502 1-216-809-11 METAL CHIP 100 5% 1/10WR503 1-216-809-11 METAL CHIP 100 5% 1/10W

R504 1-218-871-11 METAL CHIP 10K 0.5% 1/10WR505 1-218-871-11 METAL CHIP 10K 0.5% 1/10WR506 1-216-845-11 METAL CHIP 100K 5% 1/10W

(R3350)R508 1-216-811-11 METAL CHIP 150 5% 1/10WR509 1-216-864-11 SHORT CHIP 0

R510 1-216-809-11 METAL CHIP 100 5% 1/10WR511 1-216-809-11 METAL CHIP 100 5% 1/10WR512 1-216-809-11 METAL CHIP 100 5% 1/10WR513 1-216-845-11 METAL CHIP 100K 5% 1/10WR514 1-216-845-11 METAL CHIP 100K 5% 1/10W

R517 1-216-841-11 METAL CHIP 47K 5% 1/10WR518 1-216-864-11 SHORT CHIP 0R519 1-216-845-11 METAL CHIP 100K 5% 1/10WR520 1-216-845-11 METAL CHIP 100K 5% 1/10W

(R3350C)R521 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R522 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR528 1-216-845-11 METAL CHIP 100K 5% 1/10WR529 1-216-809-11 METAL CHIP 100 5% 1/10WR531 1-216-845-11 METAL CHIP 100K 5% 1/10WR532 1-216-845-11 METAL CHIP 100K 5% 1/10W

R533 1-216-833-11 METAL CHIP 10K 5% 1/10WR534 1-216-833-11 METAL CHIP 10K 5% 1/10WR535 1-216-833-11 METAL CHIP 10K 5% 1/10W

(R3350)R536 1-216-845-11 METAL CHIP 100K 5% 1/10W

(R3350)R537 1-216-845-11 METAL CHIP 100K 5% 1/10W

R539 1-216-821-11 METAL CHIP 1K 5% 1/10WR540 1-216-845-11 METAL CHIP 100K 5% 1/10W

(R3350)R541 1-216-845-11 METAL CHIP 100K 5% 1/10W

(R3350)R542 1-216-821-11 METAL CHIP 1K 5% 1/10WR543 1-216-821-11 METAL CHIP 1K 5% 1/10W

R544 1-216-821-11 METAL CHIP 1K 5% 1/10WR547 1-216-864-11 SHORT CHIP 0

MAIN

Page 44: Sony Cdx r3350

44

CDX-R3350/R3350C

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

R548 1-216-845-11 METAL CHIP 100K 5% 1/10W(R3350C)

R550 1-216-845-11 METAL CHIP 100K 5% 1/10W(R3350)

R551 1-216-845-11 METAL CHIP 100K 5% 1/10WR552 1-216-845-11 METAL CHIP 100K 5% 1/10WR553 1-216-839-11 METAL CHIP 33K 5% 1/10W

(R3350C)

R554 1-216-849-11 METAL CHIP 220K 5% 1/10W(R3350C)

R555 1-216-849-11 METAL CHIP 220K 5% 1/10W(R3350C)

R557 1-216-809-11 METAL CHIP 100 5% 1/10WR561 1-216-845-11 METAL CHIP 100K 5% 1/10WR563 1-216-845-11 METAL CHIP 100K 5% 1/10W

R564 1-216-845-11 METAL CHIP 100K 5% 1/10WR565 1-216-845-11 METAL CHIP 100K 5% 1/10WR566 1-216-845-11 METAL CHIP 100K 5% 1/10WR567 1-216-845-11 METAL CHIP 100K 5% 1/10WR569 1-216-809-11 METAL CHIP 100 5% 1/10W

R570 1-216-817-11 METAL CHIP 470 5% 1/10WR573 1-216-845-11 METAL CHIP 100K 5% 1/10WR574 1-216-845-11 METAL CHIP 100K 5% 1/10WR576 1-216-845-11 METAL CHIP 100K 5% 1/10WR578 1-216-821-11 METAL CHIP 1K 5% 1/10W

R580 1-216-809-11 METAL CHIP 100 5% 1/10W(R3350C)

R581 1-216-809-11 METAL CHIP 100 5% 1/10W(R3350C)

R582 1-216-821-11 METAL CHIP 1K 5% 1/10W(R3350)

R582 1-216-835-11 METAL CHIP 15K 5% 1/10W(R3350C)

R583 1-216-821-11 METAL CHIP 1K 5% 1/10W

R584 1-216-841-11 METAL CHIP 47K 5% 1/10WR585 1-216-849-11 METAL CHIP 220K 5% 1/10W

(R3350)R587 1-216-821-11 METAL CHIP 1K 5% 1/10W

(R3350C)R588 1-216-821-11 METAL CHIP 1K 5% 1/10W

(R3350C)R590 1-216-864-11 SHORT CHIP 0

R591 1-216-829-11 METAL CHIP 4.7K 5% 1/10W(R3350C)

