coca cola
TRANSCRIPT
BY :
• PUNIT KAPOOR
• PALAK SOI
• MODITA KACHRU
• ANNEZ SHREEN
• KUNAL BHASIN
• SUMIT SINGH RASYAL
• VIVEK SHARMA
HISTORY OF HCCBPL:-
• The Hindustan Coca-Cola Beverages Company Pvt. Ltd. was established in the year 1999. The plant of HCCBPL is situated at Kaladera which is spread over a massive area of 20 acres of land. It’s a subsidiary of Coca- Cola India. HCCBPL, Jaipur has a total of three lines for manufacturing of cold drinks, out of which two lines are for refillable glass bottles (RGB) and one for PET (Polyethylene terepthalate) bottles.
ENGINEERING SECTION:-
WATER TREATMENT
SRYUP ROOM
BLOWING
BOTTLING
PACKAGING AND LABELING
EFFECTIVE TREATMENT PROCESS
DG ROOM AND BOILERS
NEED OF WATER
TREATMENT
Untreated Water:
is unhealthy for humans, pets, and wildlife.
allows bacteria, viruses, and other disease-causing
pathogens to enter groundwater and surface water.
hepatitis, dysentery, and other diseases may result from
bacteria and viruses in drinking water.
can raise the nitrate levels in groundwater which affects
the ability of an infant's blood to carry oxygen, a condition
called methemoglobinemia (blue-baby syndrome).
Screening
The process of removal of large debris such as
sticks, leaves, trash and other large particles
which may interfere with subsequent
purification steps.
It removes debris which may clog the pumps
and may cause problems in water treatment.
•The efficiency of the screening operation depends of the spacing between screen bars:•Fine screening, for a spacing under 10 mm•Medium screening, for spacing of 10 to 40 mm•Coarse screening, for spacing of over 40 mm
Coagulation/Flocculation
“Coagulation” means a reduction in the forceswhich tend to keep suspended particles apart.
The joining together of small particles into larger, settleable and filterable particles is “flocculation.”
The coagulants include:
Ferrous Sulphate
lime
Sedimentation
It occurs in sedimentation basin or clarifier which is a large tank, allowing flocs to settle to the bottom.
Sedimentation basins may be rectangular, where water flows from end to end, or
circular where flow is from the centre outward.
The minimum clarifier retention time is normally 2- 4 hours.
Filtration
It is the removal of particulate impurities and
floc from the water being treated.
It considerably reduces presence of bacteria in water.
The most common type of filter is
Slow Sand Filter.
Disinfection
It is the treatment by which disease producing bacteria
and other micro-organisms present in water are killed.
Disinfectants cause:• Damage to cell wall of micro-organisms which leads to cell
lysis and death.• Alteration of cell permeability which causes outflow of
vital nutrients such as nitrogen and phosphorus.
Two types of disinfection on the whole is used • CHLORINE DISINFECTION• UV DISINFECTION