R601 1-216-845-11 METAL CHIP 100K 5% 1/10WR609 1-216-821-11 METAL CHIP 1K 5% 1/10WR631 1-249-425-11 CARBON 4.7K 5% 1/4WR632 1-216-841-11 METAL CHIP 47K 5% 1/10W

R633 1-216-841-11 METAL CHIP 47K 5% 1/10WR634 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR636 1-216-845-11 METAL CHIP 100K 5% 1/10WR651 1-216-821-11 METAL CHIP 1K 5% 1/10WR652 1-216-841-11 METAL CHIP 47K 5% 1/10W

R653 1-216-833-11 METAL CHIP 10K 5% 1/10WR654 1-216-833-11 METAL CHIP 10K 5% 1/10WR671 1-216-809-11 METAL CHIP 100 5% 1/10WR672 1-216-833-11 METAL CHIP 10K 5% 1/10WR673 1-218-871-11 METAL CHIP 10K 0.5% 1/10W

R674 1-216-845-11 METAL CHIP 100K 5% 1/10WR675 1-216-821-11 METAL CHIP 1K 5% 1/10W

R676 1-216-821-11 METAL CHIP 1K 5% 1/10WR677 1-216-821-11 METAL CHIP 1K 5% 1/10WR678 1-216-821-11 METAL CHIP 1K 5% 1/10W

(R3350C)R679 1-216-821-11 METAL CHIP 1K 5% 1/10WR681 1-216-864-11 SHORT CHIP 0

R704 1-216-864-11 SHORT CHIP 0R705 1-216-809-11 METAL CHIP 100 5% 1/10WR752 1-216-811-11 METAL CHIP 150 5% 1/10WR756 1-216-841-11 METAL CHIP 47K 5% 1/10W

< SWITCH >

S702 1-692-431-21 SWITCH, TACTILE (RESET)

< THERMISTOR (POSITIVE) >

TH580 1-803-350-21 THERMISTOR, POSITIVE (R3350C)

< TUNER >

TU1 A-3220-961-A TUNER UNIT (TUX-032)

< VIBRATOR >

X51 1-813-532-11 VIBRATOR, CRYSTAL (8.664MHz)X501 1-813-524-21 VIBRATOR, CERAMIC (18.432MHz)X502 1-813-202-11 VIBRATOR, CRYSTAL (32.768kHz)

*************************************************************

SENSOR BOARD**************

< SWITCH >

SW2 1-529-566-61 SWITCH, PUSH (1 KEY) (SELF)SW3 1-529-566-61 SWITCH, PUSH (1 KEY) (DISC IN)

*************************************************************

A-1082-772-A SERVO BOARD, COMPLETE**********************

< CAPACITOR >

C4 1-100-567-81 CERAMIC CHIP 0.01uF 10% 25VC5 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC6 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC7 1-100-567-81 CERAMIC CHIP 0.01uF 10% 25VC9 1-104-609-11 ELECT CHIP 100uF 20% 4V

C10 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC13 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC16 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC17 1-162-925-11 CERAMIC CHIP 68PF 5% 50VC18 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10V

C19 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC20 1-164-245-11 CERAMIC CHIP 0.015uF 10% 25VC21 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16VC22 1-100-567-81 CERAMIC CHIP 0.01uF 10% 25VC23 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10V

C24 1-100-567-81 CERAMIC CHIP 0.01uF 10% 25VC27 1-164-677-11 CERAMIC CHIP 0.033uF 10% 16VC28 1-100-567-81 CERAMIC CHIP 0.01uF 10% 25VC29 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC31 1-164-245-11 CERAMIC CHIP 0.015uF 10% 25V

MAIN SERVOSENSOR

Page 45: Sony Cdx r3350

45

CDX-R3350/R3350C

C32 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC33 1-164-677-11 CERAMIC CHIP 0.033uF 10% 16VC34 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC35 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC36 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10V

C37 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC38 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC39 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC40 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC41 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V

C42 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC43 1-100-567-81 CERAMIC CHIP 0.01uF 10% 25VC45 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC47 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC48 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10V

C49 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC51 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC52 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC53 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC57 1-115-416-11 CERAMIC CHIP 0.001uF 5% 25V

C58 1-100-567-81 CERAMIC CHIP 0.01uF 10% 25VC59 1-112-195-11 ELECT 47uF 20% 4VC60 1-112-195-11 ELECT 47uF 20% 4VC61 1-126-208-21 ELECT CHIP 47uF 20% 4VC62 1-100-567-81 CERAMIC CHIP 0.01uF 10% 25V

C64 1-100-567-81 CERAMIC CHIP 0.01uF 10% 25VC65 1-100-567-81 CERAMIC CHIP 0.01uF 10% 25VC67 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3VC72 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3VC80 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3V

C101 1-100-567-81 CERAMIC CHIP 0.01uF 10% 25VC102 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC103 1-100-567-81 CERAMIC CHIP 0.01uF 10% 25VC105 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC106 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10V

< CONNECTOR >

CN1 1-691-380-21 CONNECTOR, FFC/FPC 16PCN2 1-817-275-21 CONNECTOR, BOARD TO BOARD 28P

< JUMPER RESISTOR >

FB2 1-216-864-11 SHORT CHIP 0FB3 1-216-864-11 SHORT CHIP 0FB4 1-216-864-11 SHORT CHIP 0

< IC >

IC1 6-707-327-01 IC BA5968FP-E2IC2 6-707-328-01 IC TC94A60MFG-301IC3 6-805-086-02 IC MB90487APFV-G-142-BNDE1IC6 6-705-364-01 IC R1114N151D-TR-FA

< TRANSISTOR >

Q1 8-729-904-87 TRANSISTOR 2SB1197K-RQ2 8-729-904-87 TRANSISTOR 2SB1197K-RQ3 8-729-928-90 TRANSISTOR DTC114EE

< RESISTOR >

R1 1-218-941-81 RES-CHIP 100 5% 1/16W

Ref. No. Part No. Description Remark

R2 1-208-699-11 METAL CHIP 4.7K 0.5% 1/16WR3 1-208-912-11 METAL CHIP 11K 0.5% 1/16WR4 1-218-969-11 RES-CHIP 22K 5% 1/16WR5 1-218-969-11 RES-CHIP 22K 5% 1/16WR6 1-218-929-11 RES-CHIP 10 5% 1/16W

R7 1-218-929-11 RES-CHIP 10 5% 1/16WR8 1-218-967-11 RES-CHIP 15K 5% 1/16WR9 1-218-967-11 RES-CHIP 15K 5% 1/16WR10 1-218-965-11 RES-CHIP 10K 5% 1/16WR11 1-218-965-11 RES-CHIP 10K 5% 1/16W

R12 1-218-977-11 RES-CHIP 100K 5% 1/16WR13 1-218-969-11 RES-CHIP 22K 5% 1/16WR16 1-218-967-11 RES-CHIP 15K 5% 1/16WR17 1-218-973-11 RES-CHIP 47K 5% 1/16WR19 1-218-967-11 RES-CHIP 15K 5% 1/16W

R21 1-218-973-11 RES-CHIP 47K 5% 1/16WR22 1-218-990-11 SHORT CHIP 0R23 1-218-979-11 RES-CHIP 150K 5% 1/16WR24 1-218-962-11 RES-CHIP 5.6K 5% 1/16WR25 1-218-990-11 SHORT CHIP 0

R26 1-218-941-81 RES-CHIP 100 5% 1/16WR28 1-218-947-11 RES-CHIP 330 5% 1/16WR40 1-218-941-81 RES-CHIP 100 5% 1/16WR41 1-218-977-11 RES-CHIP 100K 5% 1/16WR42 1-218-977-11 RES-CHIP 100K 5% 1/16W

R43 1-218-941-81 RES-CHIP 100 5% 1/16WR44 1-218-941-81 RES-CHIP 100 5% 1/16WR45 1-218-989-11 RES-CHIP 1M 5% 1/16WR46 1-218-947-11 RES-CHIP 330 5% 1/16WR47 1-218-977-11 RES-CHIP 100K 5% 1/16W

R48 1-218-941-81 RES-CHIP 100 5% 1/16WR49 1-218-941-81 RES-CHIP 100 5% 1/16WR50 1-218-941-81 RES-CHIP 100 5% 1/16WR51 1-218-941-81 RES-CHIP 100 5% 1/16WR52 1-218-945-11 RES-CHIP 220 5% 1/16W

R53 1-218-941-81 RES-CHIP 100 5% 1/16WR54 1-218-941-81 RES-CHIP 100 5% 1/16WR55 1-218-977-11 RES-CHIP 100K 5% 1/16WR56 1-218-941-81 RES-CHIP 100 5% 1/16WR57 1-218-941-81 RES-CHIP 100 5% 1/16W

R58 1-218-941-81 RES-CHIP 100 5% 1/16WR59 1-218-977-11 RES-CHIP 100K 5% 1/16WR60 1-218-977-11 RES-CHIP 100K 5% 1/16WR61 1-218-977-11 RES-CHIP 100K 5% 1/16WR62 1-218-977-11 RES-CHIP 100K 5% 1/16W

R63 1-218-977-11 RES-CHIP 100K 5% 1/16WR64 1-218-977-11 RES-CHIP 100K 5% 1/16WR65 1-218-941-81 RES-CHIP 100 5% 1/16WR66 1-218-941-81 RES-CHIP 100 5% 1/16W

R67 1-218-941-81 RES-CHIP 100 5% 1/16WR68 1-218-941-81 RES-CHIP 100 5% 1/16WR69 1-218-941-81 RES-CHIP 100 5% 1/16WR70 1-218-941-81 RES-CHIP 100 5% 1/16WR71 1-220-804-11 RES-CHIP 2.2M 5% 1/16W

R72 1-218-941-81 RES-CHIP 100 5% 1/16WR73 1-218-973-11 RES-CHIP 47K 5% 1/16WR74 1-218-941-81 RES-CHIP 100 5% 1/16WR77 1-218-941-81 RES-CHIP 100 5% 1/16W

Ref. No. Part No. Description Remark

SERVO

Page 46: Sony Cdx r3350

46

CDX-R3350/R3350C

R78 1-218-941-81 RES-CHIP 100 5% 1/16WR80 1-218-941-81 RES-CHIP 100 5% 1/16WR81 1-218-973-11 RES-CHIP 47K 5% 1/16WR82 1-218-973-11 RES-CHIP 47K 5% 1/16WR83 1-218-973-11 RES-CHIP 47K 5% 1/16W

R84 1-218-953-11 RES-CHIP 1K 5% 1/16WR86 1-218-969-11 RES-CHIP 22K 5% 1/16WR90 1-218-941-81 RES-CHIP 100 5% 1/16WR91 1-218-941-81 RES-CHIP 100 5% 1/16WR100 1-220-200-81 RES-CHIP 30K 5% 1/16W

R101 1-218-971-11 RES-CHIP 33K 5% 1/16WR112 1-218-990-11 SHORT CHIP 0R113 1-218-990-11 SHORT CHIP 0R116 1-218-977-11 RES-CHIP 100K 5% 1/16WR117 1-218-977-11 RES-CHIP 100K 5% 1/16W

R118 1-218-977-11 RES-CHIP 100K 5% 1/16WR119 1-218-977-11 RES-CHIP 100K 5% 1/16WR120 1-218-990-11 SHORT CHIP 0R121 1-218-990-11 SHORT CHIP 0R122 1-218-990-11 SHORT CHIP 0

R123 1-218-990-11 SHORT CHIP 0R125 1-218-941-81 RES-CHIP 100 5% 1/16WR126 1-218-941-81 RES-CHIP 100 5% 1/16WR127 1-218-941-81 RES-CHIP 100 5% 1/16WR128 1-218-941-81 RES-CHIP 100 5% 1/16W

R131 1-216-864-11 SHORT CHIP 0R132 1-218-962-11 RES-CHIP 5.6K 5% 1/16W

< SWITCH >

SW1 1-529-565-61 SWITCH, PUSH (1 KEY) (DOWN)

< VIBRATOR >

X1 1-813-371-21 VIBRATOR, CERAMIC (12MHz)X2 1-795-561-21 VIBRATOR, CERAMIC (16.9344MHz)

*************************************************************

MISCELLANEOUS***************

7 1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER)0153 8-820-207-12 OPTICAL PICK-UP (KSS1000E/K1RP)

154 A-1075-645-A CHASSIS (OP) SUB ASSY (including M901)FU601 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10AM902 A-3372-447-A MOTOR ASSY, SL (SLED)

M903 A-1075-643-A MOTOR ASSY, LE (LOADING)SW4 1-571-099-11 SWITCH (1 KEY) (LIMIT)

*************************************************************

ACCESSORIES************

1-479-077-11 REMOTE COMMANDER (RM-X151)2-515-510-21 MANUAL, INSTRUCTION (ENGLISH,GERMAN,

FRENCH,ITALIAN,DUTCH)2-548-729-01 LID, BATTERY CASE (for RM-X151)2-560-438-21 MANUAL, INSTRUCTION, INSTALL (ENGLISH,

GERMAN,FRENCH,ITALIAN,DUTCH)X-3385-071-1 CASE ASSY (for FRONT PANEL)

*************************************************************

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

PARTS FOR INSTALLATION AND CONNECTIONS***************************************

301 X-3382-647-1 FRAME ASSY, FITTING302 X-3382-926-1 SCREW ASSY (BS), FITTING303 3-349-410-11 BUSHING304 2-318-513-01 COLLAR305 3-246-471-01 KEY (FRAME)

306 1-465-459-31 ADAPTOR, ANTENNA307 1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER)

SERVO

The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.

301 302

304

303

306

307

305

× 2